Analysis of interactions between water and shale by water activity

Yubin Zhang,Zhengsong Qiu,Gongrang Li,Hanyi Zhong,Xin Zhao

DOI: https://doi.org/10.1016/j.jngse.2020.103372

IF: 5.285

2020-08-01

Journal of Natural Gas Science and Engineering

Abstract:<p>The interaction between shale and water is the key factor of wellbore instability in shale gas reservoirs. In this work, the influence of water on shale is studied from the perspective of water activity. Two kinds of shale samples from Sichuan Basin, Southwest China, were characterized using X-ray diffraction (XRD), total organic carbon (TOC) content tests, swelling ratio tests, field emission scanning electron microscope (FE-SEM), uniaxial compressive strength (UCS) and Nitrogen adsorption experiments. The relationships between mineralogical composition, TOC content, swelling ratio and water activity were studied respectively, and then the effect of water activity on microfractures was discussed. Based on the Frenkel–Halsey–Hill equation, fractal dimensions of shales were obtained by the Nitrogen adsorption experiments. And the relationship between water activity and various factors was analyzed. The results show that the water activity of shale is positively correlated with the total content of clay minerals (TCCM), especially the montmorillonite content. When the water activity of external solution was higher than that of shale, shale samples expanded due to chemical potential difference. The swelling ratio increased with increasing water activity of external solutions and shales. Shale swelling led to the development of microfractures, which in turn caused the decrease of strength. Therefore, under higher water activity conditions, shales were more prone to develop microfractures, and thus had lower strength. The adsorption data indicated that the fractal dimensions of shale samples ranged from 2.75 to 2.82, what was heterogeneous and irregular. And fractal dimension showed a good positive correlation with the water activity of shale. What is more, the study also shows that the use of low water activity working fluid in shale gas formation (especially in the formation with high water activity) can inhibit hydration and maintain formation stability.</p>

energy & fuels,engineering, chemical

What problem does this paper attempt to address?

The paper primarily explores the interaction between water activity and shale, particularly how this interaction affects wellbore stability in shale gas reservoirs. The study examines shale samples from two different formations in the Sichuan Basin of China (from the Xujiahe Formation and the Longmaxi Formation) to investigate the relationship between water activity and parameters such as shale mineral composition, total organic carbon (TOC) content, swelling ratio, and microstructural characteristics (e.g., fractal dimension of pore structure).

Specifically, the paper addresses the following key issues:
1. **The relationship between water activity and shale properties**: The study shows that the total clay mineral content (TCCM) of shale, especially the montmorillonite content, is positively correlated with water activity. However, there is no significant correlation between the total organic carbon (TOC) content of shale and water activity.
2. **The effect of water activity on shale swelling ratio**: When the water activity of the external solution is higher than that of the shale, the shale will swell due to the chemical potential difference. The swelling ratio of shale increases with the increase in water activity of both the external solution and the shale itself.
3. **The effect of water activity on shale microcracks and strength**: Higher water activity leads to the development of microcracks in shale, which in turn reduces the strength of the shale. The study also found that the uniaxial compressive strength (UCS) of shale significantly decreases after being soaked in a solution with high water activity.
4. **The relationship between water activity and the fractal dimension of shale pore structure**: The fractal dimension of shale obtained through nitrogen adsorption experiments is found to be positively correlated with water activity. This indicates that the complexity and irregularity of the shale surface are related to its ability to control moisture.

In summary, the paper aims to understand how water activity affects the physicochemical properties of shale and its application in shale gas reservoir engineering. It provides a theoretical basis for selecting appropriate drilling fluid systems to maintain wellbore stability and reduce water damage.