Monotonizing linear programs with up to two nonzeroes per column

D. Hochbaum

DOI: https://doi.org/10.1016/S0167-6377(03)00074-9

IF: 1.151

Operations Research Letters

Abstract:

What problem does this paper attempt to address?

Efficient immobilization of highly stable Bacillus amyloliquefaciens spore laccase for biodecolorization of textile dyes in water

Magda A. El-Bendary,Safaa M. Ezzat,Emad A. Ewais,Mohamed A. Al-Zalama

DOI: https://doi.org/10.1186/s12302-024-00865-1

2024-02-25

Environmental Sciences Europe

Abstract:Globally, millions of cubic meters of dye-contaminated wastewater are generated annually from the textile industry. Discharging the dye-contaminated wastewater into natural water streams is detrimental to the ecosystem and human health. Wastewater bioremediation is considered a practical solution for converting wastewater into value-added water for safe reuse especially in irrigation. The present study investigated the immobilization of highly stable spore laccase enzyme of Bacillus amyloliquefaciens A1 by entrapment and adsorption techniques. Based on the results, agarose gel was the most efficient support with 94% immobilization yield. Optimum temperature of immobilized enzyme was at 60 °C with complete thermal stability for 120 min. The maximum activity of immobilized enzyme was at pH 6–7 and retained 91% of its activity after 24 h incubation. It showed 100% storage stability after 8 weeks which was higher than that of un-immobilized enzyme (4 weeks). The enzyme activity was nearly stable after 8 consecutive cycles of reuse. Decolorization of 8 textile dyes was studied using the immobilized enzyme. Crystal violet, direct red 81 and acid black 24 were efficiently decolorized (94.5, 77.4, and 68.8%, respectively) within 24 h in the first cycle. Reusability of immobilized enzyme showed 74.6, 53.5, and 51.8% decolorization of the same dyes in the same order after the second cycle. Immobilized spore laccase-treated dye water was used to irrigate lentil seeds and showed germination index about 73% compared to 10.8% for untreated one indicating very low toxicity of the treated dye water.

environmental sciences
Immobilization of laccase for biotechnology applications

Senay Hamarat Sanlıer,Simge Gider,Alper Köprülü

DOI: https://doi.org/10.3109/10731199.2012.731414

2013-01-08

Abstract:Laccase played an important role in the decolorization of wide spectrum dyes as a low-cost and environmentally friendly technology. Laccase was immobilized in alginate beads and immobilization conditions were identified. 25 mg/ml laccase enzyme encapsulation efficiencies of using the prepared bead was calculated as approximately 94%. At the end of the 10 days of storage, the free laccase and immobilized laccase retained about 8.08% and 80.83%, respectively. The decolorization of the dye (Direct Blue 2) was around 86% for immobilized enzyme at 45°C. In the study, compared to the free enzyme, high activity, stable, reusable immobilized enzyme preparation was prepared.
Dye decolorization and detoxification by laccase immobilized on porous glass beads

P-P Champagne,J A Ramsay

DOI: https://doi.org/10.1016/j.biortech.2009.11.066

Abstract:The decolorization and detoxification of textile dyes by fungal laccase immobilized on porous glass beads were evaluated. Anthraquinone (Reactive blue 19 and Dispersed blue 3) and indigoid (Acid blue 74) dyes were degraded more rapidly than the azo dyes (Acid red 27 and Reactive black 5). There was no dye sorption to the enzyme bed when decolorization rates were high (>12 microM dye/U-h) but at moderate rates (8 to>0.06 microM/U-h), there was a transient color which disappeared upon prolonged exposure. With Reactive black 5, permanent adsorption occurred most likely because laccase had been totally inactivated. Although laccase treatment was more efficient at decolorizing the anthraquinone dyes, their toxicity (as determined by the Microtox assay) increased while the less efficiently decolorized solutions of azo and indigoid dyes became less toxic. These results demonstrate the potential and limitations of using immobilized laccase to enzymatically decolorize a range of different dye classes and reduce dye toxicity in a single step.
[Decolorization of Dyestuff and Dying Waste Water by Laccase Solution with Self-Flocculent Mycelial Pellets of Coriolus Versicolor].

