Transparent motion from feature- and luminance-based processes

S. Hammett,T. Ledgeway,A. T. Smith

DOI: https://doi.org/10.1016/0042-6989(93)90245-R

IF: 1.8

1993-05-01

Vision Research

Abstract:

What problem does this paper attempt to address?

Activity and stability of different immobilized preparations of recombinant E. coli cells containing ω-transaminase

Gustav Rehn,Carl Grey,Cecilia Branneby,Lina Lindberg,Patrick Adlercreutz

DOI: https://doi.org/10.1016/j.procbio.2012.04.013

IF: 4.885

2012-07-01

Process Biochemistry

Abstract:Production of chiral amines using ω-transaminases has been thoroughly studied in recent years. Immobilized ω-transaminases, however, have been used on relatively few occasions despite potential benefits such as reuse of enzyme and ease of product purification. In this study principally different methods including surface immobilization, entrapment and sweep flocculation using titanium oxide, Ca-alginate and chitosan respectively were evaluated for the immobilization of recombinant Escherichia coli cells. The enzyme expressed was a modified Arthrobacter citreus ω-transaminase with improved thermostability. The preparations were compared in terms of cell loading capacity, operational stability in repeated batches and storage stability using the conversion of methylbenzylamine to acetophenone.The use of chitosan for cell immobilization proved to be the method of choice since it was both very simple and effective. At a very high cell loading of 3.2g cells/g chitosan >60% activity was observed. The preparation was reused in eight successive 1-h batches with >90% remaining activity. To further demonstrate its usability the preparation was used for asymmetric synthesis of (S)-4′-cyano-(α)-methylbenzylamine in three repeated bathes (cycle time >20h), using isopropylamine as the amine donor. Storage stability was comparable with that of non-immobilized cells. It was concluded that the chitosan method due to its properties and simplicity would be advantageous for use also on a larger scale.

biochemistry & molecular biology,biotechnology & applied microbiology,engineering, chemical
Membrane-immobilized transaminases for the synthesis of enantiopure amines

Damien Debecker,Hippolyte Meersseman Arango,Xuan Dieu Linh Nguyen,Patricia Luis,Tom Leyssens,David Roura Padrosa,Francesca Paradisi

DOI: https://doi.org/10.26434/chemrxiv-2024-31rs5

2024-06-07

Abstract:For the manufacture of enantiopure amines, greener synthesis processes are needed. Transaminases (TAs) are able to produce chiral amines with excellent enantioselectivity and in mild conditions, and can be immobilized to target stability, recoverability, and reusability. In the perspective of process intensification, we propose to study TA immobilization onto polymeric membranes. Two main immobilization strategies were investigated, requiring prior membrane surface functionalization. On the one hand, a polyacrylonitrile (PAN) membrane surface was partially hydrolyzed and coated with polyethyleneimine (PEI) to electrostatically trap TAs. On the second hand, a polypropylene (PP) membrane was coated with polydopamine (PDA), which was subsequently modified with glycerol diglycidyl ether (GDE) in order to covalently graft TAs. The successful membranes functionalization was confirmed by surface characterization techniques (infrared spectroscopy, X-ray photoelectron spectroscopy, contact angle measurements, and scanning electron microscopy). Enzyme leaching was observed from the functionalized PAN membrane, highlighting the need to post-treat the reversibly immobilized TAs to improve their anchoring. The covalent coupling of TAs with PEI using glutaraldehyde (GA) was found highly effective to avoid leaching and to increase the enzyme loading, without affecting the specific activity of the biocatalyst. Similarly, the covalent grafting of TA onto functionalized PP membranes yielded very efficient biocatalysts (retaining 85 % specific activity with respect to soluble TA) displaying perfect recyclability throughout successive cycles. Immobilizing either the S-selective HeWT or the R-selective TsRTA resulted in robust heterogeneous biocatalysts with antagonist enantioselectivities. Thus, chiral amine synthesis can be performed effectively with biocatalytic membranes, which paves the way to intensified continuous flow synthesis processes.

