Abstract:Ethanol dehydration is effectively catalyzed by strongly acidic zeolite catalysts which are known, however, to exhibit poor time on stream stability. Alumina and silica-alumina on the other hand are relatively stable but reach only low activity levels. Here, a series of aluminosilicate catalysts (Si:Al ratio = 16) was prepared by non-hydrolytic sol-gel (NHSG) and are shown to feature an intermediate level of activity, between the HZSM-5 zeolite and a commercial silica-alumina. Importantly, the best samples, were very stable with time on stream. Unlike HZSM-5, which also catalyzes ethylene oligomerization due to its strong acid sites and is therefore prone to coking, NHSG prepared catalysts did not produce any traces of ethylene oligomers and did not show any trace of coke formation. Characterization (ICP-OES, N 2 physisorption, TEM, XPS, IR coupled with pyridine adsorption, Raman spectroscopy, solid state NMR spectroscopy) reveal that the unconventional synthetic method presented here allowed to prepare mesoporous aluminosilicate materials with a remarkable degree of homogeneity. It is this thorough dispersion of Al in the amorphous silicate matrix which is responsible for the formation of acid sites which are intermediate (in terms of strength and nature) between those of commercial silica-alumina and HZSM-5 zeolite. The texture of the best NHSG catalyst – mainly mesoporous with a high specific surface area (800 m2 g −1 ) and pore volume (0.5 cm3 g −1 ) – was also unaffected after reaction. To overcome deactivation issues in ethanol dehydration, this study suggests to target amorphous aluminosilicate catalysts with open mesoporosity and with an intimate mixing of Al and Si.

Silver modified molecular sieve catalysts for the dehydration of various alcohols

Regulating Surface Acid-Base Balance on NaZSM-5 by Fe Modification Towards Enhanced Methanol Dehydration to Dimethyl Ether

Ethanol Dehydration to Ethylene over HZSM-5 Catalyst Modified by Zn and Mn

Highly Dispersed CrOx Nanoparticle-Modified NaZSM-5 for Dehydration of Methanol to Dimethyl Ether

Bioethanol Dehydration To Bioethylene With Modified Zn/Mn/Zsm-5 Catalyst

Catalytic oxidation of isoamyl alcohol on modified ZSM-5 molecular sieve catalysts prepared by different methods

Gas-Phase Selective Oxidation of Alcohols: in Situ Electrolytic Nano-Silver/Zeolite Film/Copper Grid Catalyst

ZSM-5 molecular sieve modified catalyst and its preparation method and application

Coking Behavior of Submicron ZSM-5 Zeolite Catalyst in Dehydration of Ethanol to Ethylene

Mildly Acidic Aluminosilicate Catalysts for Stable Performance in Ethanol Dehydration

Deactivation and Regeneration of ZSM-5 Zeolite Catalysts for Ethanol Dehydration

Regulation of Pore Structure and Acidity of a ZSM-5 Catalyst for Dehydration of Glycerol to Acrolein

Catalytic dehydration of methanol to dimethyl ether over micro–mesoporous ZSM-5/MCM-41 composite molecular sieves

Low-Temperature Dehydration of Ethanol to Ethylene over Cu–Zeolite Catalysts Synthesized from Cu–Tetraethylenepentamine

MCM-22, MCM-36, and ITQ-2 Zeolites with Different Si/Al Molar Ratios as Effective Catalysts of Methanol and Ethanol Dehydration

Reaction Kinetics of Methanol Dehydration over Combined AI203-HZSM-5 Solid Acids

Highly active Ag-SiO2-Al2O3 catalyst used for the dehydrogenation of methanol to anhydrous formaldehyde

A Novel Catalyst with High Activity for Polyhydric Alcohol Oxidation: Nanosilver/Zeolite Film

Functionalized CeO2/SBA-15 Materials As Efficient Catalysts for Aqueous Room Temperature Mono-dehydration of Sugar Alcohols

Ag/MCM-41 As a Highly Efficient Mesostructured Catalyst for the Chemoselective Synthesis of Methyl Glycolate and Ethylene Glycol

Silver-Loaded Chabazite in Ethanol-to-Hydrocarbon Processâ€”Operando FT-IR and UV-Vis Spectroscopic Studies