Mianbin Wu,Liming Xia

DOI: https://doi.org/10.3321/j.issn:0001-6209.2002.03.018

2002-01-01

Abstract:Both laccase production by the white-rot fungus Coriolus versicolor and decolorization of dyestuff and dying waste water with crude solution of laccase were studied in this work. Laccase production meets the definition of secondary metabolism. For laccase production the optimum initial pH is 4.5. Addition of veratryl alcohol or elevated trace metals could both enhance the laccase activity, while Tween80 showed some inhibition. The immobilized mycelia of C. versicolor in polyurethane foam had less laccase production ability than mycelial pellets. A repeated batch cultivation process was found to be a very economical way for laccase harvest. The same pellets could be used for at least 14 times and average laccase activity of each batch could maintain 6.72 IU/mL. This method reduces the enzyme production course, medium consumption and the possibility of contamination, showing high efficient and great economic benefit. Good results were also obtained in decolorization experiments with the crude solution of laccase. With 3.3 IU/mL initial laccase activity, color removal of Acid Orange reached 98.5% after 24 h reaction. Also with 2.6 IU/mL initial laccase activity, color removal of dying waste water reached 93% after 24 h reaction.
Construction of immobilized laccase hydrogels via sodium alginate-dopamine/polyethylene glycol and its efficient degradation of dyeing wastewater

Xiaolei Su,Xue Yang,Hao Long,Yahao Li,Weiyang Sun,Taoling Mo,Hongxiang Lyu,Artur Cavaco-Paulo,Hongbo Wang,Jing Su

DOI: https://doi.org/10.1016/j.ijbiomac.2024.134929

2024-08-21

Abstract:Laccases with highly catalytic properties have been widely used in developing green applications for water remediation. However, the poor stability and low reutilization rate of free laccase make it difficult to be applied practically. Hence, in this study, an immobilized laccase was prepared using dopamine (DA) functionalized sodium alginate (SA)/polyethylene glycol (PEG) composite hydrogels to realize the recyclability of the laccase. The SA/PEG composite hydrogels, as the protective carrier for laccase, exhibited excellent catalytic stability in various interfering environments. After 30 days, Lac@SA-PDA/PEG beads could remain 70.23 % of the initial activity, as the residual activity of free laccase was only 12.35 %. When free laccase and Lac@SA-PDA/PEG beads were used for decolorization of Reactive Blue 19 (RB-19,100 mg/L), the degradation rate of Lac@SA-PDA/PEG is 6.88 times higher than free laccase. More importantly, the SA-PDA/PEG composite hydrogel exhibited a high reutilization rate, which after six cycles, Lac@SA-PDA/PEG beads retained 90.23 % of its initial activity. Besides, the degradation effect of Lac@SA-PDA/PEG on different dyes was analyzed. In addition, the conjectured degradation pathways of RB-19 by laccase were analyzed. The work showed that immobilized laccase has tremendous potential for the treatment of dyestuff wastewater.
Production, Purification, Characterization and Immobilization of Laccase from Phoma betae and its Application in Synthetic Dyes Decolorization

Elsayed Abdel Razik,Eman Ali,Sawsan Abd ellatif

DOI: https://doi.org/10.21608/ejbo.2019.19226.1381

2019-12-30

Egyptian Journal of Botany

Abstract:LACCASE (EC 1.10.3.2, p-diphenol: dioxygen oxidoreductases) is an extracellular enzyme found mainly in bacteria, fungi and plants. It has the ability to decolorize the hazardous synthetic dyes. Our study aimed to produce, purify, characterize and immobilize laccase from the fungus Phoma betae and its application in decolorization of synthetic dyes. Laccase was produced using both submerged and solid-state fermentations. Some inducers (ferulic acid, vertyl alcohol and CuSO4) for laccase production were used singly and in mixture. Significant increase in laccase production with all tested compounds was detected. Submerged fermentation induced laccase production than solid-state fermentation. Fast protein liquid chromatography (FPLC) used for laccase purification and through Sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS/PAGE) the molecular mass of the purified laccase was 37 kDa. Optimum temperature for lacasse activity was determined at 30°C using guaiacol assay. Enzyme was more stable at -4ºC than at -20 and -80ºC. Maximum laccase activity was found at pH 8. Effect of metal ions and inhibitors on laccase activity was studied. Ni2+ and K1+ induced laccase activity, while Na1+, Ag1+, Hg2+, Zn2+, Cu2+, EDTA and SDS decreased laccase activity with different ratios. Laccase was immobilized in alginate beads. Both free and immobilized laccase were used to decolorize five synthetic dyes (Eriochrome Cyanine R, Merantine Brilliant Yellow 8G, Rhodamine 123, Solvent Orange 20 and Solvent Yellow 47) at concentration 0.2 g dye/L. Immobilized laccase decolorized dyes with higher yields than free one in all tested dyes. Phoma betae laccase is an efficient biocatalyst for synthetic dye decolorization.
Alginate-laccase beads in the decolourization of indigo carmine

