Optimal geometric parameters of ordered arrays of nanoprisms for enhanced sensitivity in localized plasmon based sensors.

N. Michieli,B. Kalinic,C. Scian,T. Cesca,G. Mattei

DOI: https://doi.org/10.1016/j.bios.2014.10.064

2015-03-15

Abstract:

What problem does this paper attempt to address?

Adaptive laboratory evolution and transcriptomics-guided engineering of Escherichia coli for increased isobutanol tolerance

Young Seo Jang,Jungwoo Yang,Jae Kyun Kim,Tae In Kim,Yong-Cheol Park,In Jung Kim,Kyoung Heon Kim

DOI: https://doi.org/10.1002/biot.202300270

Abstract:As a renewable energy from biomass, isobutanol is considered as a promising alternative to fossil fuels. To biotechnologically produce isobutanol, strain development using industrial microbial hosts, such as Escherichia coli, has been conducted by introducing a heterologous isobutanol synthetic pathway. However, the toxicity of produced isobutanol inhibits cell growth, thereby restricting improvements in isobutanol titer, yield, and productivity. Therefore, the development of robust microbial strains tolerant to isobutanol is required. In this study, isobutanol-tolerant mutants were isolated from two E. coli parental strains, E. coli BL21(DE3) and MG1655(DE3), through adaptive laboratory evolution (ALE) under high isobutanol concentrations. Subsequently, 16 putative genes responsible for isobutanol tolerance were identified by transcriptomic analysis. When overexpressed in E. coli, four genes (fadB, dppC, acs, and csiD) conferred isobutanol tolerance. A fermentation study with a reverse engineered isobutanol-producing E. coli JK209 strain showed that fadB or dppC overexpression improved isobutanol titers by 1.5 times, compared to the control strain. Through coupling adaptive evolution with transcriptomic analysis, new genetic targets utilizable were identified as the basis for the development of an isobutanol-tolerant strain. Thus, these new findings will be helpful not only for a fundamental understanding of microbial isobutanol tolerance but also for facilitating industrially feasible isobutanol production.
Adaptive laboratory evolution of Yarrowia lipolytica improves ferulic acid tolerance

Zedi Wang,Linlin Zhou,Minrui Lu,Yuwei Zhang,Samina Perveen,Huarong Zhou,Zhiqiang Wen,Zhaoxian Xu,Mingjie Jin

DOI: https://doi.org/10.1007/s00253-021-11130-3

IF: 5

2021-02-01

Applied Microbiology and Biotechnology

Abstract:Yarrowia lipolytica strain is a promising cell factory for the conversion of lignocellulose to biofuels and bioproducts. Despite the inherent robustness of this strain, further improvements to lignocellulose-derived inhibitors toxicity tolerance of Y. lipolytica are also required to achieve industrial application. Here, adaptive laboratory evolution was employed with increasing concentrations of ferulic acid. The adaptive laboratory evolution experiments led to evolve Y. lipolytica strain yl-XYL + *FA*4 with increased tolerance to ferulic acid as compared to the parental strain. Specifically, the evolved strain could tolerate 1.5 g/L ferulic acid, whereas 0.5 g/L ferulic acid could cause about 90% lethality of the parental strain. Transcriptome analysis of the evolved strain revealed several targets underlying toxicity tolerance enhancements. YALI0_E25201g, YALI0_F05984g, YALI0_B18854g, and YALI0_F16731g were among the highest upregulated genes, and the beneficial contributions of these genes were verified via reverse engineering. Recombinant strains with overexpressing each of these four genes obtained enhanced tolerance to ferulic acid as compared to the control strain. Fortunately, recombinant strains with overexpression of YALI0_E25201g, YALI0_B18854g, and YALI0_F16731g individually also obtained enhanced tolerance to vanillic acid. Overall, this work demonstrated a whole strain improvement cycle by “non-rational” metabolic engineering and presented new targets to modify Y. lipolytica for microbial lignocellulose valorization.Key points• Adaptive evolution improved the ferulic acid tolerance of Yarrowia lipolytica• Transcriptome sequence was applied to analyze the ferulic acid tolerate strain• Three genes were demonstrated for both ferulic acid and vanillic acid tolerance

biotechnology & applied microbiology
An integrated computational and experimental study for overproducing fatty acids in Escherichia coli

Sridhar Ranganathan,Ting Wei Tee,Anupam Chowdhury,Ali R. Zomorrodi,Jong Moon Yoon,Yanfen Fu,Jacqueline V. Shanks,Costas D. Maranas

