Abstract:The aim of this study was to evaluate the effects of agro-industrial byproduct-based diets on the productive parameters, digestibility, insect composition, and gut microbiota of mealworm (Tenebrio molitor) larvae. Three formulations corresponding to three different levels of starch and protein were tested: one formulation based on bread remains and brewer’s yeast, representing a diet of high starch (61.1%) and low crude protein (18.5%) (HS-LP); and two formulations in which an additional four byproducts (courgette (Cucurbita pepo) remains, tigernut (Cyperus scelentus) pulp, brewer’s spent grains, and rice straw) were incorporated in different proportions, consistent with a diet of both moderate starch (29.8%) and crude protein (21.0%) (MS-MP); and another corresponding to a diet of low starch (20.0%) and high crude protein (26.3%) (LS-HP). A total of 1920 young larvae (average weight = 0.65 mg per larva) were used in this study. The larvae were randomly distributed into 16 replicates per treatment (boxes of 22.5 cm × 14.0 cm × 4.75 cm). Ten replicates for the growth performance–digestibility trial and six replicates for the complementary trial to determine uric acid levels in the frass were assigned per treatment. For growth performance, the diets were administered ad libitum during the experiment. The average number of days for the larvae to start pupating was lower in those reared on the HS-LP and LS-HP diets (88.90 and 91.00 days, respectively) than those on the MS-MP diet (120.09 days) (p < 0.001). The final individual weight was higher (p < 0.001) in larvae of the LS-HP group (168.69 mg) compared to those of the other groups (100.29 and 112.99 mg for HS-LP and MS-MP, respectively). However, the feed conversion ratio was better (p < 0.001) in the HS-LP group with the lowest value (1.39 g/g), with dry matter digestibility being the highest for the same diet (70.38%) (p < 0.001). Mealworms reared on LS-HP and MS-MP diets had a higher crude protein content than those reared on the HS-LP diet (p = 0.039). The most abundant phyla in the gut microbiota of larvae were Tenericutes, Proteobacteria, and Firmicutes, with their abundance depending on the rearing substrate. The representation of Tenericutes phylum was higher (p < 0.05) in the mealworms reared on MS-MP and HS-LP diets, whereas Proteobacteria and Cyanobacteria were higher in abundance (p < 0.001) in the insects reared on LS-HP. In conclusion, the larval growth, digestibility, insect composition, and gut microbiota of Tenebrio molitor were found to depend on the composition of the administered diet, and the results suggest great potential for the use of agro-industrial byproducts in their rearing and production.

From waste to food and bioinsecticides: An innovative system integrating Tenebrio molitor bioconversion and pyrolysis bio-oil production

Sustainable strategy for lignocellulosic crop wastes reduction by Tenebrio molitor Linnaeus (mealworm) and potential use of mealworm frass as a fertilizer

Valorization of local agricultural by-products as nutritional substrates for Tenebrio molitor larvae: A sustainable approach to alternative protein production

Sunflower seed hulls waste as a novel source of insecticidal product: Pyrolysis bio-oil bioactivity on insect pests of stored grains and products

A Treatment for Rice Straw and Its Use for Mealworm (Tenebrio molitor L.) Feeding: Effect on Insect Performance and Diet Digestibility

Analysis of yellow mealworm ( Tenebrio molitor ) frass as a resource for a sustainable agriculture in the current context of insect farming industry growth

Conversion of Mixtures of Soybean Curd Residue and Kitchen Waste by Black Soldier Fly Larvae (Hermetia illucens L.)

Biogas Production from Residues of Industrial Insect Protein Production from Black Soldier Fly Larvae Hermetia ilucens (L.): An Evaluation of Different Insect Frass Samples

A new approach to biotransformation and value of kitchen waste oil driven by gut microorganisms in Hermetia illucens

Resource Utilization of Residual Organic Sludge Generated from Bioenergy Facilities Using Hermetia illucens Larvae

From organic waste to renewable energy: response surface methodology approach for optimized biodiesel production from palm weevil larvae (Rhynchophorus ferrugineus)

Effects of Agro-Industrial Byproduct-Based Diets on the Growth Performance, Digestibility, Nutritional and Microbiota Composition of Mealworm (Tenebrio molitor L.)

Potential use of mealworm frass as a fertilizer: Impact on crop growth and soil properties

Conversion Efficiency of Lignin-Rich Olive Pomace to Produce Nutrient-Rich Insect Biomass by Black Soldier Fly Larvae, Hermetia illucens

Standardisation of fermented pellet feed of Tenebrio molitor larvae for use as a biodiesel raw material

Chemical evaluation of pyrolysis oils from domestic and industrial effluent treatment station sludges with perspective to produce value-added products

Future Proteins: Sustainable Diets for Tenebrio molitor Rearing Composed of Food By-Products

Local circular economy: BSF insect rearing in the Italian Agri-Food Industry

Improving process sustainability in bio-oil transforming for biofuels and platform chemicals production: Valorization of the carbon residue

Rearing substrate impacts growth and macronutrient composition of Hermetia illucens (L.) (Diptera: Stratiomyidae) larvae produced at an industrial scale

Neotropical Biodiversity as Microbial Frontline for Obtaining Bioactive Compounds with Potential Insecticidal Action