Abstract:Improving the contamination resistance of membranes is one of the most effective ways to address the short service life of membranes. While preparing the membrane system structure, doping nanoparticles into the polymer matrix is beneficial to the preparation of high-performance membranes. To develop a new structure for membrane contamination protection, in this study, a novel asymmetric polyamide 66 composite ultrafiltration (UF) membrane was fabricated by incorporating different masses (ranging from zero to 0.5 wt.%) of graphene oxide (GO) into the polyamide 66 microporous substrate, using formic acid and propylene carbonate as solvents. The effects of GO doping on the morphology, microporous structure and surface of ultrafiltration membranes were investigated by atomic force microscopy (AFM), scanning electron microscopy (SEM), integrated thermal analysis (DSC) and contact angle (CA). In addition, pure water flux, bovine serum albumin (BSA) rejection and contamination resistance were measured to evaluate the filtration performance of different membranes. The overall performance of all the modified membranes was improved compared to pure membranes. The results of contact angle and permeation experiments showed that the addition of GO improved the hydrophilicity of the membrane, but reduced the permeability of the membrane. The minimum flux was only 3.5 L/m2·h, but the rejection rate was 92.5%. Most noteworthy was the fact that GO further enhanced the anti-pollution performance of the membranes and achieved a remarkable performance of 91.32% when the GO content was 0.5 wt.%, which was 1.36 times higher than that of the pure membrane. Therefore, optimal performance was achieved. Furthermore, the UF membrane made of composite substrate offers a promising solution for the development of long-life ultrafiltration membranes with better stability, high-cost efficiency and adequate chemical durability.

Performance investigation on GO-TiO2/PVDF composite ultrafiltration membrane for slightly polluted ground water treatment

Graphene Oxide Based Membrane Intercalated by Nanoparticles for High Performance Nanofiltration Application

Preparation of polyvinylidene fluoride composite ultrafiltration membrane for micro-polluted surface water treatment

Azido-group Functionalized Graphene Oxide/polysulfone Mixed Matrix Ultrafiltration Membrane with Enhanced Interfacial Compatibility for Efficient Water and Wastewater Treatment

Multifunctional PVDF/CNT/GO Mixed Matrix Membranes for Ultrafiltration and Fouling Detection

Prepartion and separation performance of GO modified PVDF ultrafiltration membrane

Improvement of Heavy Metal Separation Performance by Positively Charged Small-Sized Graphene Oxide Membrane.

Evaluations of holey graphene oxide modified ultrafiltration membrane and the performance for water purification

Preparation and anti-fouling performance of polyvinylidene fluoride composite membranes modified with different contents of TiO2/GO

Preparation of graphene oxide/silica hybrid composite membranes and performance studies in water treatment

Regulating the surface properties and interlamellar spacing of GO-based nanofiltration membrane for efficient water treatment

Preparation and Characterization of Reduced Graphene Oxide /TiO2 Blended Polyphenylene sulfone Antifouling Composite Membrane With Improved Photocatalytic Degradation Performance

High performance GO/MXene/PPS composite filtration membrane for dye wastewater treatment under harsh environmental conditions

Graphene Oxide Modified Polyamide 66 Ultrafiltration Membranes with Enhanced Anti-Fouling Performance

Preparation of Graphene Oxide Modified Poly(m-Phenylene Isophthalamide) Nanofiltration Membrane with Improved Water Flux and Antifouling Property

Treatment of emulsified oily wastewater using graphene oxide / polyvinylidene fluoride hybridized ultrafiltration membrane

Organic-inorganic composite ultrafiltration membrane with anti-fouling and catalytic properties by in-situ co-casting for water treatment

Photocatalytic antifouling properties of novel PVDF membranes improved by incorporation of SnO2-GO nanocomposite for water treatment

Graphene oxide-polyethylene glycol incorporated PVDF nanocomposite ultrafiltration membrane with enhanced hydrophilicity, permeability, and antifouling performance

Systematic Evaluation of TiO2-GO-modified Ceramic Membranes for Water Treatment: Retention Properties and Fouling Mechanisms

Construction of Gradient SA-TiO2 Hydrogel Coated PVDF-g-IL Fibre Membranes with High Hydrophilicity and Self-Cleaning for the Efficient Separation of Oil-Water Emulsion and Dye Wastewater