DOI: https://doi.org/10.1016/j.ymben.2012.08.008

IF: 8.4

2012-11-01

Metabolic Engineering

Abstract:Increasing demands for petroleum have stimulated sustainable ways to produce chemicals and biofuels. Specifically, fatty acids of varying chain lengths (C₆-C₁₆) naturally synthesized in many organisms are promising starting points for the catalytic production of industrial chemicals and diesel-like biofuels. However, bio-production of fatty acids from plants and other microbial production hosts relies heavily on manipulating tightly regulated fatty acid biosynthetic pathways. In addition, precursors for fatty acids are used along other central metabolic pathways for the production of amino acids and biomass, which further complicates the engineering of microbial hosts for higher yields. Here, we demonstrate an iterative metabolic engineering effort that integrates computationally driven predictions and metabolic flux analysis techniques to meet this challenge. The OptForce procedure was used for suggesting and prioritizing genetic manipulations that overproduce fatty acids of different chain lengths from C₆ to C₁₆ starting with wild-type E. coli. We identified some common but mostly chain-specific genetic interventions alluding to the possibility of fine-tuning overproduction for specific fatty acid chain lengths. In accordance with the OptForce prioritization of interventions, fabZ and acyl-ACP thioesterase were upregulated and fadD was deleted to arrive at a strain that produces 1.70 g/L and 0.14 g fatty acid/g glucose (∼39% maximum theoretical yield) of C₁₄₋₁₆ fatty acids in minimal M9 medium. These results highlight the benefit of using computational strain design and flux analysis tools in the design of recombinant strains of E. coli to produce free fatty acids.

biotechnology & applied microbiology
Improving Ethanol Tolerance of Escherichia Coli by Rewiring Its Global Regulator Camp Receptor Protein (CRP).

Huiqing Chong,Lei Huang,Jianwei Yeow,Ivy Wang,Hongfang Zhang,Hao Song,Rongrong Jiang

DOI: https://doi.org/10.1371/journal.pone.0057628

IF: 3.7

2013-01-01

PLoS ONE

Abstract:A major challenge in bioethanol fermentation is the low tolerance of the microbial host towards the end product bioethanol. Here we report to improve the ethanol tolerance of E. coli from the transcriptional level by engineering its global transcription factor cAMP receptor protein (CRP), which is known to regulate over 400 genes in E. coli. Three ethanol tolerant CRP mutants (E1- E3) were identified from error-prone PCR libraries. The best ethanol-tolerant strain E2 (M59T) had the growth rate of 0.08 h(-1) in 62 g/L ethanol, higher than that of the control at 0.06 h(-1). The M59T mutation was then integrated into the genome to create variant iE2. When exposed to 150 g/l ethanol, the survival of iE2 after 15 min was about 12%, while that of BW25113 was <0.01%. Quantitative real-time reverse transcription PCR analysis (RT-PCR) on 444 CRP-regulated genes using OpenArray® technology revealed that 203 genes were differentially expressed in iE2 in the absence of ethanol, whereas 92 displayed differential expression when facing ethanol stress. These genes belong to various functional groups, including central intermediary metabolism (aceE, acnA, sdhD, sucA), iron ion transport (entH, entD, fecA, fecB), and general stress response (osmY, rpoS). Six up-regulated and twelve down-regulated common genes were found in both iE2 and E2 under ethanol stress, whereas over one hundred common genes showed differential expression in the absence of ethanol. Based on the RT-PCR results, entA, marA or bhsA was knocked out in iE2 and the resulting strains became more sensitive towards ethanol.
Improving acid resistance of Escherichia coli base on the CfaS-mediated membrane engineering strategy derived from extreme acidophile

Wenbo Hu,Yanjun Tong,Junjie Liu,Panyan Chen,Hailin Yang,Shoushuai Feng

DOI: https://doi.org/10.3389/fbioe.2023.1158931

IF: 5.7

2023-03-22

Frontiers in Bioengineering and Biotechnology

Abstract:Industrial microorganisms used for the production of organic acids often face challenges such as inhibited cell growth and reduced production efficiency due to the accumulation of acidic metabolites. One promising way for improving the acid resistance of microbial cells is to reconstruct their membranes. Herein, the overexpression of cfa 2 from extreme acidophile endowed E. coli with high-performance on resistance to the acid stress. The engineered strain M1-93- Accfa 2, constructed by CRISPR/Cas9-mediated chromosome integration, also exhibited a significantly higher resistance to severe acid stress. The analysis of fatty acid profiles indicated that the proportion of Cy-19:0 in the cell membrane of M1-93- Accfa 2 increased by 5.26 times compared with the control, while the proportion of C18:1w9c decreased by 5.81 times. Correspondingly, the permeability and fluidity of the membrane decreased significantly. HPLC analysis demonstrated that the contents of intracellular glutamic acid, arginine, methionine and aspartic acid of M1-93- Accfa 2 were 2.59, 2.04, 22.07 and 2.65 times that of the control after environmental acidification, respectively. Meanwhile, transmission electron microscopy observation indicated that M1-93- Accfa 2 could maintain a plumper cell morphology after acid stimulation. M1-93- Accfa 2 also exhibited higher-performance on the resistance to organic acids, especially succinic acid stress. These results together demonstrated the great potential of M1-93- Accfa 2 constructed here in the production of organic acids.

