Abstract:Flocculation has been widely employed in treatment of mineral tailings and water management. In this study, a chitosan-graft-poly(acrylamide-dimethyl diallyl ammonium chloride) (Chi-g-P(AM-DMDAAC)) was synthesized in-house. The adsorption and interaction mechanisms of Chi-g-P(AM-DMDAAC) and an anionic polyacrylamide (APAM) in a two-step flocculation process of kaolinite were explored using settlement tests, zeta potential measurement, quartz crystal micro-balance with dissipation (QCM-D) and atomic force microscopy (AFM) technique. The type of primary flocculant was critical for the two-step flocculation process. The treatment of the kaolinite suspension using 1 mg/L of Chi-g-P(AM-DMDAAC) followed by adding 2 mg/L of APAM displayed more efficient flocculation performance. QCM-D results showed that three dissipative layers were assembled on model kaolinite surface after sequentially injecting 3.5 mg/L of Chi-g-P(AM-DMDAAC), 0.05 wt% kaolinite suspension and 2.5 mg/L of APAM. The above total adsorption amount (Delta f of -64.9 Hz) was much higher than that of using the two flocculants in reverse order (Delta f of -23.1 Hz). This result indicated that the adsorption layer of the positively charged Chi-g-P (AM-DMDAAC) on kaolinite surface provided active adsorption sites for APAM. Further AFM measurement confirmed that the average adhesion between the silicon tip adsorbed Chi-g-P(AM-DMDAAC) and model kaolinite surface in 2.5 mg/L APAM solution increased from 0.25 +/- 0.1 nN to 4.2 +/- 0.3 nN with the effective interaction range of 700 nm, which was stronger than that measured between a bare silicon tip and silica substrate in single-componentflocculant solutions. The highly efficient two-step flocculation process could be ascribed to the strong electrostatic attraction between the kaolinite and the oppositely charged Chi-g-P(AM-DMDAAC) and APAM. Findings in this study will benefit the development of environmentally friendly flocculant for mineral tailings and water treatment. (c) 2021 Elsevier B.V. All rights reserved.

Effect of bulk nanobubbles on flocculation of kaolin in the presence of cationic polyacrylamide

Effect of Bulk Nanobubbles on the Flocculation and Filtration Characteristics of Kaolin Using Cationic Polyacrylamide

Effect of Bulk Nanobubbles on the Entrainment of Kaolinite Particles in Flotation

Enhanced Kaolinite Flotation Using Amine Coated Nanobubbles

Effects of Pure and Modified Nanobubbles on the Reverse Flotation of Kaolinite from Hematite

Effect of Nanobubbles on Particle Flocculation in Sodium Oleate-Calcite Flotation System

The role of bulk micro-nanobubbles in reagent desorption and potential implication in flotation separation of highly hydrophobized minerals.

Revealing The Characteristics Of A Novel Bioflocculant And Its Flocculation Performance In Microcystis Aeruginosa Removal

Study on Influence Factors in Flocculation Conditions of Bioflocculant

A review of bulk nanobubbles and their roles in flotation of fine particles

Polyacrylamide and poly(N,N-dimethylacrylamide) grafted cellulose nanocrystals as efficient flocculants for kaolin suspension.

Flocculation and dewatering of the Kaolin slurry treated by single- and dual-polymer flocculants

An Assessment of the Role of Combined Bulk Micro- and Nano-Bubbles in Quartz Flotation

Flocculation of kaolin suspension with the adsorption of N,N-disubstituted hydrophobically modified polyacrylamide

Adsorption and Interaction Mechanisms of Chi-g-P(AM-DMDAAC) Assisted Settling of Kaolinite in a Two-Step Flocculation Process.

The Influence of Various Parameters on Petroleum Oil Removal from Produced Water with Novel Nanobubbles/microbubbles Flotation

Adsorption of Bulk Nanobubbles on the Chemically Surface-Modified Muscovite Minerals

Flocculation Characterization of a Bioflocculant from Bacillus Licheniformis

Influence of Two-Stage Dosing on Flocculation and Settlement of Kaolinite and Associated Mechanisms

Investigation of the Effect of Nanoparticle Exposure on the Flocculability of Activated Sludge Using Particle Image Velocimetry in Combination with the Extended Dlvo Analysis

Flocculation Behaviour and Mechanisms of Cationic Inorganic Microparticle/polymer Systems