Abstract:Abstract On-farm monitoring of milk composition can support close control of the udder and metabolic health of individual dairy cows. In previous studies, near-infrared (NIR) spectroscopy applied to milk analysis has proven useful for predicting the main components of raw milk (fat, protein, and lactose). In this contribution, we present and evaluate a precise tool for online milk composition analysis on the farm. For each milking, the online analyzer automatically collects and analyses a representative milk sample. The system acquires the NIR transmission spectra of the milk samples in the wavelength range from 960 to 1690 nm and performs a milk composition prediction afterward. Over a testing period of 8 weeks, the sensor collected 1165 NIR transmittance spectra of raw milk samples originating from 36 cows for which reference chemical analyses were performed for fat, protein, and lactose. For the same online sensor system, two calibration scenarios were evaluated: training post-hoc prediction models based on a representative set of calibration samples ( n = 319) acquired over the entire testing period, and training real-time prediction models exclusively on the samples acquired in the first week of the testing period ( n = 308). The obtained prediction models were thoroughly tested on all the remaining samples not included in the calibration sets ( n respectively 846 and 857). For the post-hoc prediction models, this resulted in an overall prediction error (root-mean-squared error of prediction, RMSEP) smaller than 0.08% (all % are in w / w ) for milk fat (range 1.5-6.3%), protein (2.6-4.3%) and lactose (4-5.1%), while for the real-time prediction models the RMSEP was smaller than 0.09% for milk fat and lactose, and smaller than 0.11% for protein. The milk lactose predictions could be further improved by taking into account a cow-specific bias. The presented online sensor system using the real-time prediction approach can thus be used for detailed and autonomous on-farm monitoring of milk composition after each individual milking, as its accuracy is well within the ICAR requirements for on-farm milk analyzers and even meet the ICAR standards for laboratory analysis systems for fat and lactose. For this real-time prediction approach, a drift was observed in the predictions, especially for protein. Therefore, further research on the development of online calibration maintenance techniques is required to correct for this model drift and further improve the performance of this sensor system.

Identification of milk quality and adulteration by surface-enhanced infrared absorption spectroscopy coupled to artificial neural networks using citrate-capped silver nanoislands

Identification of adulterated milk using electronic nose

Optimization of Sensors Array as an Electronic Nose in Identifying Adulterate Milk

Identification of Adulterated'Yili'Milk Based on Electronic Nose

A Theoretical analysis of Milk adulteration/contamination detection in camel, buffalo and cow milk using SPR Technique

Rapid detection and quantification of milk adulterants using a nanoclusters-based fluorescent optical tongue

Quality Assessment of Reconstructed Cow, Camel and Mare Milk Powders by Near-Infrared Spectroscopy and Chemometrics

Non-targeted NIR spectroscopy and SIMCA classification for commercial milk powder authentication: A study using eleven potential adulterants

Application of Near-Infrared Spectroscopy to Quality Detection of Milk and Its Products

Identification of Milk Adulteration in Camel Milk Using FT-Mid-Infrared Spectroscopy and Machine Learning Models

Portable Analyzer for Rapid Analysis of Total Protein, Fat and Lactose Contents in Raw Milk Measured by Non-dispersive Short-wave Near-infrared Spectrometry

Online milk composition analysis with an on-farm near-infrared sensor

Identification and quantification of goat milk adulteration using mid-infrared spectroscopy and chemometrics

Rapid detection and quantification of melamine, urea, sucrose, water, and milk powder adulteration in pasteurized milk using Fourier transform infrared (FTIR) spectroscopy coupled with modern statistical machine learning algorithms

Study on Qualitative and Quantitative Discrimination of Adulteration Goat's Milk by Near Infrared Technology

Online Milk Quality Assessment during Milking Using Near-infrared Spectroscopic Sensing System

Rapid detection of adulteration of goat milk and goat infant formulas using near-infrared spectroscopy fingerprints

Milk Source Identification and Milk Quality Estimation Using an Electronic Nose and Machine Learning Techniques

Adulteration detection in milk using infrared spectroscopy combined with two-dimensional correlation analysis

Identification and Authentication of Milk Using Digital Colormetry of Indicator Test Systems, Smartphone, and Chemometric Analysis

Development of a Gold Nanoparticle-Based Sensor for Authentication of Organic Milk Based on Differential Levels of miRNA