Małgorzata Białowąs,Beata Kończak,Stanisław Chałupnik,Joanna Kalka,Magdalena Cempa

DOI: https://doi.org/10.24425/aep.2024.149431

2024-03-12

Archives of Environmental Protection

Abstract:The aim of the study was to assess the feasibility of utilizing sodium alginate biopolymer as animmobilization carrier for laccase in the removal of indigo carmine (IC), an anionic dye. The main goal of this work was to optimize the decolourization process by selecting the appropriate immobilized enzyme dose per 1 mg of dye, as well as the process temperature. The effective immobilization of laccase using sodium alginate as a carrier was confirmed by Raman spectroscopy. An analysis of the size and geometric parameters of the alginate beads was also carried out. Tests of IC decolourization using alginate-laccase beads were conducted. Applying the most effective dose of the enzyme (320 mg of enzyme/1 mg of IC) made it possible to remove 92.5% of the dye over 40 days. The optimal temperature for the IC decolourization process, using laccase immobilized on sodium alginate, was established at 30-40oC. The obtained results indicate that laccase from Trametes versicolor immobilized on sodium alginate was capable of decolourizing the tested dye primarily based on mechanism of biocatalysis.

environmental sciences
Production of Laccase by Coriolus Versicolor and Its Application in Decolorization of Dyestuffs: (II). Decolorization of Dyes by Laccase Containing Fermentation Broth with or Without Self-Immobilized Mycelia.

JP Lin,W Lian,LM Xia,PL Cen

2003-01-01

Abstract:The capability of decolorization for commercial dyes by Coriolus versicolor fermentation broth containing laccase with or without immobilized mycelium was evaluated. With cell-free fermentation broth containing laccase, high decolorization ratio was achieved foracid orange 7, but not for the other dyes concerned. The immobilized mycelium was proved to be more efficient than the cell-free system. All the four dyestuffs studied were found being decolourized with certain extent by immobilized mycelium. The repeated-batch decolorization was carried out with satisfactory results. The experimental data showed that the continuous decolorization of wastewater from a printing and dyeing industry was possible by using the self-immobilized C. versicolor.
Purification and immobilization of laccase from Trichoderma harzianum strain HZN10 and its application in dye decolorization

Zabin K. Bagewadi,Sikandar I. Mulla,Harichandra Z. Ninnekar

DOI: https://doi.org/10.1016/j.jgeb.2017.01.007

2017-06-01

Journal of Genetic Engineering and Biotechnology

Abstract:In this study we report the purification of laccase produced by Trichoderma harzianum strain HZN10 (using wheat bran under solid state fermentation) and its application in decolorization of synthetic dyes. Extracellular laccase was purified to homogeneity by DEAE-Sepharose and Sephadex G-100 chromatography with specific activity of 162.5 U/mg and 25-fold purification. Purified laccase was immobilized in various entrapments like calcium alginate, copper alginate, calcium alginate-chitosan beads and sol-gel matrix. Optimization results revealed that the laccase immobilized in sol-gel was optimally active in wide pH range (4.0-7.0) and thermo-stable (50-70 °C) than free enzyme which was optimum at 50 °C and pH 6.0. Kinetic analysis showed K m of 0.5 mM and 2.0 mM and V max of 285 U/mg and 500 U/mg by free laccase and sol-gel immobilized laccase respectively with 2,2'-azino-bis(3-ethylbenzothiazoline-6-sulfonic acid) [ABTS] substrate. Free and immobilized laccase was employed for decolorization of three different synthetic dyes (malachite green, methylene blue and congo red). High performance liquid chromatography (HPLC) analysis results revealed that approximately 100% of malachite green, 90% of methylene blue and 60% of congo red dyes at initial concentration of 200 mg/L were decolorized within 16, 18 and 20 h, respectively by laccase immobilized in sol-gel matrix in the presence of 1-hydroxybenzotriazole (HBT) mediator. During the decolorization all three synthetic dyes showed various peaks on HPLC chromatogram indicating different by-products formation. Finally, phytotoxicity analysis results revealed that the by-products of synthetic dyes (formed during decolorization) showed less toxicity against Phaseolus mungo compared to untreated synthetic dyes.
Harnessing the hidden environmental power of Bjerkandera adusta laccase: Sustainable production, green immobilization, and eco-friendly decolorization of mixed azo dyes