Chemistry
Driving Transamination Irreversible by Decomposing Byproduct Α-Ketoglutarate into Ethylene Using Ethylene-Forming Enzyme

Li-Jun Meng,Ya-Yun Liu,Hai-Sheng Zhou,Xin-Jian Yin,Jian-Ping Wu,Mian-Bin Wu,Gang Xu,Li-Rong Yang

DOI: https://doi.org/10.1007/s10562-018-2552-8

IF: 2.936

2018-01-01

Catalysis Letters

Abstract:The transformations of transaminases have been extensively studied as an approach to the production of chiral amino moieties. However, the low equilibrium conversion of the reaction is a critical disadvantage to transaminase application, and a strategy for shifting the reaction equilibrium is essential. Herein, we have developed a novel method to effectively prevent the reversibility of transamination by fully decomposing byproduct α-ketoglutarate into ethylene and carbon dioxide in situ using ethylene-forming enzyme (EFE). Two transaminases and one EFE were expressed in E. coli and purified to be used in the cascade reaction. After optimal reaction conditions were determined based on the enzymatic properties, a cascade reaction coupling transaminase with EFE was conducted and showed high efficiency in the synthesis of l-phosphinothricin. Finally, using this approach with only an equivalent amount of amino donor l-glutamate increased the conversions of various keto acids from < 60% to > 99%. This strategy shows great potential for transamination using glutamate as the amino donor.
[Immobilizing engineered Escherichia coli cells into zeolitic imidazolate framework 8 for efficient biosynthesis of Ala-Gln].

Yingkang Zhang,Ting Cheng,Feiyang Zhao,Yanqin Yi,Qingqing Li,Zhenhua Lu,Mianbin Wu,Tao Wang,Xiaohuan Liu

DOI: https://doi.org/10.13345/j.cjb.220848

2023-01-01

Abstract:The α-amino acid ester acyltransferase (SAET) from is one of the enzymes with the highest catalytic ability for the biosynthesis of l-alanyl-l-glutamine (Ala-Gln) with unprotected l-alanine methylester and l-glutamine. To improve the catalytic performance of SAET, a one-step method was used to rapidly prepare the immobilized cells (SAET@ZIF-8) in the aqueous system. The engineered (. ) expressing SAET was encapsulated into the imidazole framework structure of metal organic zeolite (ZIF-8). Subsequently, the obtained SAET@ZIF-8 was characterized, and the catalytic activity, reusability and storage stability were also investigated. Results showed that the morphology of the prepared SAET@ZIF-8 nanoparticles was basically the same as that of the standard ZIF-8 materials reported in literature, and the introduction of cells did not significantly change the morphology of ZIF-8. After repeated use for 7 times, SAET@ZIF-8 could still retain 67% of the initial catalytic activity. Maintained at room temperature for 4 days, 50% of the original catalytic activity of SAET@ZIF-8 could be retained, indicating that SAET@ZIF-8 has good stability for reuse and storage. When used in the biosynthesis of Ala-Gln, the final concentration of Ala-Gln reached 62.83 mmol/L (13.65 g/L) after 30 min, the yield reached 0.455 g/(L·min), and the conversion rate relative to glutamine was 62.83%. All these results suggested that the preparation of SAET@ZIF-8 is an efficient strategy for the biosynthesis of Ala-Gln.
Effect of Immobilization by Modified Ultrastable-Y Molecular Sieve on the Resolution of (R,s)-2-octanol in Nonaqueous Media by Lipase

Dai Da-Zhang,Xia Li-Ming

DOI: https://doi.org/10.3321/j.issn:0567-7351.2008.02.017

2008-01-01

Acta Chimica Sinica

Abstract:The lipase from Penicillium expansum PED-03 (PEL) was immobilized into a modified ultrastable-Y molecular sieve and the resolution of (R,S)-2-octanol was carried out in a bioreactor in nonaqueous media by the immobilized lipase to investigate the effect of immobilization on the catalytic property of PEL duing the enzymatic reaction. It was found that the conversion (c), enantiomeric excess (ee), and enantioselectivity (E) of the resolution catalyzed by the PEL immobilized on the modified ultrastable-Y molecular sieve were much higher than those of the reaction catalyzed by free PEL and PEL immobilized on other supports. Being immobilized on the modified Ultrastable-Y molecular sieve, the lipase exhibited obvious activity in a wider pH range and at a much higher temperature than the free PEL, and showed a marked enhancement of stability against thermal inactivation, by which the suitable pH value of the buffer used for immobilization could be "memorized". The conversion of the reaction catalyzed by PEL immobilized on the modified ultrastable-Y molecular sieve reached 97.68% of the theoretical value with excellent enantioselectivity (Average E of 8 batches >460) in nonaqueous media at "memorial" pH 9.5, 50 degrees C for 24 h, which showed a good application potential to the production of optically pure (R,S)-2-octanol.
Continuous Preparative Application of Amine Transaminase‐Catalyzed Reactions with Integrated Crystallization

