Abstract:β-carotene is the major carotenoid in carrots and the most widely studied natural carotenoid. It is very import in foods, for it adds the color to the food products, and also associates with human health. For example, it is the most potent precursor of vitamin A and has a potent antioxidant capacity. It also can lower the risk of heart diseases and certain types of cancers. However, the utilization ofβ-carotene as a nutraceutical ingredient in the food industry is currently limited because of its poor water-solubility, high melting point, low chemical stability and bioavailability. Oil-in-water emulsions are often a better choice for deliveringβ-carotene into functional foods since the emulsions increase bioavailability. One factor which can influenceβ-carotene stability in oil-in-water emulsions is the chemical and physical properties of the interface formed between oil and water, as some researchers reported protein has a positive effect on the degradation ofβ-carotene in oil-in-water emulsion. In this research, we usedα-lactalbumin (α-LA) as emulsifier to stabilize nanoemulsion to deliverβ-carotene. The effects ofα-LA on the particle size, the zeta-potential, the encapsulation rate, the oil-water interfacialα-LA concentration, and the physical and chemical stability ofβ-carotene emulsion were determined. The mean particle diameter (Z-average) and zeta-potential ofβ-carotene emulsion were measured using the laser particle size analyzer (Malvern Instruments Ltd.) based on the dynamic light scattering principle. The particle size decreased and the zeta-potential increased with the increasing of the added amount ofα-LA inβ-carotene emulsion; but they did not change significantly (P>0.05) after adding more than 1.50%α-LA as the emulsifier. Adding moreα-LA (0.25%-1.50%), the encapsulation rate was improved in a dose-dependent manner (P<0.05), however, there was no significant difference in the encapsulation rate when more than 1.50%α-LA was added inβ-carotene emulsion. We used Turbiscan Lab Expert to evaluate the physical stability ofβ-carotene emulsion. Turbiscan stability index (TSI) of the top part ofβ-carotene emulsion was determined. TSI decreased with the increasing of the amount of addedα-LA. When the addition ofα-LA was more than 1.50%, there was no change in TSI, which meant the physical stability ofβ-carotene emulsion had become good. To remove continuous phaseα-LA inβ-carotene emulsion, we used the ultra high speed centrifuge to separate the oil phase and aqueous phase. The interfacialα-LA concentration increased significantly with the increasing addition ofα-LA (P<0.05). There was multilayeredα-LA on the interface between oil and water. This could explain the change of particle size, zeta-potential, encapsulation rate and TSI ofβ-carotene emulsion with the increasing addition ofα-LA.β-carotene concentrations in emulsion samples were analyzed through the whole storage time. With lessα-LA (0.25%-0.75%) the more degradation ofβ-carotene was observed during the storage under 55℃. The chemical stability ofβ-carotene was improved when more than 1.00%α-LA was added as the emulsifier inβ-carotene emulsion. These results show thatα-LA can be a kind of good emulsifier and the proper amount of addition is 1.50% inβ-carotene emulsion. This study can be helpful to increaseβ-carotene utilization in food industry.

Role of continuous phase protein, (-)-epigallocatechin-3-gallate and carrier oil on β-carotene degradation in oil-in-water emulsions

Impact of Chitosan–egcg Conjugates on Physicochemical Stability of Β-Carotene Emulsion

Physicochemical characterisation of β-carotene emulsion stabilised by covalent complexes of α-lactalbumin with (-)-epigallocatechin gallate or chlorogenic acid.

α-lactalbumin enhancing emulsion stability ofβ-carotene

Physicochemical Properties of Β-Carotene Bilayer Emulsions Coated by Milk Proteins and Chitosan–egcg Conjugates

Physical and chemical stability of β-carotene-enriched nanoemulsions: Influence of pH, ionic strength, temperature, and emulsifier type

Utilization of Interfacial Engineering to Improve Physicochemical Stability of Β-Carotene Emulsions: Multilayer Coatings Formed Using Protein and Protein–polyphenol Conjugates

Characterization and utilization of soy protein isolate-(-)-epigallocatechin gallate-maltose ternary conjugate as an emulsifier for nanoemulsions: Enhanced physicochemical stability of the β-carotene nanoemulsion

Evaluation of Non-Covalent Ternary Aggregates of Lactoferrin, High Methylated Pectin, EGCG in Stabilizing Β-Carotene Emulsions.

Physicochemical stability of corn protein hydrolysate/tannic acid complex-based β-carotene nanoemulsion delivery system

Influence of pH, metal chelator, free radical scavenger and interfacial characteristics on the oxidative stability of β-carotene in conjugated whey protein-pectin stabilised emulsion.

Effects of Antioxidants on the Stability of Β-Carotene in O/W Emulsions Stabilized by Gum Arabic

A glycated whey protein isolate-epigallocatechin gallate nanocomplex enhances the stability of emulsion delivery of β-carotene during simulated digestion

Evaluation of Structural and Functional Properties of Protein–egcg Complexes and Their Ability of Stabilizing a Model Β-Carotene Emulsion

Controlling the Potential Gastrointestinal Fate of Β-Carotene Emulsions Using Interfacial Engineering: Impact of Coating Lipid Droplets with Polyphenol-Protein-carbohydrate Conjugate.

Stability of Β-Carotene in Oil-in-Water Emulsions Prepared by Mixed Layer and Bilayer of Whey Protein Isolate and Beet Pectin

Development of -carotene loaded oil-in-water emulsions using mixed biopolymer-particle-surfactant interfaces

Physicochemical Properties and Chemical Stability of Β-Carotene Bilayer Emulsion Coated with Bovine Serum Albumin and Arabic Gum Compared to Monolayer Emulsions.

Stability and in Vitro Digestibility of Beta‐carotene in Nanoemulsions Fabricated with Different Carrier Oils

Emulsifier Dependent in vitro Digestion and Bioaccessibility of β-Carotene Loaded in Oil-in-Water Emulsions

Effect Of Polyglycerol Esters Of Fatty Acids On The Physicochemical Properties And Stability Of Beta-Carotene Emulsions During Digestion In Simulated Gastric Fluid