Nevena Ilić,Jelena Filipović Tričković,Marija Milić,Katarina Mihajlovski

DOI: https://doi.org/10.1016/j.scp.2024.101747

IF: 5.464

2024-09-03

Sustainable Chemistry and Pharmacy

Abstract:This research unveils the untapped potential of laccase, derived from the Bjerkandera genus, utilizing it in an immobilized system aimed at detoxifying harmful azo dye effluents from the textile industry, thus contributing to environmental protection. Marking a pioneering achievement, we recorded the highest laccase activity at 94.52 U/g cultivating B. adusta 's mycelium on brewer's spent grain, enhanced with lignocellulosic waste, under meticulously optimized conditions −2.69 g of alkali-pretreated beech sawdust, 0.91 g of cypress cone, and 8-day incubation period. The harvested laccase was subjected to an immobilization process on alkali-pretreated beech sawdust, where, through optimization, we established the ideal conditions (30 mg of carrier, pH 7, and 3.5 h), achieving an immobilization efficiency of 72.24% with a residual activity of 57.64%. Remarkably, both free and immobilized forms of the B. adusta TMF1 laccase enzyme demonstrated formidable efficacy in decolorizing a mix of three distinct azo dyes (Orange G, Eriochrome Black T, and Congo Red), eliminating over 63% of the coloration within just 30 min. The immobilized laccase showed consistent performance across four decolorization cycles. Moreover, the breakdown products of the azo dye mix were analyzed using the HPLC method, complemented by evaluations of potential antimicrobial activity, phytotoxicity and cytotoxicity, revealing a non-toxic composition without cytotoxicity, highlighting the process's safety for environmental release. The significance of this research is reflected in the distinguished construction of a green biocatalyst acting as a stable and time-efficient in remediation of targeted azo dye pollution from the textile industry following the principles of circular economy.

chemistry, multidisciplinary,green & sustainable science & technology,environmental sciences
Production, Purification and Immobilization of Laccase from Trametes versicolor HBB 7328 for its Role in Decolorization of Textile Dyes

Nikita Goyat,Rajeev Kumar Kapoor,Baljeet Singh Saharan,Prexha Kapoor,Kajal Kumari,Namita Singh

DOI: https://doi.org/10.1007/s12088-024-01260-3

2024-04-02

Indian Journal of Microbiology

Abstract:Laccase is an extracellular enzyme that is widely used in the decolonization of textile dyes in waste water. The aim of our study was to isolate, purify, characterize and immobilize the laccase enzyme produced by Trametes versicolor HBB 7328. Purified laccase enzyme was immobilized in polyacrylamide gel to explore its ability in decolonization of textile dyes. Laccase purification process was carried out by fractionation using ammonium sulphate (80%) followed by DEAE Sepharose column (30 × 3 cm) chromatography method. Recovery and fold purification in this step were 27.35 and 16.23%. Purified laccase (named as LAC1) revealed its optimum activity at pH 5.0 and 35 °C temperature, and displayed remarkable stability in the range of 30–40 °C and in the pH range (pH 3.0–7.0). The single bands on SDS-PAGE represent the purity of LAC1 with molecular weight of 60 kDa. Both free and immobilized laccase assessed for their ability to decolorize textile dyes. Free laccase decolorized Methyl red to 72.705%, Reactive orange to 57.851%, Reactive blue to 37.231%, Bromophenol blue to 24.412% however Immobilized laccase decolorized Methyl red to 89.823%, Reactive orange to 63.151%, Reactive blue to 59.548%, Bromophenol blue to 49.421% respectively. This study proposes the role of laccase from Trametes versicolor HBB 7328 in decolonization of textile dyes.