multidisciplinary sciences
An Evolved Strain of the Oleaginous Yeast Rhodotorula toruloides, Multi-Tolerant to the Major Inhibitors Present in Lignocellulosic Hydrolysates, Exhibits an Altered Cell Envelope

Mónica A. Fernandes,Marta N. Mota,Nuno T. Faria,Isabel Sá-Correia

DOI: https://doi.org/10.3390/jof9111073

2023-11-02

Journal of Fungi

Abstract:The presence of toxic compounds in lignocellulosic hydrolysates (LCH) is among the main barriers affecting the efficiency of lignocellulose-based fermentation processes, in particular, to produce biofuels, hindering the production of intracellular lipids by oleaginous yeasts. These microbial oils are promising sustainable alternatives to vegetable oils for biodiesel production. In this study, we explored adaptive laboratory evolution (ALE), under methanol- and high glycerol concentration-induced selective pressures, to improve the robustness of a Rhodotorula toruloides strain, previously selected to produce lipids from sugar beet hydrolysates by completely using the major C (carbon) sources present. An evolved strain, multi-tolerant not only to methanol but to four major inhibitors present in LCH (acetic acid, formic acid, hydroxymethylfurfural, and furfural) was isolated and the mechanisms underlying such multi-tolerance were examined, at the cellular envelope level. Results indicate that the evolved multi-tolerant strain has a cell wall that is less susceptible to zymolyase and a decreased permeability, based on the propidium iodide fluorescent probe, in the absence or presence of those inhibitors. The improved performance of this multi-tolerant strain for lipid production from a synthetic lignocellulosic hydrolysate medium, supplemented with those inhibitors, was confirmed.

microbiology,mycology
Schistosoma kisumuensis n. sp. (Digenea: Schistosomatidae) from murid rodents in the Lake Victoria Basin, Kenya and its phylogenetic position within the S. haematobium species group

B. Hanelt,S. Brant,M. Steinauer,Giuseppe Maina,Joseph M. Kinuthia,L. E. Agola,I. Mwangi,B. Mungai,Martin W. Mutuku,G. Mkoji,E. Loker

DOI: https://doi.org/10.1017/S003118200900643X

2009-07-02

Parasitology

Abstract:SUMMARY Schistosoma kisumuensis n. sp. is described based on 6 adult males and 2 adult females collected from the circulatory system of 3 murid rodent species, Pelomys isseli, Mastomys natalensis, and Dasymys incomtus. Specimens were collected from a single location, Nyabera Swamp, in Kisumu, Kenya in the Lake Victoria Basin. This new species is morphologically similar to members of the S. haematobium group, currently represented by 8 species parasitizing artiodactyls and primates, including humans. Schistosoma kisumuensis differs from these species by producing relatively small Schistosoma intercalatum-like eggs (135·2×52·9 μm) with a relatively small length to width ratio (2·55). Comparison of approximately 3000-base-pair sequences of nuclear rDNA (partial 28S) and mtDNA (partial cox1, nad6, 12S) strongly supports the status of S. kisumuensis as a new species and as a sister species of S. intercalatum. The cox1 genetic distance between these two species (6·3%) is comparable to other pairwise comparisons within the S. haematobium group. Separation of the Congo River and Lake Victoria drainage basins is discussed as a possible factor favoring the origin of this species.
Metabolic and evolutionary responses of Clostridium thermocellum to genetic interventions aimed at improving ethanol production

Evert K Holwerda,Daniel G Olson,Natalie M Ruppertsberger,David M Stevenson,Sean J L Murphy,Marybeth I Maloney,Anthony A Lanahan,Daniel Amador-Noguez,Lee R Lynd

