Abstract:Biotechnological strategies using renewable materials as starting substrates are a promising alternative to traditional oleochemical processes for the isolation of different fatty acids. Among them, long chain mono-unsaturated fatty acids are especially interesting in industrial lipid modification, since they are precursors of several economically relevant products, including detergents, plastics and lubricants. Therefore, the aim of this study was to develop an enzymatic method in order to increase the percentage of long chain mono-unsaturated fatty acids from Camelina and Crambe oil ethyl ester derivatives, by using selective lipases. Specifically, the focus was on the enrichment of gondoic (C20:1 cisΔ11) and erucic acid (C22:1 cisΔ13) from Camelina and Crambe oil derivatives, respectively. The pursuit of this goal entailed several steps, including: (i) the choice of a suitable lipase scaffold to serve as a protein engineering template (Candida antarctica lipase A); (ii) the identification of potential amino acid targets to disrupt the binding tunnel at the adequate location; (iii) the design, creation and high-throughput screening of lipase mutant libraries; (iv) the study of the selectivity towards different chain length p-nitrophenyl fatty acid esters of the best hits found, as well as the analysis of the contribution of each amino acid change and the outcome of combining several of the aforementioned residue alterations and, finally, (v) the selection and application of the most promising candidates for the fatty acid enrichment biocatalysis. As a result, enrichment of C22:1 from Crambe ethyl esters was achieved either, in the free fatty acid fraction (wt, 78%) or in the esterified fraction (variants V1, 77%; V9, 78% and V19, 74%). Concerning the enrichment of C20:1 when Camelina oil ethyl esters were used as substrate, the best variant was the single mutant V290W, which doubled its content in the esterified fraction from approximately 15% to 34%. A moderately lower increase was achieved by V9 and its two derived triple mutant variants V19 and V20 (27%).

Enzymatic synthesis of novel structured lipids with tiger nut oil: optimized by response surface methodology

Synthesis of Structured Lipid 1,3-Dioleoyl-2-palmitoylglycerol in Both Solvent and Solvent-Free System

Immobilization, Regiospecificity Characterization and Application of Aspergillus Oryzae Lipase in the Enzymatic Synthesis of the Structured Lipid 1,3-Dioleoyl-2-palmitoylglycerol

Optimization of the Synthetic of Triglyceride Mimicked Human-milk by Using Response Surface Method

Enzymatically catalyzed synthesis of low-calorie structured lipid in a solvent-free system: optimization by response surface methodology

An Overview of Structured Lipid in Food Science: Synthesis Methods, Applications, and Future Prospects

Synthesis of Structured Phospholipids with Conjugated Linoleic Acid by Lipase - Catalyzed Acidolysis: Optimization Using Response Surface Methodology

Enzymatic Synthesis and Characterization of MLM-type Structured Lipid Using Grapeseed Oil and Capric Acid

Lipase-catalyzed solvent-free synthesis of monoglycerides from biodiesel-derived crude glycerol: Optimized using response surface methodology

Lipase-catalyzed Synthesis of Monocylglycerol Rich in Α-Linolenic Acid from Linseed Oil by Response Surface Methodology

Preparation of medium- and long-chain triacylglycerols rich in n-3 polyunsaturated fatty acids by bio-imprinted lipase-catalyzed interesterification

Free Lipase-Catalyzed Esterification of Oleic Acid for Fatty Acid Ethyl Ester Preparation with Response Surface Optimization

Ultrasound assisted enzymatic synthesis of OPO structured lipids bycovalent organic framework immobilizedlipase

Oil extraction from tiger nut (Cyperus esculentus L.) using the combination of microwave-ultrasonic assisted aqueous enzymatic method - design, optimization and quality evaluation

Optimization of immobilized lipase catalyzed transesterification of cottonseed oil for biodiesel production using response surface methodology

Optimization of the Lipase-Catalyzed Irreversible Transesterification of Pistacia Chinensis Bunge Seed Oil for Biodiesel Production

Optimization of Lipase-Catalyzed Transesterification of Cotton Seed Oil for Biodiesel Production Using Response Surface Methodology

Enzymatic synthesis of phytosteryl lipoate and its antioxidant properties

Response Surface Optimization of Biocatalytic Biodiesel Production with Acid Oil

Alteration of Chain Length Selectivity of Candida antarctica Lipase A by Semi-Rational Design for the Enrichment of Erucic and Gondoic Fatty Acids

Optimization of PB011 Lipase-Catalyzed Synthesis of Biodiesel from Soybean Oil by Response Surface Method