microbiology,biotechnology & applied microbiology
Analysis of the feasibility of using biopolymers of different viscosities as immobilization carriers for laccase in synthetic dye removal

Małgorzata Białowąs,Beata Kończak,Stanisław Chałupnik,Joanna Kalka

DOI: https://doi.org/10.24425/aep.2024.149429

2024-03-12

Archives of Environmental Protection

Abstract:The main aim of the study was to assess the feasibility of using biopolymers of different viscosities (high, medium and low viscosity) as immobilization carriers for laccase in synthetic dye removal. The following dye solutions were decolorized: indigo carmine (IC, anionic dye), methylene blue (MB, cationic dye), and their mixture in a molar mass ratio MB/IC=0.69, using biopolymers of different viscosities as laccase immobilization carriers. Toxicity tests were also carried out to assess the toxicity of the post-decolorization samples. Decolorization tests showed that the main decolorization mechanism depends on the dye class. The removal of IC (max. total removal efficiency 72.15%) was mainly by biocatalysis. The mechanism of the MB decolorization process was mainly by sorption on alginate beads, and the efficiency of enzymatic removal was low. However, the highest efficiency of MB decolorization (45.80%) was obtained for beads prepared using the high viscosity alginate when decolorization occurred by both sorption and biocatalysis. The results of mixture decolorization tests differ from the results obtained for single dyes.The results showed differences in the efficiency of the dye sorption process depending on the alginate used for immobilization. Moreover, the varying mechanisms of dye removal from the dye mixture were confirmed by toxicity tests. The occurrence of both biocatalysis and sorption promotes reduced toxicity

environmental sciences
Immobilized laccase: an effective biocatalyst for industrial dye degradation from wastewater

Shifa Naseem,Raja Singh Rawal,Deepshikha Pandey,Sunil Kumar Suman

DOI: https://doi.org/10.1007/s11356-023-28275-5

IF: 5.8

2023-06-28

Environmental Science and Pollution Research

Abstract:Environmental concerns due to the release of industrial wastewater contaminated with dyes are becoming more and more intense with the increasing industrialization. Decolorization of industrial effluents has become the top priority due to the continuous demand for color-free discharge into the receiving water bodies. Different dye removal techniques have been developed, among which biodegradation by laccase enzyme is competitive. Laccase, as a green catalyst, has a high catalytic activity, generates less toxic by-products, and has been extensively researched in the field of remediation of dyes. However, laccase’s significant catalytic activity could only be achieved after an effective immobilization step. Immobilization helps strengthen and stabilize the protein structure of laccase, thus enhancing its functional properties. Additionally, the reusability of immobilized laccase makes it an attractive alternative to traditional dye degradation technologies and in the realistic applications of water treatment, compared with free laccase. This review has elucidated different methods and the carriers used to immobilize laccase. Furthermore, the role of immobilized laccase in dye remediation and the prospects have been discussed.

environmental sciences
Synergistic removal of dyes by Myrothecium verrucaria immobilization on a chitosan–Fe membrane

yuezhong wen,ying liang,chensi shen,hongkai wang,dongmei fu

DOI: https://doi.org/10.1039/c5ra11320b

IF: 4.036

2015-01-01

RSC Advances

Abstract:A green efficient strategy for the combination of biodegradation and adsorption methods is urgently desired nowadays to degrade dyes in an economical and effective way. In this study, a kind of novel, environmentally friendly and efficient hybrid for the fungus and chitosan-Fe membrane has been fabricated by the alginate approach. Myrothecium verrucaria I-5 and C-1, deuteromycete fungi capable of producing laccase to degrade dyes, have been used. It is found that the chitosan-Fe membrane can excellently immobilize the fungi mycelia and enzyme, and after the immobilization, the fungi and enzyme still maintain a high activity after the dye decolorization. Also, the immobilized fungi membranes have been proved to have a high efficiency for dye decolorization. Simultaneously, the decolorization ability of the crude enzymes, which are extracted from I-5 and C-1 medium, and the decolorization ability of chitosan-Fe membrane are also investigated, respectively. The results demonstrate that the dyes can be removed by the fungi and the membrane synergistically. In addition, different kinds of dyes are successfully removed with chitosan-Fe immobilized fungi membranes. These results demonstrate that dyes are first adsorbed on the chitosan-Fe membrane, decreasing the toxicity to the fungus, and then bio-degraded by the laccase produced from the fungi on the membrane.
Decolorization and detoxification of synthetic dye compounds by laccase immobilized in vault nanoparticles