DOI: https://doi.org/10.1186/s13068-020-01680-5

2020-03-10

Abstract:Background: Engineering efforts targeted at increasing ethanol by modifying the central fermentative metabolism of Clostridium thermocellum have been variably successful. Here, we aim to understand this variation by a multifaceted approach including genomic and transcriptomic analysis combined with chemostat cultivation and high solids cellulose fermentation. Three strain lineages comprising 16 strains total were examined. Two strain lineages in which genes involved in pathways leading to organic acids and/or sporulation had been knocked out resulted in four end-strains after adaptive laboratory evolution (ALE). A third strain lineage recapitulated mutations involving adhE that occurred spontaneously in some of the engineered strains. Results: Contrary to lactate dehydrogenase, deleting phosphotransacetylase (pta, acetate) negatively affected steady-state biomass concentration and caused increased extracellular levels of free amino acids and pyruvate, while no increase in ethanol was detected. Adaptive laboratory evolution (ALE) improved growth and shifted elevated levels of amino acids and pyruvate towards ethanol, but not for all strain lineages. Three out of four end-strains produced ethanol at higher yield, and one did not. The occurrence of a mutation in the adhE gene, expanding its nicotinamide-cofactor compatibility, enabled two end-strains to produce more ethanol. A disruption in the hfsB hydrogenase is likely the reason why a third end-strain was able to make more ethanol. RNAseq analysis showed that the distribution of fermentation products was generally not regulated at the transcript level. At 120 g/L cellulose loadings, deletions of spo0A, ldh and pta and adaptive evolution did not negatively influence cellulose solubilization and utilization capabilities. Strains with a disruption in hfsB or a mutation in adhE produced more ethanol, isobutanol and 2,3-butanediol under these conditions and the highest isobutanol and ethanol titers reached were 5.1 and 29.9 g/L, respectively. Conclusions: Modifications in the organic acid fermentative pathways in Clostridium thermocellum caused an increase in extracellular pyruvate and free amino acids. Adaptive laboratory evolution led to improved growth, and an increase in ethanol yield and production due a mutation in adhE or a disruption in hfsB. Strains with deletions in ldh and pta pathways and subjected to ALE demonstrated undiminished cellulolytic capabilities when cultured on high cellulose loadings.
Genome-wide Escherichia coli stress response and improved tolerance towards industrially relevant chemicals

Martin Holm Rau,Patricia Calero,Rebecca M. Lennen,Katherine S. Long,Alex T. Nielsen

DOI: https://doi.org/10.1186/s12934-016-0577-5

IF: 6.352

2016-10-13

Microbial Cell Factories

Abstract:BackgroundEconomically viable biobased production of bulk chemicals and biofuels typically requires high product titers. During microbial bioconversion this often leads to product toxicity, and tolerance is therefore a critical element in the engineering of production strains.ResultsHere, a systems biology approach was employed to understand the chemical stress response of Escherichia coli, including a genome-wide screen for mutants with increased fitness during chemical stress. Twelve chemicals with significant production potential were selected, consisting of organic solvent-like chemicals (butanol, hydroxy-γ-butyrolactone, 1,4-butanediol, furfural), organic acids (acetate, itaconic acid, levulinic acid, succinic acid), amino acids (serine, threonine) and membrane-intercalating chemicals (decanoic acid, geraniol). The transcriptional response towards these chemicals revealed large overlaps of transcription changes within and between chemical groups, with functions such as energy metabolism, stress response, membrane modification, transporters and iron metabolism being affected. Regulon enrichment analysis identified key regulators likely mediating the transcriptional response, including CRP, RpoS, OmpR, ArcA, Fur and GadX. These regulators, the genes within their regulons and the above mentioned cellular functions therefore constitute potential targets for increasing E. coli chemical tolerance. Fitness determination of genome-wide transposon mutants (Tn-seq) subjected to the same chemical stress identified 294 enriched and 336 depleted mutants and experimental validation revealed up to 60 % increase in mutant growth rates. Mutants enriched in several conditions contained, among others, insertions in genes of the Mar-Sox-Rob regulon as well as transcription and translation related gene functions.ConclusionsThe combination of the transcriptional response and mutant screening provides general targets that can increase tolerance towards not only single, but multiple chemicals.

biotechnology & applied microbiology
Improvement of environmental tolerance of E. coli through biological membrane engineering to boost succinic acid conversion

Yujia Jiang,Runze Pan,Yuxuan Tao,Wenlong Xiao,Wankui Jiang,Fengxue Xin,Wenming Zhang,Min Jiang

