Abstract:Highlights • A new KHI PVCap- co -TBA was synthesized and evaluated in different hydrate forming systems. • The relationship between the dosage of KHI and the inhibition performance was analyzed. • PPG was proposed as a good synergist for PVCap- co -TBA with concentration of 1.0 wt%. Low dosage kinetic hydrate inhibitors (KHIs) are a kind of alternative chemical additives to high dosage thermodynamic inhibitors for preventing gas hydrate formation in oil & gas production wells and transportation pipelines. In this paper, a new KHI, poly (N-vinyl caprolactam)- co -tert-butyl acrylate (PVCap- co -TBA), was successfully synthesized with N-vinyl caprolactam (NVCap) and tert-butyl acrylate. The kinetic inhibition performances of PVCap- co -TBA on the formations of both structure I methane hydrate and structure II natural gas hydrate were investigated by measuring the onset times of hydrate formation under different conditions and compared with commercial KHIs such as PVP, PVCap and inhibex 501. The results indicated that PVCap- co -TBA outperformed these widely applied inhibitors for both structure I and structure II hydrates. At the same dosage of KHI, the maximum tolerable degree of subcooling under which the onset time of hydrate formation exceeded 24 hours for structure I hydrate was much lower than that for structure II hydrate. The inhibition strength increased with the increasing dosage of PVCap-co-TBA; The maximum tolerable degree of subcooling for the natural gas hydrate is more than 10 K when the dosage was higher than 0.5% (mass) while it achieved 12 K when that dosage rose to 0.75% (mass). Additionally, we found polypropylene glycol could be used as synergist at the dosage of 1.0% (mass) or so, under which the kinetic inhibition performance of PVCap- co -TBA could be improved significantly. All evaluation results demonstrated that PVCap-co-TBA was a very promising KHI and a competitive alternative to the existing commercial KHIs. Graphical abstract Download : Download high-res image (34KB) Download : Download full-size image

Comparing the Kinetic Hydrate Inhibition Performance of Linear versus Branched Polymers

Kinetic Hydrate Inhibition from Thermoresponsive Poly(2-amino-2-oxazoline)s: Size and Shape of the Hydrophobic Groups Are Critical for Performance

Non-amide kinetic hydrate inhibitors: A review

Reliability and Performance of Vinyl Lactam-Based Kinetic Hydrate Inhibitor Polymers after Treatment under a Range of Conditions

Kinetic Gas Hydrate Inhibition by Alternating Dipeptoids with Optimal Size and Shape N -Substituents

Synthesis and evaluation of poly (N-vinyl caprolactam)-co-tert-butyl acrylate as kinetic hydrate inhibitor

Kinetic Inhibition of Clathrate Hydrate by Copolymers Based on N -Vinylcaprolactam and N -Acryloylpyrrolidine: Optimization Effect of Interfacial Nonfreezable Water of Polymers

6-Ring Piperidine-Based Polymers with Both Upper and Lower Critical Solution Temperatures as Kinetic Hydrate Inhibitors

Preparation of poly(N-vinyl caprolactam) with various end groups using chain transfer agents and evaluation of their effects on kinetic hydrate inhibition

Synthesis and Evaluation Investigation of Novel Kinetic Hydrate Inhibitors at High Subcooling Conditions

Non-amide based zwitterionic poly(sulfobetaine methacrylate)s as kinetic hydrate inhibitors

Influence of the introduction of small hydrophilic groups on the kinetic hydrate inhibition effect of poly(N-vinylcaprolactam)

A Short Review on Natural Gas Hydrate, Kinetic Hydrate Inhibitors and Inhibitor Synergists

Hydrate Formation and Deposition Behaviors with Kinetic Inhibitors under Pseudo Multiphase Flow

Molecular Dynamics Study of Kinetic Hydrate Inhibitors: The Optimal Inhibitor Size and Effect of Guest Species

Molecular Dynamics Simulations for Selection of Kinetic Hydrate Inhibitors

Experimental Evaluation of Kinetic Hydrate Inhibitors and Mixed Formulations with Monoethylene Glycol for Hydrate Prevention in Pure Water and Brine–Oil Systems

Multi-functional oilfield production chemicals: maleic-based polymers for gas hydrate and corrosion inhibition

Dependence of the Kinetic Hydrate Inhibition Effect of Poly( N -vinylpyrrolidone) upon the Molecular Weight Is Influenced by Water Mobility in Millisecond Dynamics

Resolving hydrate inhibition mechanism: Interactions between kinetic hydrate inhibitors and CH 4 bubble

Differences in Nucleator Adsorption May Explain Distinct Inhibition Activities of Two Gas Hydrate Kinetic Inhibitors