Abstract:In situ methane enrichment method can increase the methane content in biogas, which is a cost-effective technology used for producing bio-methane compared with conventional biogas upgrading technologies. During the in situ methane enrichment process, liquid stream from the anaerobic digester is circulated through a CO2-desorption unit and then returned back to the digester. The most important step in this process is CO2 desorption. In this study we evaluated the effects of different CO2 desorption techniques. Three CO2 desorption methods including air stripping, vacuum extraction and ultrasonic-auxiliary air stripping were studied through experiments. The experiments were conducted under mesophilic (38℃) anaerobic digestion by using synthetic wastewater with glucose and supplemental nutrients. The experimental apparatus included one anaerobic digester with volume of 1 500 mL and two CO2-desorption bottles with volume of 500 mL used for air stripping and vacuum extraction respectively. The results showed that the average volume fraction of methane in biogas reached 76.4%and 78.3%for the air stripping groups (aeration fluxes of 205 mL/min and daily stripping time of 30min), and increased by 17%and 20%compared to the control (65.4%) with the daily recycle rates of liquid stream (DRR) at 0.2 L/(L·d) and 0.4 L/(L·d), respectively. The cumulative methane production is similar to controlled one for the group with DRR of 0.2 L/(L·d). But the cumulative methane production decreased by 15%compared with control one for the group with DRR of 0.4 L/(L·d). In situ methane enrichment effect of the group of CO2 vacuum extraction with 0.1 MPa vacuum maintaining 5 min was slightly lower than that of the air stripping group with aeration flux at 205 mL/min, daily stripping time 20min and DDR 0.2 L/(L·d). The methane volume fraction of biogas in the first group was decreased by 4.6% compared to that of the second group. However, the difference is not significant (P>0.05). The results of experiment of ultrasonic-auxiliary air stripping, with aeration flux of 100 mL/min, daily stripping time of 21 min and ultrasonic frequency of 40 kHz, show that ultrasonic wave can accelerate CO2 air stripping, especially when the concentration of CO2 in the liquid was high. During the initial 3 min of stripping the CO2 removing rate of ultrasonic-auxiliary air stripping group was advanced by 32%compared to air stripping group. The total free CO2 removal amount from the liquid stream was increased by 29.8% compared to air stripping group during the whole stripping time of 21 min. Furthermore, ultrasonic wave has potential advantages on CO2 removing by lowering pH of liquid and increasing anaerobic digestion efficiency through decomposing many complex organic compounds. Therefore, the effect of air stripping and vacuum extraction on methane enrichment has no significance difference, but vacuum extraction has no problem of oxygen inhibition, the control of which is vital for successful running of in situ methane enrichment process of air stripping. Ultrasonic-auxiliary air stripping method has advantages for CO2 desorption due to its unique characteristics of lowering pH, degrading complex compounds and increasing CO2 removal.

In situ methane enrichment with vacuum application to produce biogas with higher methane content

Influence of Techniques for Desorption of Carbon Dioxide on in Situ Methane Enrichment During Biogas Fermentation

Integrated biogas upgrading and hydrogen utilization in an anaerobic reactor containing enriched hydrogenotrophic methanogenic culture.

Chemo-autotrophic biogas purification for methane enrichment: mechanism and kinetics

A New Degassing Membrane Coupled Upflow Anaerobic Sludge Blanket (UASB) Reactor to Achieve In-Situ Biogas Upgrading and Recovery of Dissolved CH4 from the Anaerobic Effluent

Use of Continuous Stirred Tank Reactors for Anaerobic Co-Digestion of Dairy and Meat Industry By-Products for Biogas Production

Application of In-Situ H2-assisted Biogas Upgrading in High-Rate Anaerobic Wastewater Treatment.

Simultaneous methane production and wastewater reuse by a membrane-based process: evaluation with raw domestic wastewater.

Purification and upgrading biogas from anaerobic digestion using chemical asborption of CO2 with amines in order to produce biomethane as biofuel for vehicles: a pilot-scale study

Evaluation of High-Solids Anaerobic Digestion Process for Converting Excess Sludge to Biogas

Enhancement of Anaerobic Methanogenesis at A Short Hydraulic Retention Time Via Bioelectrochemical Enrichment of Hydrogenotrophic Methanogens

Two-Stage Enrichment of Ventilation Air Methane with Vacuum, Temperature, and Vacuum Swing Adsorption (VTVSA) Processes

Performance and mechanism of in-situ biogas upgrading using anaerobic membrane bioreactor effluent

Comparison Biomethane Potential (BMP) Test of Sewage Sludge Recovered from Different Treatment Processes

Optimization of the Ex Situ Biomethanation of Hydrogen and Carbon Dioxide in a Novel Meandering Plug Flow Reactor: Start-Up Phase and Flexible Operation

Simultaneous Hydrogen Utilization and in Situ Biogas Upgrading in an Anaerobic Reactor.

Biological upgrading of biogas assisted with membrane supplied hydrogen gas in a three-phase upflow reactor

Rice Straw and Swine Manure Anaerobic co-digestion Enhancement Through Bioaugmentation: Effect on the Microbial Community

Pilot-scale in-situ biomethanation of sewage sludge: Effects of gas recirculation method

Bioaugmentation As a Solution to Increase Methane Production from an Ammonia-Rich Substrate.

An Incubation System To Enhance Biogas And Methane Production: A Case Study Of An Existing Biogas Plant In Umbria, Italy