DOI: https://doi.org/10.1016/j.bej.2023.109026

IF: 3.9

2023-07-04

Biochemical Engineering Journal

Abstract:Escherichia coli has been applied as an important platform for carboxylic acids production, such as succinic acid (SA). However, carboxylic acids will cause membrane damage, inhibiting E. coli growth and metabolism, which has been considered as one of the main obstacles to large-scale SA production. In this study, the approach of biological membrane engineering was attempted to improve the environmental tolerance of E. coli , which resulted from the change of membrane lipid composition. After introduction of whiB with function of stress responses and cell division, and cti with capability of trans unsaturated fatty acids biosynthesis, the SA production in the 5-L fermenter reached 80.0 g/L, which was 37.0% higher than that of the control group. Further incorporating fabA and fabB to promote unsaturated fatty acid biosynthesis of membrane, the engineered E. coli showed higher survival rate and better metabolic performance under the harsh environments, including exogenous octanoic acid (C8) addition, high osmotic pressure and low pH. The change of membrane composition contributed to the stronger resistance of E. coli , in particular the SA production still reached 29.9 g/L with 0.79 g/g of yield under low pH (pH 5.6) in the 5-L fermenter. The membrane engineering strategy is proved to be effective in improving strain robustness, paving the way to boost the large-scale production of carboxylic acids.

engineering, chemical,biotechnology & applied microbiology
Adaptive Laboratory Evolution of Tolerance to Dicarboxylic Acids in Saccharomyces Cerevisiae.

Rui Pereira,Yongjun Wei,Elsayed Mohamed,Mohammad Radi,Carl Malina,Markus J Herrgård,Adam M Feist,Jens Nielsen,Yun Chen

DOI: https://doi.org/10.1016/j.ymben.2019.09.008

IF: 8.4

2019-01-01

Metabolic Engineering

Abstract:Improving the growth phenotypes of microbes in high product concentrations is an essential design objective in the development of robust cell factories. However, the limited knowledge regarding tolerance mechanisms makes rational design of such traits complicated. Here, adaptive laboratory evolution was used to explore the tolerance mechanisms that Saccharomyces cerevisiae can evolve in the presence of inhibiting concentrations of three dicarboxylic acids: glutaric acid, adipic acid and pimelic acid. Whole-genome sequencing of tolerant mutants enabled the discovery of the genetic changes behind tolerance and most mutations could be linked to the up-regulation of multidrug resistance transporters. The amplification of QDR3, in particular, was shown to confer tolerance not only to the three dicarboxylic acids investigated, but also towards muconic acid and glutaconic acid. In addition to increased acid tolerance, QDR3 overexpression also improved the production of muconic acid in the context of a strain engineered for producing this compound.
Emulsion-based evolution of Escherichia coli for higher growth yield on D-xylose identifies central role of cyclic AMP

James S. Orr,Edwin Zen,Xiaoyi Wang,Christopher V. Rao

DOI: https://doi.org/10.1007/s43393-022-00136-1

2022-10-06

Systems Microbiology and Biomanufacturing

Abstract:D -xylose is an abundant sugar found in plant biomass and can be used as a renewable feedstock for the microbial production of diverse biofuels and bioproducts. However, D-xylose metabolism is slow in many industrial microorganisms, at least as compared to glucose metabolism. Not surprisingly, a number of approaches have been developed for improving D -xylose metabolism in diverse microorganisms. In this work, we applied a previously developed evolution strategy based on media-in-oil emulsions for improving the growth yield of Escherichia coli NCM3722 on D -xylose. After 30 rounds of evolutions, we isolated multiple mutants with increased growth yield on D -xylose. In addition, we also observed similar increases in the growth rate. Three mutants were selected for whole-genome sequencing. Two mutants had an amber stop mutation in adenylate cyclase, which truncates nearly 60% of the enzyme. However, the ability of this mutant to grow on xylose indicated that truncated enzyme, lacking the C-terminal regulatory domain, is still active. The other mutant had a point mutation in the cyclic AMP receptor protein (CRP), near the high affinity binding site for cyclic AMP. Both mutations, when introduced into wild type E. coli , were able to increase the growth yields at levels similar to the isolated mutants. In addition to D -xylose, these mutant strains and their genetic mimics also exhibited higher growth rates and yields on glucose, lactose, and L -arabinose. These results suggest that the improved growth rates and yields are due to changes in the production and sensing of intracellular cyclic AMP concentrations and also suggest native concentrations are suboptimal with respect to the growth rate and yield under the growth conditions tested. Collectively, these results may prove useful for engineering strains of E. coli for high-density fermentations or protein production.
It depends whose data are being shared: considerations for genomic data sharing policies