Sven Tiedemann,Jan Eric Neuburger,Alina Gazizova,Jan von Langermann

DOI: https://doi.org/10.1002/ejoc.202400068

IF: 3.261

2024-02-16

European Journal of Organic Chemistry

Abstract:Transaminases are valuable catalysts in the synthesis of chiral amines. However, secondary techniques are typically required to shift the reaction equilibrium to the product side. This study focuses on the in situ‐product crystallization, specifically at preparative synthetic scale as a non‐synthetic tool for a selection of aromatic and aliphatic substrates using the transaminase from Silicibacter pomeroyi. Herein the technique is implemented in a simplified manner to facilitate in situ‐product removal and downstream‐processing in a combined crystallization step. After a series of optimizations, product concentrations of >0.9 mol/L and >99% e.e.(S) were obtained implementing a repetitive batch reaction approach using a universal carboxylate as anion.

chemistry, organic
Medicare's Hospital Readmissions Reduction Program in Surgery May Disproportionately Affect Minority-serving Hospitals.

T. Shih,A. Ryan,Andrew A. Gonzalez,J. Dimick

DOI: https://doi.org/10.1097/SLA.0000000000000778

IF: 13.787

2015-06-01

Annals of Surgery

Abstract:OBJECTIVE To project readmission penalties for hospitals performing cardiac surgery and examine how these penalties will affect minority-serving hospitals. BACKGROUND The Hospital Readmissions Reduction Program will potentially expand penalties for higher-than-predicted readmission rates to cardiac procedures in the near future. The impact of these penalties on minority-serving hospitals is unknown. METHODS We examined national Medicare beneficiaries undergoing coronary artery bypass grafting in 2008 to 2010 (N = 255,250 patients, 1186 hospitals). Using hierarchical logistic regression, we calculated hospital observed-to-expected readmission ratios. Hospital penalties were projected according to the Hospital Readmissions Reduction Program formula using only coronary artery bypass grafting readmissions with a 3% maximum penalty of total Medicare revenue. Hospitals were classified into quintiles according to proportion of black patients treated. Minority-serving hospitals were defined as hospitals in the top quintile whereas non-minority-serving hospitals were those in the bottom quintile. Projected readmission penalties were compared across quintiles. RESULTS Forty-seven percent of hospitals (559 of 1186) were projected to be assessed a penalty. Twenty-eight percent of hospitals (330 of 1186) would be penalized less than 1% of total Medicare revenue whereas 5% of hospitals (55 of 1186) would receive the maximum 3% penalty. Minority-serving hospitals were almost twice as likely to be penalized than non-minority-serving hospitals (61% vs 32%) and were projected almost triple the reductions in reimbursement ($112 million vs $41 million). CONCLUSIONS Minority-serving hospitals would disproportionately bear the burden of readmission penalties if expanded to include cardiac surgery. Given these hospitals' narrow profit margins, readmission penalties may have a profound impact on these hospitals' ability to care for disadvantaged patients.
Co-immobilization of amine dehydrogenase and glucose dehydrogenase for the biosynthesis of (S)-2-aminobutan-1-ol in continuous flow

Pengcheng Xie,Jin Lan,Jingshuan Zhou,Zhun Hu,Jiandong Cui,Ge Qu,Bo Yuan,Zhoutong Sun

DOI: https://doi.org/10.1186/s40643-024-00786-0

2024-07-20

Bioresources and Bioprocessing

Abstract:Reductive amination by amine dehydrogenases is a green and sustainable process that produces only water as the by-product. In this study, a continuous flow process was designed utilizing a packed bed reactor filled with co-immobilized amine dehydrogenase wh84 and glucose dehydrogenase for the highly efficient biocatalytic synthesis of chiral amino alcohols. The immobilized amine dehydrogenase wh84 exhibited better thermo-, pH and solvent stability with high activity recovery. ( S )-2-aminobutan-1-ol was produced in up to 99% conversion and 99% ee in the continuous flow processes, and the space-time yields were up to 124.5 g L -1 d -1 . The continuous reactions were also extended to 48 h affording up to 91.8% average conversions. This study showcased the important potential to sustainable production of chiral amino alcohols in continuous flow processes.

