Abstract:High-accuracy servo control of pneumatic systems requires nonlinear model-based control techniques based on full-state knowledge of the system.For the consideration of cost or light-weight design,non-linear pressure observers in place of pressure sensors were constructed to acquire the pressure states in the chambers of the pneumatic cylinder.Firstly,the global stability of the proposed pressure observer was demonstrated based on Lyapunov-stability theory.Secondly,the pressure observer's polytropic exponent was analyzed and determined experimentally.Moreover,to check the fast convergence of the proposed pressure observer,a set of experiments for tracking a 0.5 Hz sinusoidal trajectory were performed under condition that the initial states of both chambers should be pressurized and the initial values of the observed pressures were intentionally set different from the actual values.Furthermore,to verify the load-independent of the presented pressure observer,the valve-controlled pneumatic cylinder system acted upon by a variable-stiffness loading force was adopted to carry out pneumatic servo control.A three-way on-off solenoid value was configured as two-way valve.Thus,four two-way on-off solenoid valves controlled with pulse width modulation (PWM) in lieu of one or two proportional valves were employed to govern the pneumatic cylinder for achieving the pneumatic servo control.Finally,extensive experiments validated the effectiveness and feasibility of the proposed pressure observer for high-accuracy pneumatic servo control of the valve-controlled pneumatic cylinder system.

Position control of a rodless cylinder in pneumatic servo with actuator saturation

Disturbance Observer Based Position Tracking of Electro-Hydraulic Actuator

Nonlinear adaptive position tracking of an electro-hydraulic actuator

EXTENDED DISTURBANCE OBSERVER-BASED SLIDING MODE FAULT-TOLERANT CONTROL FOR THE DUAL-VALVE HYDRAULIC SERVO SYSTEM WITH REDUCED-ORDER MODEL

Fuzzy Impedance Control of an Electro-Hydraulic Actuator with an Extended Disturbance Observer

Adaptive Robust Control of Pneumatic Cylinders Using Fast Switching On/off Solenoid Valves

Tracking Control Simulation of Pneumatic Muscle Actuator Joint Using Saturated Adaptive Robust Controller

A Fast Integral Sliding Mode Controller with an Extended State Observer for Position Control of Permanent Magnet Synchronous Motor Servo Systems

Parallel Velocity Control of an Electro-Hydraulic Actuator with Dual Disturbance Observers

Precision Trajectory Tracking Control of a Pneumatic Cylinder and Output Stiffness Regulation

Globally Stable, Fast Convergent and Load-independent Pressure Observer for Pneumatic Servo Systems

Position Servo Control for Pneumatic Actuator with Fuzzy PID

Motion Trajectory Tracking Control of Pneumatic Position Servo Systems

Nonlinear Motion Control of a Hydraulic Press Based on an Extended Disturbance Observer

Positioning Control for a Linear Actuator with Nonlinear Friction and Input Saturation Using Output-Feedback Control.

Disturbance Observer Based Robust Motion Control for Single Rod Hydraulic Actuators

Linear active disturbance rejection control for the electro-hydraulic position servo system

Neural Network-Based High-Accuracy Motion Control of a Class of Torque-Controlled Motor Servo Systems with Input Saturation

A Sampled-Data Approach to Nonlinear ESO-Based Active Disturbance Rejection Control for Pneumatic Muscle Actuator Systems with Actuator Saturations.

Saturated Adaptive Control of an Electrohydraulic Actuator with Parametric Uncertainty and Load Disturbance

Robust Control of A Linear Actuator with Nonlinear Dynamic Friction and Unknown Width Input Dead-Zone