J. Robinson,M. J. Slashinski,E. Chiao,A. McGuire

DOI: https://doi.org/10.1093/jlb/lsv030

IF: 3.4

2015-07-21

Journal of Law and the Biosciences

Abstract:There is an urgent need for consistent data sharing policies that promote the advancement of science while respecting the values and interests of those providing their genetic data for research. Responding to the article of Jalayne J. Arias, Genevieve Pham-Kanter, and Eric G. Campbell, ‘The Growth and Gaps of Genetic Data Sharing Policies in the United States’, this commentary further explores the challenges of human subjects’ protection in existing data sharing policies. We will elaborate on the need for data sharing policies to accommodate variation in individual and group preferences around data sharing and privacy concerns by comparing our previously published data on patients’ and parents’ consent to data sharing and attitudes about privacy to data from focus groups with HIV-positive, underserved individuals who were asked about their willingness to participate in genetic research and share their data broadly. These studies support the observation of Arias, Pham-Kanter, and Campbell that researchers, and funding agencies will need to balance the privacy interests of groups as well as individuals in future genomic data sharing policies.
Simultaneous enhancement of lignin-derived inhibitor tolerance and lipid accumulation of oleaginous yeast Trichosporon cutaneum by adaptive evolution

Qi Liu,Bin Zhang,Mingshan Hu,Jie Bao

DOI: https://doi.org/10.1016/j.procbio.2023.12.010

IF: 4.885

2023-12-15

Process Biochemistry

Abstract:Inhibitory compounds should be removed from the pretreated lignocellulose feedstock before fermentative production of microbial lipid by oleaginous yeast. Biodetoxification effectively degrades furan aldehydes and weak organic acids, but is less efficient against complex and various lignin-derived phenolic aldehydes. Residual phenolics in lignocellulose hydrolysates require a tolerant fermentation strain. This study adopted the long-term adaptive evolution combined with centrifugal enrichment in corn stover hydrolysate to simultaneously improve the phenolic inhibitors tolerance and lipid synthesis of Trichosporon cutaneum. The obtained mutant T. cutaneum MS28 showed significant improved performances of phenolic aldehydes tolerance and lipid accumulation. The final cellulosic lipid production of T. cutaneum MS28 utilizing corn stover reached 33.8 ± 0.1 g/L, approximately 6-fold higher than that of the starting strain. Transcriptional analysis suggested that T. cutaneum MS28 had more active lignocellulose-derived sugars metabolism and lipid synthesis shunts. The intracellular contents of lipid synthesis precursors including NADPH and acetyl-CoA increased 1.7-3.0 folds. This adaptive evolution in lignocellulose hydrolysate combined with centrifugal enrichment is an efficient tool to targeted enhancement of inhibitors tolerance and cellulosic lipid production of oleaginous yeast.

biochemistry & molecular biology,biotechnology & applied microbiology,engineering, chemical
Engineering and adaptive laboratory evolution of <i>Escherichia coli</i> for improving methanol utilization based on a hybrid methanol assimilation pathway

Qing Sun,Dehua Liu,Zhen Chen

DOI: https://doi.org/10.3389/fbioe.2022.1089639

IF: 5.7

2023-01-01

Frontiers in Bioengineering and Biotechnology

Abstract:Engineering Escherichia coli for efficient methanol assimilation is important for developing methanol as an emerging next-generation feedstock for industrial biotechnology. While recent attempts to engineer E. coli as a synthetic methylotroph have achieved great success, most of these works are based on the engineering of the prokaryotic ribulose monophosphate (RuMP) pathway. In this study, we introduced a hybrid methanol assimilation pathway which consists of prokaryotic methanol dehydrogenase (Mdh) and eukaryotic xylulose monophosphate (XuMP) pathway enzyme dihydroxyacetone synthase (Das) into E. coli and reprogrammed E. coli metabolism to improve methanol assimilation by combining rational design and adaptive laboratory evolution. By deletion and down-regulation of key genes in the TCA cycle and glycolysis to increase the flux toward the cyclic XuMP pathway, methanol consumption and the assimilation of methanol to biomass were significantly improved. Further improvements in methanol utilization and cell growth were achieved via adaptive laboratory evolution and a final evolved strain can grow on methanol with only 0.1 g/L yeast extract as co-substrate. C-13-methanol labeling assay demonstrated significantly higher labeling in intracellular metabolites in glycolysis, TCA cycle, pentose phosphate pathway, and amino acids. Transcriptomics analysis showed that the expression of fba, dhak, and part of pentose phosphate pathway genes were highly up-regulated, suggesting that the rational engineering strategies and adaptive evolution are effective for activating the cyclic XuMP pathway. This study demonstrated the feasibility and provided new strategies to construct synthetic methylotrophy of E. coli based on the hybrid methanol assimilation pathway with Mdh and Das.
Genome reduction improves octanoic acid production in scale down bioreactors