biotechnology & applied microbiology
Process Understanding of Transamination Reaction in Chiral Pharmaceutical Intermediate Production Catalyzed by an Engineered Amine Transaminase

Zeynep Perçin,Florian Kleinbeck,Paul Bubenheim,Thomas Ruch,Andreas Liese

DOI: https://doi.org/10.1002/cctc.202401405

IF: 4.5

2024-12-01

ChemCatChem

Abstract:Industrial application of biocatalytic transamination for the conversion of a γ‐keto acid into a γ‐amino acid utilizing isoproplyamine (IPA) and a cofactor (PLP). The transamination reaction is modeled and simulated to gain deeper process understanding and evaluate different equipment options. Continuous operation modes: plug flow reactor (PFR) and continuous stirred tank reactor (CSTR). Chiral amines are key building blocks for the synthesis of many active pharmaceutical ingredients (APIs). Biocatalytic routes offer significant advantages to provide sustainable access to such motifs on commercial scale, with sacubitril valsartan sodium hydrate as a recent example. In this study a deeper mechanistic and kinetic understanding of the central biocatalytic step in the synthesis of sacubitril valsartan sodium hydrate, applying the evolved transaminase CDX‐043, was gained. The equilibrium of the transamination reaction was investigated in detail, and two kinetic models (ping‐pong two‐substrate kinetics and Michaelis–Menten double substrate kinetics) were established, considering substrate and product inhibition. The determined equilibrium constant indicates that the equilibrium lies strongly on the product side. The results of the kinetic studies demonstrate that the transaminase reaction is in conformity with the Michaelis–Menten double substrate kinetic model. Product inhibition was found to be more severe than substrate inhibition. The application of a plug flow reactor (PFR) was shown to be the preferred reactor setup to reduce the occurring inhibition.

chemistry, physical
Stemphylium lycopersici immobilized in mesoporous of type MCM 48 as biocatalyst for ω-transamination reactions

Maria Sandra Ramos Queiroz,Glaciela Cristina Rodrigues da Silva,Nádia Ligianara D. Nyari,Rodrigo O.M.A. de Souza,Rogério Marcos Dallago,Denise Oliveira Guimarães,Marcelo Luis Mignoni,Ivana Correa Ramos Leal

DOI: https://doi.org/10.1016/j.scp.2024.101504

IF: 5.464

2024-03-12

Sustainable Chemistry and Pharmacy

Abstract:The ability of Stemphylium lycopersici immobilized in MCM 48 zeolite structure as biocatalyst for ω-transamination reactions was evaluated. The conversion capacity for rac -1-methylbenzylamine, and also rac -1,2,3,4-tetrahydro-1-naphthylamine was verified in order to ascertain the potential of this biocatalyst in relation to the bioconversion of amines with different side chains when using immobilized crude enzyme extract in zeolite. In this first reaction (after 24 h), a conversion of 23% to acetophenone and 27% to tetralone was obtained. Observing the promising values obtained in the kinetic resolution reactions, an experimental design was carried considering the amount (mg) out of biocatalyst present in the support and the amount of ionic liquid used Central Compound Rotational Design (CCRD 2 complete). After optimization, values close to 36% conversion were achieved. In the present work, there were performed 25 cycles of 18 h with Zeolite MCM48 with the addition of ionic liquids (LI). The presence of LI's helps with stability and still acts as structure drivers, which may have helped by providing a large number of recycles. In this analysis, 87% of the initial activity was maintained.

chemistry, multidisciplinary,green & sustainable science & technology,environmental sciences
Rational Design of Transaminases Based on Comparative Analysis of Catalytically Active and Distance-Free Modes of the High-Energy Intermediate State

