Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Inverse Phase Transition in Droplet Clusters Levitating over the Locally Heated Water Layer

Inversion of Stabilized Large Droplet Clusters

Self-assembled levitating clusters of water droplets: pattern-formation and stability

Realization of Coalescence-Induced Condensate Droplet Jumping on a Hierarchical Porous Superhydrophobic Surface over a Wide Range of Subcooling Up to 20 K

A hierarchical levitating cluster containing transforming small aggregates of water droplets

Water nanodroplet thermodynamics: quasi-solid phase-boundary dispersivity.

Uncovering novel phase transitions in dense dry polar active fluids using a lattice Boltzmann method

Droplet Evaporation to Boiling in Van Der Waals Fluid

Small Leidenfrost droplet dynamics

Levitation of a nonboiling droplet over hot liquid bath

Symmetry-Breaking in Point-Heated Droplets

Geometrical Clusterization in SU(2) gluodynamics and Liquid-gas Phase Transition

Droplet deformation and heat transfer in isotropic turbulence

Liquid-liquid transition in supercooled aqueous solution involving a low-temperature phase similar to low-density amorphous water

Pulsating–gliding transition in the dynamics of levitating liquid nitrogen droplets

Coalescing Clusters Unveil New Regimes of Frictional Fluid Mechanics

The Action of One-dimensional Spatial Temperature Modulation on Dynamics of a Floating Droplet Heated from Below

Phase separation dynamics in deformable droplets

Phase Separation in Cold Para- Clusters

Flow stability in shallow droplets subject to localized heating of the bottom plate

Understanding the role of droplet clusters in a reactive mixing layer