Experimental Research on Adsorption Kinetic Characteristics of CH4, CO2, and N2 in Coal from Junggar Basin, China, at Different Temperatures

Wanjie Sun,Haifei Lin,Shugang Li,Xiangguo Kong,Hang Long,Min Yan,Yang Bai,Jiamin Tian
DOI: https://doi.org/10.1007/s11053-021-09812-w
IF: 5.609
2021-02-07
Natural Resources Research
Abstract:The adsorption kinetic characteristics of CH<sub>4</sub>, CO<sub>2</sub>, and N<sub>2</sub> in coal provide crucial information for increasing coal seam gas recovery. In this study, isothermal adsorption kinetics experiments were conducted using automatic high-pressure gas adsorption analyzer to reveal differences in adsorption kinetic characteristics of CH<sub>4</sub>, CO<sub>2</sub>, and N<sub>2</sub> in coal. The research shows that, before reaching adsorption equilibrium, the adsorption ratio of CO<sub>2</sub> was higher than that of N<sub>2</sub> while that of CH<sub>4</sub> was the smallest. The initial adsorption rates of CO<sub>2</sub>, CH<sub>4</sub>, and N<sub>2</sub> were 1998, 205, and 76 cm<sup>3</sup> g<sup>−1</sup> h<sup>−1</sup>, respectively. The order of decreasing gas adsorption rate with respect to the fluctuation zone was CO<sub>2</sub> → N<sub>2</sub> → CH<sub>4</sub>. Before reaching adsorption equilibrium, the gas adsorption ratio at high temperature was higher than that at low temperature. The adsorption rates (<i>R</i><sub><i>t</i></sub>) of gas were divided into a rapid decay zone (<i>R</i><sub><i>t</i></sub> &gt; 0.1 <i>Q</i><sub>e</sub>/h), slow decay zone (0.01 <i>Q</i><sub>e</sub>/h &lt; <i>R</i><sub><i>t</i></sub> &lt; 0.1 <i>Q</i><sub>e</sub>/h), and an adsorption equilibrium zone (|<i>R</i><sub><i>t</i></sub>| &lt; 0.01 <i>Q</i><sub>e</sub>/h). Among the pseudo-first-order kinetic equation, the Fickian diffusion model and the dynamic diffusion model, the latter can best describe the adsorption kinetic process of coal. This work is expected to improve the theoretical basis of enhancing coal seam gas recovery and enrich the theory of gas adsorption in coal.
geosciences, multidisciplinary
What problem does this paper attempt to address?
The paper mainly studies the adsorption kinetics characteristics of methane (CH4), carbon dioxide (CO2) and nitrogen gas (N2) in coal seams in the Junggar Basin, China, at different temperatures. The study reveals the differences in adsorption rate and proportion of the three gases in coal through isothermal adsorption kinetics experiments using an automated high-pressure gas adsorption analyzer. The experimental results show that, before reaching adsorption equilibrium, the adsorption proportion of CO2 is higher than N2, while the adsorption proportion of CH4 is the smallest. The initial adsorption rates of the gases are 1998 cm3/g·h for CO2, 205 cm3/g·h for CH4, and 76 cm3/g·h for N2. As the temperature increases, the adsorption proportion of the gases increases before reaching equilibrium. In the analysis of adsorption kinetics, the researchers considered pseudo-first-order kinetic equation, Fick's diffusion model, and dynamic diffusion model. The results indicate that the dynamic diffusion model can best describe the adsorption kinetics process of coal. The study also found that the adsorption rate of the gases is faster at high temperatures than at low temperatures, and after reaching adsorption equilibrium, the adsorption rate enters a slowly decreasing region and an adsorption equilibrium region. The paper points out that these findings are of great significance for understanding the mechanism of coalbed methane (CBM) extraction and improving the efficiency of CH4 recovery, and provide further research basis for improving the theory of coal adsorption gases.