Yifan Gao,Meng Wang,Kshitija Shah,Shashank Singh Kalra,Leonard H Rome,Shaily Mahendra,Leonard H. Rome

DOI: https://doi.org/10.1016/j.biortech.2022.127040

IF: 11.4

2022-05-01

Bioresource Technology

Abstract:This study presents an eco-friendly and efficient technology, using immobilized enzymes, vault-encapsulated laccases (vlaccase), for decolorization and detoxification of dyes. Vault encapsulation remarkably improved the performance of laccase at industrially relevant conditions, including neutral to alkaline pH and relatively high temperatures. Two representative anthraquinone and azo dyes, Reactive Blue 19 and Acid Orange 7, respectively, were rapidly decolorized (72% and 80%) by vlaccase treatment while natural laccase (nlaccase) achieved 40% and 32% decolorization. The toxicity of treated and untreated dyes was tested on model bacterial, algal, and insect cells. The inhibitory effects of dyes towards selected bacteria were reduced in vlaccase-treated samples. The chlorophyll synthesis in algae was less inhibited by dyes after vlaccase treatment. Furthermore, the toxicity of dye degradation products to insect cells was significantly mitigated in the vlaccase group. Collectively, these results indicate that vlaccase is a stable and strong enzymatic system for removing dyes from waters.

energy & fuels,biotechnology & applied microbiology,agricultural engineering
Toward a zero waste approach: Utilization of sugarcane bagasse for dye removal and multienzymes production

Uroosa Ejaz,Ayaz Taj,Muhammad Sohail,Abdullah K. Alanazi,Hala M. Abo‐dief

DOI: https://doi.org/10.1002/jobm.202300529

2023-12-09

Journal of Basic Microbiology

Abstract:Global production of sugarcane bagasse (SB) by sugar industries exceeds more than 100 tons per annum. SB is rich in lignin and polysaccharide and hence can serve as a low‐cost energy and carbon source for the growth of industrially important microorganism. However, various other applications of SB have also been investigated. In this study, SB was used as an adsorbent to remove an azo dye, malachite green. Subsequently, the dye‐adsorbed SB was fermented by Trametes pubescens MB 89 for the production of laccase enzyme. The fungal pretreated SB was further utilized as a substrate for the simultaneous production of multiple plant cell wall degrading enzymes including, cellulase, xylanase, pectinase, and amylase by thermophilic bacterial strains. Results showed that 0.1% SB removed 97.04% malachite green at 30°C after 30 min from a solution containing 66 ppm of the dye. Fermentation of the dye‐adsorbed SB by T. pubescens MB 89 yielded 667.203 IU mL−1 laccase. Moreover, Brevibacillus borstelensis UE10 produced 38.41 and 18.6 IU mL−1 β‐glucosidase and pectinase, respectively, by using fungal‐pretreated SB. Cultivation of B. borstelensis UE27 in the medium containing the same substrate yielded 32.14 IU mL−1 of endoglucanase and 27.23 IU mL−1 of β‐glucosidase. Likewise, Neobacillus sedimentimangrovi UE25 could produce a mix of β‐glucosidase (37.24 IU mL−1), xylanase (18.65 IU mL−1) and endoglucanase (26.65 IU mL−1). Hence, this study led to the development of a method through which dye‐containing textile effluent can be treated by SB along with the production of industrially important enzymes.

microbiology
Untersuchungen zur Frage einer Abhängigkeit der Alkoholwirkung von der Tageszeit

J. Rutenfranz,R. Singer

DOI: https://doi.org/10.1007/BF00693571

1967-03-01

Internationale Zeitschrift für Angewandte Physiologie Einschliesslich Arbeitsphysiologie

