Abstract:Four wild "red" yeast strains (Rhodosporidium kratochvilovae FMCC Y70, R. toruloides NRRL Y-27013, R. toruloides NRRL Y-17902 and R. toruloides NRRL Y-6985) were cultured in shake flasks on industrial glycerol at an initial substrate (Gly0) concentration ≈ 50 g/L under nitrogen limitation. Strains NRRL Y-27013, NRRL Y-17902 and NRRL Y-6985 presented appreciable dry cell weight (DCW) and lipid synthesis (DCW up to 18–19 g/L containing lipids in quantities ≈ 47%, w/w). Strains NRRL Y-27013 and NRRL Y-6985 were further tested in higher Gly0 concentrations (≈90 g/L and ≈110 g/L) with the same initial nitrogen quantity as in the first ("screening") experiment. Both strains, despite the high Gly0 concentrations and C/N ratios (up to 120 moles/moles) imposed, presented significant DCW production (up to c. 29.0–29.5 g/L). Yeast biomass contained significant lipid (42–43%, w/w) and endopolysaccharide (up to 42%, w/w) quantities. Both lipids and endopolysaccharide quantities (in % w/w) noticeably increased as a response to the imposed nitrogen limitation. Lipids containing mainly oleic and palmitic acids constituted ideal candidates for biodiesel synthesis. Thereafter, the wastewaters derived from the lipid production process (lipid fermentation wastewaters—LFWs) were used as maceration waters in cultivations of edible and medicinal fungi, where novel (non-conventional) substrates were used in the performed cultures. CW (coffee residue + wheat straw), CB (coffee residue + beech wood shavings), OW (olive crop + wheat straw), OB (olive crop + beech wood shavings), RW (rice husk + wheat straw) and RB (rice husk + beech wood shavings) were soaked/sprayed with LFWs or tap water and utilized in the cultivation of Pleurotus, Ganoderma and Lentinula mushrooms. The impact of LFWs on the mycelial growth rate (mm/d) and biomass production was evaluated. The results show that regardless of the wetting method, the highest growth rates (6.2–6.6 mm/d) were noticed on RW and RB for Pleurotus eryngii and Ganoderma resinaceum, on OW, OB and RW for Ganoderma applanatum and on RW, OW and OB for Lentinula edodes. Nevertheless, high biomass production was obtained on substrates soaked with LFWs for Pleurotus ostreatus (RW: 443 mg/g d.w.), L. edodes (RB: 238 mg/g d.w.) and Ganoderma lucidum (RW: 450 mg/g d.w.). Overall, this study demonstrates the possibility of the industrial conversion of low-value agro-waste to mycelial mass and eventually to important food products.

Fungal textiles: Wet spinning of fungal microfibers to produce monofilament yarns

Tunable Fungal Monofilaments from Food Waste for Textile Applications

Dry gel spinning of fungal hydrogels for the development of renewable yarns from food waste

Development of hydrogels from cell wall of Aspergillus oryzae containing chitin-glucan and wet spinning to monofilaments

Green and Economical Strategy for Spinning Robust Cellulose Filaments

Properties and environmental sustainability of fungal chitin nanofibril reinforced cellulose acetate films and nanofiber mats by solution blow spinning

Successful cultivation of edible fungi on textile waste offers a new avenue for bioremediation and potential food production

Polyacrylonitrile Nanofibrous Mat from Electrospinning: Born with Potential Anti-Fungal Functionality

Mycelium-based biomimetic composite structures as a sustainable leather alternative

Primarily Industrialized Trial of Novel Fibers Spun from Cellulose Dope in NaOH/Urea Aqueous Solution

Fungal Carbon: A Cost‐Effective Tunable Network Template for Creating Supercapacitors

Bio-Producing Bacterial Cellulose Filaments through Co-Designing with Biological Characteristics

Effect of wet spinning parameters on the properties of novel cellulosic fibres

Transforming post-consumer cotton waste textiles into viscose staple fiber using hydrated zinc chloride

Resource recovery and treatment of wastewaters using filamentous fungi

Spin-dyeing of cellulose fibres with vat dyes using the Ioncell process

Engineering strong man-made cellulosic fibers: a review of the wet spinning process based on cellulose nanofibrils

High-performance cellulosic filament fibers prepared via dry-jet wet spinning from ionic liquids

Yeast Lipids from Crude Glycerol Media and Utilization of Lipid Fermentation Wastewater as Maceration Water in Cultures of Edible and Medicinal Mushrooms

Continuous Pilot‐Scale Wet‐Spinning of Biocompatible Chitin/Chitosan Multifilaments from an Aqueous KOH/Urea Solution

Mechanically Strong Multifilament Fibers Spun from Cellulose Solution Via Inducing Formation of Nanofibers