Efficient biosynthesis of d-ribose using a novel co-feeding strategy in Bacillus subtilis without acid formation

J Cheng,W Zhuang,N N Li,C L Tang,H J Ying

DOI: https://doi.org/10.1111/lam.12685

Abstract:Normally, low d-ribose production was identified as responsible for plenty of acid formation by Bacillus subtilis due to its carbon overflow. An approach of co-feeding glucose and sodium citrate is developed here and had been proved to be useful in d-ribose production. This strategy is critical because it affects the cell concentration, the productivity of d-ribose and, especially, the formation of by-products such as acetoin, lactate and acetate. d-ribose production was increased by 59·6% from 71·06 to 113·41 g l-1 without acid formation by co-feeding 2·22 g l-1 h-1 glucose and 0·036 g l-1 h-1 sodium citrate to a 60 g l-1 glucose reaction system. Actually, the cell density was also enhanced from 11·51 to 13·84 g l-1 . These parameters revealed the importance of optimization and modelling of the d-ribose production process. Not only could zero acid formation was achieved over a wide range of co-feeding rate by reducing glycolytic flux drastically but also the cell density and d-ribose yield were elevated by increasing the hexose monophosphate pathway flux. Significance and impact of the study: Bacillus subtilis usually produce d-ribose accompanied by plenty of organic acids when glucose is used as a carbon source, which is considered to be a consequence of mismatched glycolytic and tricarboxylic acid cycle capacities. This is the first study to provide high-efficiency biosynthesis of d-ribose without organic acid formation in B. subtilis, which would be lower than the cost of separation and purification. The strain transketolase-deficient B. subtilis CGMCC 3720 can be potentially applied to the production of d-ribose in industry.