Abstract:
Evaluation of Lacc134 Oxidoreductase of Ganoderma multistipitatum in Detoxification of Dye Wastewater under Different Nutritional Conditions

Eman A. Alhomaidi,Aisha Umar,Salam S. Alsharari,Sami Alyahya

DOI: https://doi.org/10.3390/microbiolres14030095

2023-09-18

Microbiology Research

Abstract:In the present study, we investigated the effects of different carbon sources (glucose, sucrose, and maltose) on laccase production from mycelium of Ganoderma multistipitatum grown on malt extract agar plates. The preliminary screening test was performed on the guaiacol plate, where a maroon brown zone formed after laccase oxidation. A few pure mycelial discs of Ganoderma species were transferred into submerged fermentation nutrient broth. The nutrient medium of submerged fermentation at 20 g of glucose revealed the highest laccase activities (2300 U/L) than other carbon sources. The interesting results also shown by inorganic NaNO3 in the production of maximum laccase (7800 ± 1.1 U/L). The organic nitrogen inducer, namely yeast extract, exhibited 5834 U/L laccase activity and a potential source of laccase secretion. The results concluded that C and N inducers enhanced the laccase production. This production process is eco-friendly and effective in the removal of dye from water. Laccase from the cultural broth was partially purified by SDS-PAGE for molecular weight determination, while Native-PAGE confirmed the laccase band after staining with guaiacol. The Km and Vmax values of Lacc134 were 1.658 mm and 2.452 mM min−1, respectively. The Lacc134 of this study effectively removed the Remazol Brilliant Blue R (RBBR) dye (extensively used in textile industries and wastewater). For dye removal capacity, 2.0 mg, 4.0 mg, 5.0 mg, and 6.0 mg were used, from which 6.0 mg was most effective in removal (85% and 88%) dye concentration in 1st and 2nd h interval treatment, respectively. Total organic carbon (TOC) quantity after dye removal percentage in the first- and second-hour time interval was 62% and 89%, respectively, at 30 g glucose. According to the experimental finding of this study, the breakdown products catalyzed by Lacc134 are less hazardous due to lower molecular weight than the dye itself.
Laccase producing bacteria influenced the high decolorization of textile azo dyes with advanced study

Rajivgandhi Govindan,Chenthis Kanisha Chelliah,Muthuchamy Maruthupandy,Shine Kadaikunnan,Reya Issac,Sevanan Murugan,Wen-Jun Li,Jamal M. Khaled,Sami A. Alyahya,Naiyf S. Alharbi

DOI: https://doi.org/10.1016/j.envres.2021.112211

IF: 8.3

2022-05-01

Environmental Research

Abstract:Recent year, bacterial laccases are increasing interest in the field of industry and environmental applications especially decolorization of azo dyes. In industry, the dyes are present in stable nature including chemicals and lights. Due to these defects, the novel approaches are needed to removal of dyes before discharging into the environment. Among the various technologies, biological treatment methods and their strategies are very important, because of the decolorization and detoxification. Consecutively, biological mediated dyes removal are emerged with high potential especially microbes. Microbial laccases creates up new opportunities for their commercial applications. In this study, laccases were produced from Bacillus cereus (B. Cereus) and Pseudomonas parafulva (P. parafulva) by sub merged fermentation. For immobilization, the produced laccases were subjected to purify using 80% saturated ammonium sulphate and followed by dialysis. Then, crude laccases were immobilized through copper-alginate entrapment method. The maximum immobilized enzyme activity of the immobilized laccases were shown pH 8 at 50 °C and pH 7 at 40 °C for B. Cereus and P. parafulva respectively. In contrast, the normal enzyme activity was pH 10 at 40 °C and pH 8 at 40 °C were indicated for Bacillus cereus and P. parafulva respectively. Next, the free and immobilized laccases were performed the decolorization of three azo dyes T-blue, yellow GR and orange 3R, and exhibited that the 91.69 and 89.21% of Orange 3R were completely decolorized by both the B. Cereus and P. parafulva laccases when compared with free laccases enzymes. The confirmation of decolorization was monitored by UV-vis spectroscopy and FTIR spectroscopy, which clearly confirm the changes of peaks when compared with normal laccases. Finally, we have concluded that the B. Cereus and P. parafulva laccases are very important in azo dye decolorization and these used in future biological treatment of dyeing effluents.

