Abstract:Membrane Aerated Biofilm Reactors (MABR) are gaining more and more acceptance in the plethora of wastewater process intensification technologies. Mathematical modelling has contributed to show their feasibility in terms of reduced energy consumption and footprint. Nevertheless, most simulation studies published until now are still focused on analyzing MABR as single units and not fully integrated within the flow diagram of the water treatment plant (WWTP). In this paper, the prediction capabilities of an integrated modelling approach is tested using full-scale data from Ejby Mølle WWTP+MABR site (Odense, Denmark). Mass balances, data reconciliation methods, process simulation and the different evaluation criteria were used to adjust influent, effluent and process indicators. Results show 10 % mismatch between flow, COD, N and P predictions and measurements in different plant locations. Using the adopted hydraulic retention time (HRT), nitrogen load (NL), membrane surface area (MA) and oxygen transfer rate (OTR), it was possible to predict nitrification rates (NR) within the interquartile range. This has been done under two different MABR operational conditions: with (#S2) and without (#S1) external aeration (EA) in the bulk liquid. The model provides additional process insights about biofilm structure, substrate gradients, weak acid base chemistry and precipitation potential. More specifically, simulations suggest the potential undesirable effects of sulfate (SRB) and iron reducing bacteria (IRB) on both microbial activity and composition of the biofilm. The latter may have a strong impact on ammonium (NHx), sulfate (SOx) and ferrous ion (Fe+2) conversion processes. The change of operational strategy in the scenario analysis highlights that the denitrifying activity of phosphorus accumulating organisms (PAOs) can enhance nutrient removal in MABR tanks. In addition, it was possible to assess the chance of success (in terms of energetic cost of nitrogen removal) of adding several MABR units in one tank of the WWTP under study before full-scale implementation.

A plant-wide modelling comparison between membrane bioreactors and conventional activated sludge

LCA of a Membrane Bioreactor Compared to Activated Sludge System for Municipal Wastewater Treatment

Integrated fixed-film activated sludge membrane bioreactors versus membrane bioreactors for nutrient removal: A comprehensive comparison

Greenhouse gases from membrane bioreactors: Mathematical modelling, sensitivity and uncertainty analysis

Carbon footprint reduction by coupling intermittent aeration with submerged MBR: A pilot plant study

Modelling the impacts of operational conditions on the performance of a full-scale membrane aerated biofilm reactor

Aeration control in membrane bioreactor for sustainable environmental footprint

Integrated membrane bioreactors modelling: A review on new comprehensive modelling framework

Mathematical modelling of greenhouse gas emissions from membrane bioreactors: A comprehensive comparison of two mathematical models

[A Comparison Between a Submerged Membrane Bioreactor and a Conventional Activated Sludge Process].

Trading-off greenhouse gas emissions and 741/2020 European Union water reuse legislation: An experimental MBR study

Techno-economic characteristics of wastewater treatment plants retrofitted from the conventional activated sludge process to the membrane bioreactor process

Membrane aerated biological reactors (MABRs) to enhance the biological treatment process at a WWTP

Effects of various factors on critical flux in submerged membrane bioreactors for municipal wastewater treatment

Metagenomes Reveal Microbial Structures, Functional Potentials, and Biofouling-Related Genes in a Membrane Bioreactor

Biological Nutrient Removal in the Anaerobic Side-Stream Reactor Coupled Membrane Bioreactors for Sludge Reduction.

Calibration and validation of an activated sludge model for membrane bioreactor wastewater treatment plants

Achieving low-carbon municipal wastewater treatment by anaerobic membrane bioreactor at seasonal temperatures: A pilot scale investigation on reducing sludge yield and greenhouse gas emissions

Greenhouse gas emissions from membrane bioreactors: analysis of a two-year survey on different MBR configurations

Sewage sludge minimisation by OSA-MBR: A pilot plant experiment

Sustainability evaluation and implication of a large scale membrane bioreactor plant