Abstract:The inhibiting effect of Al(OH) 3 and Mg(OH) 2 dust on explosion of methane-air mixtures was investigated by means of explosion parameter tests in a 20-liter closed vessel. The influences of varying methane concentration and dust concentration on explosion parameters were characterized based on the experimental data to determine the maximum explosion pressure, maximum rate of pressure rise, lower explosion limits and upper explosion limits. The inhibiting mechanisms of these kinds of dust were analyzed as well. The investigations indicate that Al(OH) 3 and Mg(OH) 2 dust can be used as inhibitors to prevent methane explosion, however, their inhibiting effects are less than those of inert gas such as N 2 and CO 2 in that their dust can weaken the methane explosion but cannot totally eliminate it. The tests show that all of the explosion parameters with dust additives are strongly dependent on methane/air ratio and dust concentration, and Al(OH) 3 dust has better performance than Mg(OH) 2 dust in inhibiting methane explosion. The average percentage decreases of maximum explosion pressure and maximum rate of pressure rise with Al(OH) 3 dust are 11.08% and 66.15%, respectively. Experiments also showed that there is a special phenomenon when methane explosion is inhibited by Al(OH) 3 and Mg(OH) 2 dust, in which is that during the process of explosion the maximum explosion pressure value first decreases then increases as dust concentration increases. The best dust concentrations to inhibit the explosion are 250 g/m 3 with methane/air ratio at 9.5%, and 200 g/m 3 with methane/air ratio at 7%. It is suggested that water vapor produced by the thermal decomposition of metal hydroxides makes the particles of descending dust combine, resulting in a decrease of the real dust concentration in the vessel. Water vapor also is the major cause of another phenomenon that the LEL curve and the UEL curve never meet with the increase of gas concentration.

Inhibitory effects of typical inert gases on the flame propagation and structures in TiH 2 dust clouds

Inhibitory Effects of Typical Inert Gases on the Flame Propagation and Structures in TiH2 Dust Clouds

Experimental and Kinetic Study of the Effects of CO2 and H2O Addition on PAH Formation in Laminar Premixed C2H4/O2/Ar Flames

Suppression Characteristic of Three Inhibitors on the Flame Propagation of Titanium Dust Layer

Flame Propagation Behaviors and Influential Factors of TiH2 Dust Explosions at a Constant Pressure

Study on the Instability and Suppression Mechanism of Methane/air Deflagration Flame by Inert Gas-Halogenated Hydrocarbons

Inhibition evaluation of gas inhibitors in micron-sized aluminum dust explosion

Thermal Suppression Effects of Diluent Gas on the Deflagration Behavior of H2–Air Mixtures

Quantitative study on the inhibitory effect of carbon dioxide on hydrogen explosion and the production of carbon monoxide

Study on inhibition effect and mechanism of NH4H2PO4 on explosion of titanium powder

Secondary Explosion Characteristics of TiH2 Dust Induced by Hydrogen-Oxygen Detonations

Experimental Study of Flame Propagating Behaviors Through Titanium Particle Clouds

Effects of partial inerting on flame structures of starch dust deflagration in duct

Hybrid H2/Ti dust explosion hazards during the production of metal hydride TiH2 in a closed vessel

Study on the effect and mechanism of Ca(H2PO4)2 and CaCO3 powders on inhibiting the explosion of titanium powder

Thermal suppression effects of diluent gas on the deflagration behavior of H 2 –air mixtures

Effects Investigation of Particle Size and Concentration on the Ignition, Explosion Characteristics, and Behavior of Flame Propagation in TC4 Titanium Alloys

Suppression Effects and Mechanisms of Three Typical Solid Suppressants on Titanium Hydride Dust Explosions

Effects of Reduced Oxygen Levels on Flame Propagation Behaviors of Starch Dust Deflagration

The weakening effect of the inhibition of CO2 on the explosion of HCNG with the increase of hydrogen: Experimental and chemical kinetic research

Inhibiting Effect of Al(OH) 3 and Mg(OH) 2 Dust on the Explosions of Methane-Air Mixtures in Closed Vessel