Xiaomin Yi,Hongwei Yu,Lidan Ye

DOI: https://doi.org/10.1002/bit.28626

IF: 3.8

2024-01-01

Biotechnology and Bioengineering

Abstract:Bioproduction of chiral amines is limited by low transaminase (TA) activity on nonnatural substrates, leading to the need for protein engineering. To address the challenge of quickly and precisely identifying the engineering targets, a strategy was proposed based on analyzing the mode changes in the high-energy intermediate state (H-state) of the substrate-enzyme complex during catalysis. By substituting the residues with minimal structural changes in catalytically active mode (A-mode) and distance-free mode (F-mode) of the H-state complex with more conserved ones to stabilize it, a TA mutant M5(T295C/L387A/V436A) with 121.9-fold higher activity for synthesizing the (S)-Rivastigmine precursor (S)-1-(3-methoxyphenyl)ethylamine was created. The applicability of this strategy was also validated by engineering another TA for 1.52-fold higher activity and >99% selectivity toward (R)-3-amino-1-butanol biopreparation. The much higher stereoselectivity of the mutant compared with the wild type (28.3%) demonstrated that this strategy is not only advantageous in engineering enzyme activity but also applicable for modulating stereoselectivity.
Progressive outer retinal necrosis caused by varicella-zoster virus in children with acquired immunodeficiency syndrome.

Ken W. Purdy,J. Heckenlively,J. Church,M. Keller

DOI: https://doi.org/10.1097/01.INF.0000059962.59114.3A

2003-04-01

The Pediatric Infectious Disease Journal

Abstract:We report three HIV-infected children with bilateral progressive outer retinal necrosis caused by varicella-zoster virus. All three lost vision in both eyes. Aggressive treatment strategies with combination intravenous antiviral therapy in addition to intravitreal antiviral therapy and appropriate surgical management may prevent blindness. Rapid recognition of this distinct clinical syndrome is essential to improve visual outcome.
Three‐liquid‐phase Spinning Reactor for the Transaminase‐catalyzed Synthesis and Recovery of a Chiral Amine

Claudia Matassa,Dominic Ormerod,Uwe T. Bornscheuer,Matthias Höhne,Yamini Satyawali

DOI: https://doi.org/10.1002/cctc.201902056

IF: 4.5

2020-01-09

ChemCatChem

Abstract:A device for the transaminase‐catalysed synthesis combined with continuous recovery of chiral amines was designed. The system enabled the separation of the reaction components in three liquid phases: a reaction phase, an organic solvent phase (where the poorly water soluble ketone substrate was supplied), and an aqueous extraction phase for continuous product recovery. The transaminase‐mediated asymmetric synthesis of ( S )‐1‐methyl‐3‐phenylpropylamine was employed as model reaction. Factors influencing the performance of the system, such as reactor geometry, working volumes and operating parameters, were investigated. Specifically, reaction yield and product recovery were enhanced by i) reducing the thickness of the reaction phase, while continuously stirring and ii) reducing the volume of the extraction phase. Under the optimal condition tested, 85% of the product formed was extracted and a product concentration value of 9 g/L was reached. However, co‐extraction of the unreacted amine donor (17%) was observed. Advantages and drawbacks of this process compared to existing technologies, as well as possible optimization strategies are discussed

chemistry, physical
Hydrogel-Based Enzyme and Cofactor Co-Immobilization for Efficient Continuous Transamination in a Microbioreactor

Tadej Menegatti,Polona Žnidaršič-Plazl

DOI: https://doi.org/10.3389/fbioe.2021.752064

IF: 5.7

2021-11-04

Frontiers in Bioengineering and Biotechnology

Abstract:A microbioreactor was developed in which selected amine transaminase was immobilized together with the cofactor pyridoxal phosphate (PLP) to allow efficient continuous transamination. The enzyme and cofactor were retained in a porous copolymeric hydrogel matrix formed in a two-plate microreactor with an immobilization efficiency of over 97%. After 10 days of continuous operation, 92% of the initial productivity was retained and no leaching of PLP or enzyme from the hydrogel was observed. The microbioreactor with co-immobilized cofactor showed similar performance with and without the addition of exogenous PLP, suggesting that the addition of PLP is not required during the process. The space-time yield of the microbioreactor was 19.91 g L −1 h −1 , while the highest achieved biocatalyst productivity was 5.4 mg mg enzyme −1 h −1 . The immobilized enzyme also showed better stability over a wider pH and temperature range than the free enzyme. Considering the time and cost efficiency of the immobilization process and the possibility of capacity expansion, such a system is of great potential for industrial application.

