Abstract:Froth flotation stands as the preferred technique for the separation of charcoal and ash from coal gasification fine slag (CGFS). However, the presence of a well-developed pore structure and an abundance of oxygen-containing functional groups on the surface of residual charcoal necessitates the use of substantial dosage of collectors during the flotation of CGFS. To address this, a high internal phase water-in-oil (HIP W/O) emulsion, with an internal phase water volume fraction of 85 %, was formulated for the flotation decarburization of CGFS, with the objective of reducing the collector dosage. The outcomes of flotation tests demonstrated that at dosages of 50 kg/t for kerosene and 15.04 kg/t for the organic liquid of the HIP W/O emulsion, both were capable of yielding tailings with an ash content exceeding 95 %. The results from Cryo-SEM and viscosity tests suggest that the high viscosity characteristics of the HIP W/O emulsion are primarily attributed to the compact arrangement of emulsion droplets and the active influence of emulsifiers at the oil–water interface. High-speed camera observations revealed that the HIP W/O emulsion droplets exhibited a tendency to disperse into bar-shaped flocs with larger particle sizes in water. This particular dispersion morphology is advantageous for enhancing the oil agglomeration flotation mechanism within the flotation decarburization process of CGFS. LF-NMR tests have further substantiated that the emulsion droplets are not readily absorbed by the microporous structure of the residual charcoal within the CGFS. Wettability tests and FTIR analyses have demonstrated that the hydrophobic modification of the residual charcoal surface, achieved through the HIP W/O emulsion, markedly surpasses that of conventional kerosene. The combination of these results indicates that the use of HIP W/O emulsion in the flotation decarbonization process of CGFS offers multiple benefits. It not only significantly reduces the dosage of organic collectors required, but also enhances the economic efficiency and effectiveness of the flotation process, presenting a novel reagent option for the decarbonization of CGFS.

Recovering hydrocarbon from oily sludge using supercritical CO 2 : Experiments and a new method for predicting optimal conditions

Low-carbon treatment and remediation of oil sludge in mid-to-high latitude regions: A coupled approach of freeze-thaw and supercritical CO2 extraction

Research on oil recovery of oily sludge by subcritical/supercritical hydrothermal upgrading

Experimental Investigation on the Degradation of Polymer-Containing Oily Sludge in Sub-/Supercritical Water

Investigation on the Composition and Extraction Mechanism of the Soluble Species from Oily Sludge by Solvent Extraction

Simulation of multiphase behavior in supercritical CO2–heavy oil–water sludge extraction systems using cubic-plus-association equation of state

Extraction of kerogen from oil shale with supercritical carbon dioxide: Molecular dynamics simulations

Insight into water-enhanced CO2 extraction in the treatment of oily sludge

The solvent extraction is a potential choice to recover asphalt from unconventional oil ores

Research on a harmless treatment method for oily sludge in coal chemical wastewater and the pollutant transformation mechanism of oily sludge during the treatment process

Subcritical Hydrothermal Purification from Oily Sludge Recovered from Petroleum Oily Sludge by Adding Sodium Hydroxide, Sodium Bicarbonate, and Formic Acid

Molecular Insights into the Synergistic Mechanisms of Hybrid CO2-surfactant Thermal Systems at Heavy Oil-Water Interfaces

Experimental Study on Supercritical Water Gasification of Oily Sludge Using a Continuous Two-Step Method

Chemical reactions of oily sludge catalyzed by iron oxide under supercritical water gasification condition

Probe into a novel surfactant-free microemulsion system of ethylene glycol monobutyl ether + water + diesel for crude oil removal and recovery from oily sludge

Experimental study on supercritical water oxidation of oily sludge with auxiliary fuels

Experimental Investigation on Hydrocarbon Generation of Organic-Rich Shale with Low Maturity in Sub- and Supercritical Water

Mechanism of Highly Efficient Oil Removal from Spent Hydrodesulfurization Catalysts by Ultrasound-Assisted Surfactant Cleaning Methods

Investigation of high internal phase water-in-oil emulsion on coal gasification fine slag flotation decarburization and its oil saving mechanism

The Resource Utilization of Oily Sludge by Co-Gasification with Coal