Abstract:Adding hydrogen to natural gas is a promising way to improve the ignition stability and reduce the greenhouse gas emissions of pilot-ignition direct-injection natural gas engines. Most of the previous studies concerning hydrogen-enriched natural gas engines are focused on spark-ignition engines. The limited investigations on the addition of hydrogen in direct-injection natural gas engines are conducted by experimental method. Therefore, some detailed information on the in-cylinder combustion and emission formation process are left unknown. In this work, numerical simulations have been performed for the combustion process of a pilot-ignition direct-injection natural gas engine based on an integrated mechanism which is capable of describing the chemical kinetics involving diesel, natural gas, and hydrogen. Three-dimensional (3D) computational fluid dynamics simulations were conducted at different hydrogen blend ratios to explore the effects of hydrogen addition on the whole combustion process and the mole fraction traces of small radicals as well as CO, NOx, and soot emissions. Hydrogen addition was achieved by both volume-equivalent principle and energy-equivalent principle to guide the choice of hydrogen-addition method. Zero-dimensional simulations were conducted to elaborate the explanations of the phenomena in 3D simulations and disclose the interactions among the sensitivity of the key reactions, the formation of the active radicals, and the heat release process. The results show that the ignition delay is shortened and the ignition of natural gas is enhanced with the increase of hydrogen addition, which is primarily caused by the enhanced reactions related to active small radicals induced by increased hydrogen concentration. When hydrogen is added based on the volume-equivalent principle, all emission values will reduce with little sacrifice on thermal efficiency at hydrogen blend ratios smaller than 20%. However, CO emissions experience an increasing trend when hydrogen blend ratio is further increased to higher than 20% while NOx and soot emissions retain the decreasing trend. When hydrogen is added based on the energy-equivalent principle, CO emissions and soot emissions will decrease with the increase of hydrogen blend ratio while NOx emissions will witness an opposite trend with considerable improvements in thermal efficiency.

Experimental investigation of the effect of CO2 dilution on the performance and hydrogen knock limit of a hydrogen–gasoline dual fuel spark ignition engine 1

Effects of H2/CO Addition on Knock Tendency and Lean Limit in a Natural Gas SI Engine

Role of the Compression Ratio in Dual-Fuel Compression Ignition Combustion with Hydrogen and Methanol

An experimental investigation of effect on diesel engine performance and exhaust emissions of addition at dual fuel mode of hydrogen

An experimental investigation of the performance and emissions of a hydrogen-diesel dual fuel compression ignition internal combustion engine

The performance of a spark ignition gasoline engine with hydrogen addition under low-load conditions

Investigation of the effects of hydrogen energy ratio and valve lift amount on performance and emissions in a hydrogen-diesel dual-fuel compression ignition engine

The effect of using hydrogen at partial load in a diesel-natural gas dual fuel engine

Experimental investigation of the effect of hydrogen ratio on engine performance and emissions in a compression ignition single cylinder engine with electronically controlled hydrogen-diesel dual fuel system

Experimental Investigation of Diluents Components on Performance and Emissions of a High Compression Ratio Methanol SI Engine

An Experimental and Numerical Study of a Hydrogen Fueled, Directly Injected, Heavy Duty Engine at Knock-Limited Conditions

Effects of Hydrogen Addition on the Performance of a Pilot-Ignition Direct-Injection Natural Gas Engine: A Numerical Study

Quantitative assessment of small-bore gasoline direct injection engine for homogenous stoichiometric lean condition with hydrogen addition in dual fuel mode

Effects of Hydrogen Addition on Cycle-By-Cycle Variations in A Lean Burn Natural Gas Spark-Ignition Engine

Comprehensive effects of ammonia substitution rate, compression ratio, and ignition timing on knock, NOx emissions and indicated thermal efficiency in a hydrogen fuel engine

Experimental investigation of variable compression ratio and ignition timing effects on performance, combustion, and Nox emission of an ammonia/hydrogen-fuelled Si engine

Experimental study on the combustion and emission performance of the hydrogen direct injection engine

Enhancing performance and reducing emissions of a spark ignition engine by adding dimethyl carbonate to gasoline

Investigations on a Spark Ignition Engine, Part II: Impact of Hydrogen Addition and Compression Ratio on a Biogas-Fuelled Engine

Effects of passive pre-chamber jet ignition on knock combustion at hydrogen engine

Experimental study of the performance of a SI-engine fueled with hydrogen-natural gas mixtures