multidisciplinary sciences
Highly Efficient Production of Optically Active ( R )-Tetrahydrothiophene-3-ol in Batch and Continuous Flow by Using Immobilized Ketoreductase

Vyasa Williams,Yuxia Cui,Jiadong Zhao,Han Fu,Xuecheng Jiao,Yulei Ma,Xiang Li,Xin Du,Na Zhang

DOI: https://doi.org/10.1021/acs.oprd.1c00383

2022-02-15

Abstract:In this work, an engineered ketoreductase, apKRED-9, derived from Acetobacter pasteurianus 386B was successfully immobilized on two platforms, namely, glutaraldehyde-activated amino polymer beads, LX1000 HA, and cofactor enriched poly(ethylenimine) (CEP) mediated coaggregation followed by glutaraldehyde cross-linking, respectively. The enzyme apKRED-9 immobilized on LX1000HA was evaluated in a packed bed reactor (PBR) for continuous-flow synthesis of (R)-tetrahydrothiophene-3-ol from 3-keto tetrahydrothiophene in an aqueous-isopropanol mixture, while the enzyme apKRED-9 immobilized on CEP was tested in batch mode until pilot scale for the same reaction. The long-term operational stability of the enzyme in both continuous-flow and batch modes was demonstrated, with high conversion of >99.0% and ee > 99.5% in both the cases. From the pilot-scale application of apKRED-9-CEP, (R)-tetrahydrothiophene-3-ol was obtained (118.0 g, GC purity 99.9%, chiral purity ee 99.9% and yield 76.3%). In the PBR flow reactor, the productivity in terms of space time yield (STY) 729 g L–1 d–1 was achieved with 64 h of continuous usage. Based on performance metrics, both platforms are scalable and reproducible, while CEP offers additional advantages on effective cost and adaptability to other enzymes.

chemistry, organic, applied
Carrier-free immobilized enzymatic reactor based on CipA-fused carbonyl reductase for efficient synthesis of chiral alcohol with cofactor self-sufficiency

Yao-Wu Wang,Han-Yu Liu,Zhi-Wen Duan,Pan Ning,Hai-Min Zhang,Feng Qian,Pu Wang

DOI: https://doi.org/10.1016/j.ijbiomac.2024.133873

Abstract:In this study, based on the self-assembly strategy, we fused CipA with carbonyl reductase LXCARS154Y derived from Leifsonia xyli by gene coding, and successfully performed the carrier-free immobilization of LXCARS154Y. The immobilized enzyme was then characterized using scanning electron microscope (SEM), dynamic light scattering (DLS) and fourier transform infrared spectroscopy (FTIR). Compared with the free enzyme, the immobilized LXCARS154Y exhibited a 2.3-fold improvement in the catalytic efficiency kcat/km for the synthesis of a chiral pharmaceutical intermediate (R)-3,5-bis(trifluoromethyl)phenyl ethanol ((R)-BTPE) by reducing 3,5-bis(trifluoromethyl)acetophenone (BTAP). Moreover, the immobilized enzyme showed the enhanced stability while maintaining over 61 % relative activity after 18 cycles of batch reaction. Further, when CipA-fused carbonyl reductase was employed for (R)-BTPE production in a continuous flow reaction, almost complete yield (97.0 %) was achieved within 7 h at 2 M (512.3 g/L) of BTAP concentration, with a space-time yield of 1717.1 g·L-1·d-1. Notably, we observed the retention of cofactor NADH by CipA-based enzyme aggregates, resulting in a higher total turnover number (TTN) of 4815 to facilitate this bioreductive process. This research developed a concise strategy for efficient preparation of chiral intermediate with cofactor self-sufficiency via continuous flow biocatalysis, and the relevant mechanism was also explored.
Biocatalytic Production of Ethyl Butyrate from Butyric Acid with Immobilized Candida Rugosa Lipase on Cotton Cloth