William T. Cordell,Gennaro Avolio,Ralf Takors,Brian F. Pfleger

DOI: https://doi.org/10.1111/1751-7915.70034

2024-11-08

Microbial Biotechnology

Abstract:Genome reduction is a strategy for reallocating resources away from unneeded stress responses towards production of desired products. Octanoic acid production was improved in an engineered genome‐reduced strain of Escherichia coli relative to the engineered parent strain. Microorganisms in large‐scale bioreactors are exposed to heterogeneous environmental conditions due to physical mixing constraints. Nutritional gradients can lead to transient expression of energetically wasteful stress responses and as a result, can reduce the titres, rates and yields of a bioprocess at larger scales. To what extent these process parameters are impacted is often unknown and therefore bioprocess scale‐up comes with major risk. Designing platform strains to account for these intermittent stresses before introducing synthesis pathways is one strategy for de‐risking bioprocess development. For example, Escherichia coli strain RM214 is a derivative of wild‐type MG1655 that has had several genes and whole operons removed from its genome based on their metabolic cost. In this study, we engineered E. coli strain RM214 (referred to as WG02) to produce octanoic acid from glycerol in batch‐flask and fed‐batch bioreactor cultivations and compared it to an octanoic acid‐producing E. coli MG1655 (WG01). In batch flask cultivations, the two strains performed similarly. However, in carbon limited fed‐batch bioreactor cultivations, WG02 provided a greater than 22% boost to biomass compared to WG01 while maintaining similar titres of octanoic acid. Reducing the biomass accumulation of WG02 with nitrogen limited fed‐batch cultivation resulted in a 16% improvement in octanoic acid titre over WG01. Finally, in a scale‐down system consisting of a stirred tank reactor (representing a well‐mixed zone) and plug flow reactor (representing an intermittent carbon starvation zone), WG02 again improved octanoic acid titre by almost 18% while maintaining similar biomass concentrations as WG01.

biotechnology & applied microbiology,microbiology
Adaptive laboratory evolution of Escherichia coli W enhances gamma-aminobutyric acid production using glycerol as the carbon source

Kangsan Kim,Chen Yuan Hou,Donghui Choe,Minjeong Kang,Suhyung Cho,Bong Hyun Sung,Dae-Hee Lee,Seung-Goo Lee,Taek Jin Kang,Byung-Kwan Cho

DOI: https://doi.org/10.1016/j.ymben.2021.11.004

IF: 8.4

2022-01-01

Metabolic Engineering

Abstract:The microbial conversion of glycerol into value-added commodity products has emerged as an attractive means to meet the demands of biosustainability. However, glycerol is a non-preferential carbon source for productive fermentation because of its low energy density. We employed evolutionary and metabolic engineering in tandem to construct an Escherichia coli strain with improved GABA production using glycerol as the feedstock carbon. Adaptive evolution of E. coli W under glycerol-limited conditions for 1300 generations harnessed an adapted strain with a metabolic system optimized for glycerol utilization. Mutation profiling, enzyme kinetic assays, and transcriptome analysis of the adapted strain allowed us to decipher the basis of glycerol adaptation at the molecular level. Importantly, increased substrate influx mediated by the mutant glpK and modulation of intracellular cAMP levels were the key drivers of improved fitness in the glycerol-limited condition. Leveraging the enhanced capability of glycerol utilization in the strain, we constructed a GABA-producing E. coli W-derivative with superior GABA production compared to the wild-type. Furthermore, rationally designed inactivation of the non-essential metabolic genes, including ackA, mgsA, and gabT, in the glycerol-adapted strain improved the final GABA titer and specific productivity by 3.9- and 4.3-fold, respectively, compared with the wild-type.

biotechnology & applied microbiology
Identification of crucial roles of transcription factor IhfA on high production of free fatty acids in Escherichia coli

Lixia Fang,Ziyi Han,Xueru Feng,Xueyan Hao,Mengxiao Liu,Hao Song,Yingxiu Cao

DOI: https://doi.org/10.1016/j.synbio.2024.01.007

IF: 4.692

2024-01-27

Synthetic and Systems Biotechnology

Abstract:Transcription factor engineering has unique advantages in improving the performance of microbial cell factories due to the global regulation of gene transcription. Omics analyses and reverse engineering enable learning and subsequent incorporation of novel design strategies for further engineering. Here, we identify the role of the global regulator IhfA for overproduction of free fatty acids (FFAs) using CRISPRi-facilitated reverse engineering and cellular physiological characterization. From the differentially expressed genes in the ihfA L‚àí strain, a total of 14 beneficial targets that enhance FFAs production by above 20‚ÄØ% are identified, which involve membrane function, oxidative stress, and others. For membrane-related genes, the engineered strains obtain lower cell surface hydrophobicity and increased average length of membrane lipid tails. For oxidative stress-related genes, the engineered strains present decreased reactive oxygen species (ROS) levels. These gene modulations enhance cellular robustness and save cellular resources, contributing to FFAs production. This study provides novel targets and strategies for engineering microbial cell factories with improved FFAs bioproduction. Graphical abstract Download : Download high-res image (307KB) Download : Download full-size image

biotechnology & applied microbiology
Extraction of Concept Maps from Textbooks for Domain Modeling

