Abstract:Introduction. Understanding of crystal growth mechanism enables to develop efficient tools to control scaling and improve the process of treatment using membranes and increasing the amount of filtrate output. This investigation is aimed at studying an antiscalant behaviour in reverse osmosis (RO) process when treating ground water. Experimental dependences of calcium carbonate scaling efficiency on antiscalant dosage were found. Rates of adsorption on crystal surface of scaling deposit and on membrane surfaces were compared. Dependences of rates of inhibitor adsorption on crystal surface versus scaling rates were determined. Inhibitor adsorption on RO membrane surfaces was studied. New approaches to studying crystal growth mechanism in the presence of polymeric inhibitors are presented. Materials and methods. In the course of experiments conducted with using inhibitor dissolved in distilled water, inhibitor sorption on membrane surface was observed in the absence of calcium ions. As to experiments with dosing the inhibitor in tap water, the inhibitor sorption on the membrane did not occur: the inhibitor was adsorbed on the surface of the scaling crystals. Results. Experimental relationships are obtained that show dependencies of calcium carbonate deposit growth rates versus RO facility filtrate output values in the presence of different antiscalants with their dose values of 3, 5 and 7 mg/l. The article shows that antiscalant dose value does not provide substantial influence on antiscalant efficiency when natural water with low hardness is treated in the RO facility. This permits substantial reduction of operational costs. It was also proved that inhibitor is not adsorbed on membrane surface during natural water treatment that also confirms efficiency of low antiscalant dosing. Conclusions. Low hardness values of natural water (3–5 mill equivalents per liter) demonstrate that antiscalant efficiencies do not depend on its dose. Rate of inhibitor adsorption on crystal surface during calcium carbonate deposition also increases with scaling rate increase. Rates of antiscalant consumption increase with antiscalant dose values. In natural water the dissolved antiscalant molecules are bonded with calcium ions therefore antiscalant does not react with membranes and is not adsorbed on membrane surface.

Investigating the effect of temperature on calcium sulfate scaling of reverse osmosis membranes using FTIR, SEM-EDX and multivariate analysis

A Review of Heterogeneous Nucleation of Calcium Carbonate and Control Strategies for Scale Formation in Multi-Stage Flash (MSF) Desalination Plants

Fouling Behavior of Calcium Phosphate in Direct Contact Membrane Distillation

Membrane distillation operated at high seawater concentration factors: Role of the membrane on CaCO3 scaling in presence of humic acid

Effect of spacer on mass transfer coefficient and calcium sulfate scaling phenomena in reverse osmosis desalination

Insights into dynamic evolution of combined scaling-biofouling in reverse osmosis

A Comprehensive Study on Combined Organic Fouling and Gypsum Scaling in Reverse Osmosis: Decoupling Surface and Bulk Phenomena

Calcium carbonate scaling in seawater desalination by ammonia–carbon dioxide forward osmosis: Mechanism and implications

Gypsum Scale Formation on Graphene Oxide Modified Reverse Osmosis Membrane

Microbially-induced Mineral Scaling in Desalination Conditions: Mechanisms and Effects of Commercial Antiscalants.

Silica Mitigated Calcium Mineral Scaling in Brackish Water Reverse Osmosis.

Mineral Scaling on Reverse Osmosis Membranes: Role of Mass, Orientation, and Crystallinity on Permeability

Scaling behavior in membrane distillation: Effect of biopolymers and antiscalants

Effects of Anti-Scaling and Cleaning Chemicals on Membrane Scale in Direct Contact Membrane Distillation Process for RO Brine Concentrate

A Case Study of Calcium Carbonate Crystallization during Reverse Osmosis Water Desalination in Presence of Novel Fluorescent-Tagged Antiscalants

Calcium carbonate scaling and seeding induced precipitation in FO treating textile reverse osmosis concentrate

Study of Membrane Fouling in Cross-Flow Vacuum Membrane Distillation

Investigation of antiscalant dosing influence on scaling process in reverse osmosis facilities and membrane surface adsorption

Electro mitigation of calcium carbonate and calcium sulfate scaling in an optimized thermal conductive membrane distillation process

Protein-Decorated Reverse Osmosis Membranes with High Gypsum Scaling Resistance

Surface modification of anti‐fouling novel cellulose/graphene oxide (GO) nanosheets (NS) microfiltration membranes for seawater desalination applications