Chengliang Shu,Jin Cai,Lei Huang,Xiangcheng Zhu,Zhinan Xu

DOI: https://doi.org/10.1016/j.molcatb.2011.05.011

2011-01-01

Abstract:A novel method involving polyethylenimine (PEI) coating and glutaraldehyde cross-linking processes was developed to immobilize Candida rugosa lipase onto cotton cloth. After the systematic investigation, the optimal lipase immobilization was achieved when 0.1g lipase was loaded on 1.5g support, which was pretreated with 10ml of 1.0mg/ml PEI solution at pH 8.0. Subsequent catalytic analysis of immobilized lipase for ethyl butyrate synthesis was also carried out in the Erlenmeyer flasks. The results indicated that when optimal 0.25M ethanol and 0.6M butyric acid were catalyzed by the immobilized lipase at 25°C, the highest conversion yield of 91.2% and 1.27mmolh−1g−1 productivity of ethyl butyrate were obtained. Furthermore, a kinetic model of Ping Pong Bi-Bi mode with inhibition of both substrates was proposed and validated by experimental data. To explore the practical potential of immobilized lipase, its operational stability was evaluated and the residual activity was remained about 50% after 12 repeated recycles, with a half-life time of about 300h for the immobilized lipase. Finally, a recycle batch reactor using immobilized lipase was developed for ethyl butyrate production. The achieved result of 0.85M final ethyl butyrate concentration, with the conversion of 70.6% and the productivity of 1.45mmolh−1g−1, had revealed the promising potential of this immobilized lipase in practical applications.
Efficient Production of S-(+)-2-chlorophenylglycine by Immobilized Penicillin G Acylase in a Recirculating Packed Bed Reactor

Ya-Ping Xue,Tao Jiang,Xue Liu,Yu-Guo Zheng

DOI: https://doi.org/10.1016/j.bej.2013.03.005

IF: 3.9

2013-01-01

Biochemical Engineering Journal

Abstract:(S)-(+)-2-Chlorophenylglycine 1 is an important intermediate in the synthesis of Clopidogrel. A recirculating packed bed reactor (RPBR) was constructed for efficient production of (S)-1 by kinetic resolution of racemic N-phenylacetyl-2- chlorophenylglycine 2 using immobilized penicillin G acylase (PGA). The immobilized PGA exhibited maximum activity at 50 degrees C and pH 8.0 with (R,S)-2 as substrate. The kinetic constants (K-m and v(max)) of immobilized PGA were calculated to be 20.61 mM and 83.2 mM/min/g, respectively. The substrate displayed inhibitory effect on immobilized PGA with inhibition constant of 221.23 mM. The immobilized PGA showed a strict enantiospecificity for substrate at different temperature, pH and substrate concentration examined. The performance and productivity of RPBR were evaluated by several critical parameters, including immobilized PGA load, substrate feeding rate, height to diameter ratio and so on. The kinetic resolution process shows higher initial reaction rate and conversion by recycling 100 mL of substrate solution (80 mM) through RPBRs packed with 6.0 g immobilized PGA with a feeding rate of 1.5 mL/min while the HID ratio was 4.0. The immobilized PGA-catalyzed kinetic resolution of (R,S)-2 was successfully operated in the RPBR for 60 batches, with an average productivity of 1.2 g/L/h for (5)-1 in high optical purity (>97% enantiomeric excess) in semi-continuous operation. The residual (R)-2 can be easily racemized and then used as substrate. (C) 2013 Elsevier B.V. All rights reserved.
Continuous-Flow Chemoenzymatic Enantioselective Synthesis of Chiral α-Mono- and Difluoromethyl Amines

Chen Huang,Yunting Liu,Weixi Kong,Guanhua Liu,Liya Zhou,Ying He,Jing Gao,Yanjun Jiang

DOI: https://doi.org/10.1021/acscatal.3c03795

IF: 12.9

2023-09-20

ACS Catalysis

Abstract:The enantioselective synthesis of chiral fluorinated amines is of great importance but highly challenging in synthetic chemistry and the pharmaceutical industry. Herein, we established a chemoenzymatic cascade for enantioselective synthesis of chiral α-mono- and difluoromethyl amines from easily available β-keto-acid esters in water–oil–solid multiphasic systems via two catalytic modules, i.e., organo-enzymatic decarboxylative fluorination and bienzymatic reductive amination. An efficient continuous synthesis system was constructed by stepwise enzyme immobilization, biphasic system construction, and continuous-flow operation to achieve process intensification. The flow system achieved a high space-time yield of up to 19.7 g L–1 h–1, which was a 35-fold enhancement compared to the batch system using free enzymes, and also demonstrated high operational stability, maintaining 87% of the production activity after 96 h with a half-life of 443.9 h.