A. Olney

DOI: https://doi.org/10.1007/978-3-642-13437-1_80

2010-06-14

Abstract:
Metabolic engineering of Escherichia coli for efficient biosynthesis of butyl acetate

Jason T. Ku,Arvin Y. Chen,Ethan I. Lan

DOI: https://doi.org/10.1186/s12934-022-01755-y

IF: 6.352

2022-02-22

Microbial Cell Factories

Abstract:Abstract Background Butyl acetate is a versatile compound that is widely used in the chemical and food industry. The conventional butyl acetate synthesis via Fischer esterification of butanol and acetic acid using catalytic strong acids under high temperature is not environmentally benign. Alternative lipase-catalyzed ester formation requires a significant amount of organic solvent which also presents another environmental challenge. Therefore, a microbial cell factory capable of producing butyl acetate through fermentation of renewable resources would provide a greener approach to butyl acetate production. Result Here, we developed a metabolically engineered strain of Escherichia coli that efficiently converts glucose to butyl acetate. A modified Clostridium CoA-dependent butanol production pathway was used to synthesize butanol which was then condensed with acetyl-CoA through an alcohol acetyltransferase. Optimization of alcohol acetyltransferase expression and redox balance with auto-inducible fermentative controlled gene expression led to an effective titer of 22.8 ± 1.8 g/L butyl acetate produced in a bench-top bioreactor. Conclusion Building on the well-developed Clostridium CoA-dependent butanol biosynthetic pathway, expression of an alcohol acetyltransferase converts the butanol produced into butyl acetate. The results from this study provided a strain of E. coli capable of directly producing butyl acetate from renewable resources at ambient conditions.

biotechnology & applied microbiology

Optimal geometric parameters of ordered arrays of nanoprisms for enhanced sensitivity in localized plasmon based sensors.

Adaptive laboratory evolution and transcriptomics-guided engineering of Escherichia coli for increased isobutanol tolerance

Adaptive laboratory evolution of Yarrowia lipolytica improves ferulic acid tolerance

An integrated computational and experimental study for overproducing fatty acids in Escherichia coli

Improving Ethanol Tolerance of Escherichia Coli by Rewiring Its Global Regulator Camp Receptor Protein (CRP).

Improving acid resistance of Escherichia coli base on the CfaS-mediated membrane engineering strategy derived from extreme acidophile

An Evolved Strain of the Oleaginous Yeast Rhodotorula toruloides, Multi-Tolerant to the Major Inhibitors Present in Lignocellulosic Hydrolysates, Exhibits an Altered Cell Envelope

Schistosoma kisumuensis n. sp. (Digenea: Schistosomatidae) from murid rodents in the Lake Victoria Basin, Kenya and its phylogenetic position within the S. haematobium species group

Metabolic and evolutionary responses of Clostridium thermocellum to genetic interventions aimed at improving ethanol production

Genome-wide Escherichia coli stress response and improved tolerance towards industrially relevant chemicals

Improvement of environmental tolerance of E. coli through biological membrane engineering to boost succinic acid conversion

Adaptive Laboratory Evolution of Tolerance to Dicarboxylic Acids in Saccharomyces Cerevisiae.

Emulsion-based evolution of Escherichia coli for higher growth yield on D-xylose identifies central role of cyclic AMP

It depends whose data are being shared: considerations for genomic data sharing policies

Simultaneous enhancement of lignin-derived inhibitor tolerance and lipid accumulation of oleaginous yeast Trichosporon cutaneum by adaptive evolution

Engineering and adaptive laboratory evolution of <i>Escherichia coli</i> for improving methanol utilization based on a hybrid methanol assimilation pathway

Genome reduction improves octanoic acid production in scale down bioreactors

Adaptive laboratory evolution of Escherichia coli W enhances gamma-aminobutyric acid production using glycerol as the carbon source

Identification of crucial roles of transcription factor IhfA on high production of free fatty acids in Escherichia coli

Extraction of Concept Maps from Textbooks for Domain Modeling

Metabolic engineering of Escherichia coli for efficient biosynthesis of butyl acetate