Abstract:As a prerequisite to the development of real label-free bioassay applications, a high-throughput top-down nanofabrication process is carried out with a combination of nanoimprint lithography, anisotropic wet-etching, and photolithography methods realizing nanoISFET arrays that are then analyzed for identical sensor characteristics. Here, a newly designed array-based sensor chip exhibits 32 high aspect ratio silicon nanowires (SiNWs) laid out in parallel with 8 unit groups that are connected to a very highly doped, Π-shaped common source and individual drain contacts. Intricately designed contact lines exert equal feed-line resistances and capacitances to homogenize the sensor response as well as to minimize parasitic transport effects and to render easy integration of a fluidic layer on top. The scalable nanofabrication process as outlined in this article casts out a total of 2496 nanowires (NWs) on a 4 inch p-type silicon-on-insulator (SOI) wafer, yielding 78 sensor chips based on nanoISFET arrays. The sensor platform exhibiting high-performance transistor characteristics in buffer solutions is thoroughly characterized using state-of-the-art surface and electrical measurement techniques. Deploying a pH sensor in liquid buffers after high-quality gas-phase silanization, nanoISEFT arrays demonstrate typical pH sensor behavior with sensitivity as high as 43 ± 3 mV·pH-1 and a device-to-device variation of 7% at the wafer scale. Demonstration of a high-density sensor platform with uniform characteristics such as nanoISFET arrays of silicon (Si) in a routine and refined nanofabrication process may serve as an ideal solution deployable for real assay-based applications.

High-Performance Field-Effect Sensing of Ammonia Based on High-Density and Ultrathin Silicon Nanowire Channels

Highly Sensitive Ammonia Gas Detection at Room Temperature by Integratable Silicon Nanowire Field-Effect Sensors

Fabrication of Silicon Nanowire Ph Sensors Using High Output, Low Cost Sidewall Mask Technology

A 3-D-silicon Nanowire FET Biosensor Based on a Novel Hybrid Process

Highly sensitive pH sensors based on double-gate silicon nanowire field-effect transistors with dual-mode amplification

Monolayer Two‐dimensional Molecular Crystals for an Ultrasensitive OFET‐based Chemical Sensor

Nanowire Field-Effect Transistor Sensors

Fabrication of Low Cost and Low Temperature Poly-Silicon Nanowire Sensor Arrays for Monolithic Three-Dimensional Integrated Circuits Applications

Application of Silicon Nanowire Field Effect Transistor (SiNW-FET) Biosensor with High Sensitivity

Self-aligned Multi-Channel Silicon Nanowire Field-Effect Transistors

Terrace-confined guided growth of high-density ultrathin silicon nanowire array for large area electronics

Low-Noise Schottky Junction Trigate Silicon Nanowire Field-Effect Transistor for Charge Sensing

Ph Response of Silicon Nanowire Sensors: Impact of Nanowire Width and Gate Oxide

A Theoretical and Simulation Analysis of the Sensitivity of SiNWs-FET Sensors

On the Use of Scalable NanoISFET Arrays of Silicon with Highly Reproducible Sensor Performance for Biosensor Applications

Design and Performance Analysis of Ultrathin Nanowire FET Ammonia Gas Sensor

The possibility of ultrasensitive detection of biomolecules using silicon nanowire biosensor with structural optimization

Nanowire biosensors for label-free, real-time, ultrasensitive protein detection.

Electric-field assisted silicon nanowire field effect transistor for the ultra-low concentration nucleic acid detection

Silicon-based nanoelectronic field-effect pH sensor with local gate control

A Novel NH3 Sensing Mechanism Based on Au Pads Activated Schottky Barrier MOSFET on Silicon-on-Insulator With Extremely High Sensitivity at Room Temperature