chemistry, physical
Production of L-alanyl-L-glutamine by immobilized Escherichia coli expressing amino acid ester acyltransferase

Xuze Pei,Yimin Li,Cong Du,Tangguo Yuan,Chao Fan,Hao Hong,Wenjie Yuan

DOI: https://doi.org/10.1007/s00253-020-10752-3

Abstract:Production of Ala-Gln by the E. coli expressing α-amino acid ester acyltransferase was a promising technical route due to its high enzyme activity, but the continuous production ability still needs to improve. Therefore, the immobilized E. coli expressing α-amino acid ester acyltransferase was applied for the continuous production of Ala-Gln. Four materials were selected as embedding medium for the whole cell entrapment of recombinant bacteria. Calcium alginate beads were found to be the most proper entrapment carrier for production of Ala-Gln. The temperature, pH, and repeatability of the immobilized cell were compared with free cells. Results showed that immobilization cell could maintain a wider range of temperature/pH and better stability than free cell (20-35 °C/pH 8.0-9.0, and 25 °C/pH 8.5, respectively). On this basis, continuous production strategy was put forward by filling the immobilized cell in the tubular reactor with multiple control conditions. The Ala-Gln by immobilization cell achieved the productivity of 2.79 mg/(min*mL-CV) without intermittent time. Consequently, these findings suggest that the immobilization technique has potential applications in the production of Ala-Gln by biotechnological method. KEY POINTS: • Immobilization helps to achieve high efficiency production of Ala-Gln. • Immobilized cells have better stability than free cells. • Sodium alginate is the most suitable immobilized material.

Transparent motion from feature- and luminance-based processes

Activity and stability of different immobilized preparations of recombinant E. coli cells containing ω-transaminase

Membrane-immobilized transaminases for the synthesis of enantiopure amines

Driving Transamination Irreversible by Decomposing Byproduct Α-Ketoglutarate into Ethylene Using Ethylene-Forming Enzyme

[Immobilizing engineered Escherichia coli cells into zeolitic imidazolate framework 8 for efficient biosynthesis of Ala-Gln].

Effect of Immobilization by Modified Ultrastable-Y Molecular Sieve on the Resolution of (R,s)-2-octanol in Nonaqueous Media by Lipase

Continuous Preparative Application of Amine Transaminase‐Catalyzed Reactions with Integrated Crystallization

Medicare's Hospital Readmissions Reduction Program in Surgery May Disproportionately Affect Minority-serving Hospitals.

Co-immobilization of amine dehydrogenase and glucose dehydrogenase for the biosynthesis of (S)-2-aminobutan-1-ol in continuous flow

Process Understanding of Transamination Reaction in Chiral Pharmaceutical Intermediate Production Catalyzed by an Engineered Amine Transaminase

Stemphylium lycopersici immobilized in mesoporous of type MCM 48 as biocatalyst for ω-transamination reactions

Rational Design of Transaminases Based on Comparative Analysis of Catalytically Active and Distance-Free Modes of the High-Energy Intermediate State

Progressive outer retinal necrosis caused by varicella-zoster virus in children with acquired immunodeficiency syndrome.

Three‐liquid‐phase Spinning Reactor for the Transaminase‐catalyzed Synthesis and Recovery of a Chiral Amine

Hydrogel-Based Enzyme and Cofactor Co-Immobilization for Efficient Continuous Transamination in a Microbioreactor

Highly Efficient Production of Optically Active ( R )-Tetrahydrothiophene-3-ol in Batch and Continuous Flow by Using Immobilized Ketoreductase

Carrier-free immobilized enzymatic reactor based on CipA-fused carbonyl reductase for efficient synthesis of chiral alcohol with cofactor self-sufficiency

Biocatalytic Production of Ethyl Butyrate from Butyric Acid with Immobilized Candida Rugosa Lipase on Cotton Cloth

Efficient Production of S-(+)-2-chlorophenylglycine by Immobilized Penicillin G Acylase in a Recirculating Packed Bed Reactor

Continuous-Flow Chemoenzymatic Enantioselective Synthesis of Chiral α-Mono- and Difluoromethyl Amines

Production of L-alanyl-L-glutamine by immobilized Escherichia coli expressing amino acid ester acyltransferase