environmental sciences,public, environmental & occupational health
Laccase immobilized on functionalized cellulose nanofiber/alginate composite hydrogel for efficient bisphenol A degradation from polluted water

Feng Zhang,Mengying Lian,A. Alhadhrami,Mina Huang,Bin Li,Gaber A. M. Mersal,Mohamed M. Ibrahim,Miaojun Xu

DOI: https://doi.org/10.1007/s42114-022-00476-5

IF: 11.806

2022-04-30

Advanced Composites and Hybrid Materials

Abstract:Enzyme immobilization technique has a broad application prospect in the area of biotechnology, biochemistry, and environmental remediation. In this study, the composite hydrogel consisting of dopamine functionalized cellulose nanofiber and alginate was fabricated for immobilization of laccase. Infrared spectra, scanning electron micrographs, and energy dispersive X-ray analysis demonstrated that the laccase molecules were covalently immobilized onto the surface of composite hydrogel. The immobilized laccase exhibited the highest enzymatic activity about 462 U·g−1. Compared with free laccase, the pH, temperature, and storage stabilities of immobilized laccase were improved dramatically. Moreover, the immobilized enzyme can be easily separated from reaction system and reused. It retained 79.6% of its initial activity after 14 cycles of operation. Immobilized laccase was utilized for efficient degradation of bisphenol A (BPA) from polluted water, and the affecting factors on BPA removal efficiency were analyzed. Greater than 82% of BPA was removed under optimum conditions. A small amount of ABTS was added into BPA degradation; the removal efficiency had reached up to 98.7%. Results indicated that the immobilized laccase has great potential for industrial applications.Graphical abstract

nanoscience & nanotechnology,materials science, composites

Monotonizing linear programs with up to two nonzeroes per column

Efficient immobilization of highly stable Bacillus amyloliquefaciens spore laccase for biodecolorization of textile dyes in water

Immobilization of laccase for biotechnology applications

Dye decolorization and detoxification by laccase immobilized on porous glass beads

[Decolorization of Dyestuff and Dying Waste Water by Laccase Solution with Self-Flocculent Mycelial Pellets of Coriolus Versicolor].

Construction of immobilized laccase hydrogels via sodium alginate-dopamine/polyethylene glycol and its efficient degradation of dyeing wastewater

Production, Purification, Characterization and Immobilization of Laccase from Phoma betae and its Application in Synthetic Dyes Decolorization

Alginate-laccase beads in the decolourization of indigo carmine

Production of Laccase by Coriolus Versicolor and Its Application in Decolorization of Dyestuffs: (II). Decolorization of Dyes by Laccase Containing Fermentation Broth with or Without Self-Immobilized Mycelia.

Purification and immobilization of laccase from Trichoderma harzianum strain HZN10 and its application in dye decolorization

Harnessing the hidden environmental power of Bjerkandera adusta laccase: Sustainable production, green immobilization, and eco-friendly decolorization of mixed azo dyes

Production, Purification and Immobilization of Laccase from Trametes versicolor HBB 7328 for its Role in Decolorization of Textile Dyes

Analysis of the feasibility of using biopolymers of different viscosities as immobilization carriers for laccase in synthetic dye removal

Immobilized laccase: an effective biocatalyst for industrial dye degradation from wastewater

Synergistic removal of dyes by Myrothecium verrucaria immobilization on a chitosan–Fe membrane

Decolorization and detoxification of synthetic dye compounds by laccase immobilized in vault nanoparticles

Toward a zero waste approach: Utilization of sugarcane bagasse for dye removal and multienzymes production

Untersuchungen zur Frage einer Abhängigkeit der Alkoholwirkung von der Tageszeit

Evaluation of Lacc134 Oxidoreductase of Ganoderma multistipitatum in Detoxification of Dye Wastewater under Different Nutritional Conditions

Laccase producing bacteria influenced the high decolorization of textile azo dyes with advanced study

Laccase immobilized on functionalized cellulose nanofiber/alginate composite hydrogel for efficient bisphenol A degradation from polluted water