Abstract:Diesel soot is a significant contributor to air pollution. Soot particles present in diesel engine exhaust have a negative impact on the environment and human health. Diesel oxidation catalysts (DOCs) and diesel particulate filters (DPFs) currently use noble metal-based catalysts for soot oxidation. Due to the use of noble metals in the catalyst, the cost of diesel after-treatment systems is steadily rising. As a result, diesel vehicles have become commercially less viable than gasoline vehicles and electronic vehicles. The study focuses on an alternative diesel oxidation catalyst with efficiency similar to that of a noble metal catalyst but with a much lower cost. CeO2-Al2O3 catalysts are known for their oxygen storage capacity and high redox activity, making them suitable for soot oxidation. Adding Zr to these catalysts has been shown to influence their structural and chemical properties, significantly affecting their catalytic behavior. Therefore, the current study is focused on using Zr/CeO2-Al2O3 as a substitute for noble metal-based catalysts to enhance its performance for diesel soot oxidation in automotive exhaust. Evaporation-induced self-assembly (EISA) was used to prepare 1, 3, and 5 weight (wt) % Zr supported mesoporous CeO2-Al2O3 catalysts. Morphological, structural, and physicochemical properties of the synthesized catalysts were examined using Brunauer-Emmett-Teller (BET) absolute isotherm, Scanning electron microscopy (SEM), X-ray diffraction (XRD), Fourier transform infrared spectroscopy (FTIR), Temperature programmed reduction (TPR), and Temperature-programmed desorption of ammonia (NH3-TPD). XRD, BET, and SEM data confirmed that the catalysts were mesoporous and low-crystalline with a high surface area. The soot oxidation activity of the catalysts was evaluated using a thermogravimetric analysis (TGA) technique. The loose contacts soot oxidation activity test suggested that 50% oxidation of soot occurred at 390 °C in the absence of a catalyst. T50 of CeO2-Al2O3 catalyzed soot oxidation was 296 °C. Adding Zr to the catalyst significantly improved catalytic activity for diesel soot oxidation. We observed a further drastic change in T50 of soot over 1, 3, and 5% Zr/CeO2-Al2O3, which were 220 °C, 210 °C, and 193 °C, respectively. According to these results, incorporating Zr into the CeO2-Al2O3 catalyst significantly improved the oxidation process of soot.

A systematic evaluation of the catalytic behavior of transition metal (Fe and Mn)–doped ceria-zirconia-alumina oxides on automobile exhaust

Assessment of the Synergetic Performance of Nanostructured CeO2-SnO2/Al2O3 Mixed Oxides on Automobile Exhaust Control

Doping Manganese Oxides with Ceria and Ceria Zirconia Using a One-Pot Sol–Gel Method for Low Temperature Diesel Oxidation Catalysts

Catalytic activity of Zr/CeO2-Al2O3 catalyst for diesel soot oxidation: synthesis, characterization, and performance evaluation

Control of carbon monoxide (CO) from automobile exhaust by a dealuminated zeolite supported regenerative MnCo2O4 catalyst

Catalytic evaluation of promoted CeO2-ZrO2 by transition, alkali, and alkaline-earth metal oxides for diesel soot oxidation

Transition-metal‐doped ceria carried on two-dimensional vermiculite for selective catalytic reduction of NO with CO: Experiments and density functional theory

Synergetic Promotion of 4Mn10ce/γ-Al2o3 Catalyst to Pt/xBa/Ce0.5Zr0.5O2 Catalysts for NOx Removal from Diesel Exhausts

Study of Ce, Ca, Fe, and Mn-Doped LaCoO3 Perovskite Oxide for the Four-Way Purification of PM, NOx, CO, and HC from Diesel Engine Exhaust

Facile preparation of Fe-Beta zeolite supported transition metal oxide catalysts and their catalytic performance for the simultaneous removal of NO x and soot

Mn-modified Near-Surface Atomic Structure of CeO2 Nanorods for Promoting Catalytic Oxidation of Auto-Exhaust Carbon Particles

Emission Reduction in SI Engines by using metal doped Cu- ZSM5 and Ce.Cu- ZSM5 zeolite as Catalysts

The Preparation of Mn-Modified CeO2 Nanosphere Catalysts and Their Catalytic Performance for Soot Combustion

Synergistic Effects of a CeO2/SmMn2O5-H Diesel Oxidation Catalyst Induced by Acid-Selective Dissolution Drive the Catalytic Oxidation Reaction.

Synergistic Effects of a CeO 2 /SmMn 2 O 5 –H Diesel Oxidation Catalyst Induced by Acid-Selective Dissolution Drive the Catalytic Oxidation Reaction

Investigation of the active sites for NO oxidation reactions over MnOx–CeO2 catalysts

Facile preparation of alkali metal‐modified hollow nanotubular manganese‐based oxide catalysts and their excellent catalytic soot combustion performance

Mn-modified near-surface atomic structure of CeO 2 nanorods for promoting catalytic oxidation of auto-exhaust carbon particles

Effect of iron doping into CeO2-ZrO2 on the properties and catalytic behaviour of Pd-only three-way catalyst for automotive emission control

MnO x –CeO 2 mixed oxides for diesel soot oxidation: a review

Synthesis of CeO2–MnOx Mixed Oxides and Catalytic Performance under Oxygen-Rich Condition