Abstract:Noncovalently cross-linked hydrogels can exhibit toughness and mechanical adaptability typically associated with biological tissues, which make them promising for a variety of applications. However, molecules in the environment can interact to significantly alter the properties of these hydrogels, which could adversely impact their performance. Here, we illustrate how two common ionic surfactants, sodium dodecyl sulfate (SDS) and cetyltrimethylammonium bromide (CTAB), influence the swelling and rheological properties of hydrogel films cross-linked by hydrophobic associations based on a random copolymer of poly(N,N-dimethylacryalmide-co-2-(N-ethylperfluorooctanesulfonamido)ethyl acrylate (DMA-FOSA) using a quartz crystal microbalance with dissipation (QCM-D). The effect of the surfactants on the swelling and dissolution of these physically crosslinked hydrogels is contrasted with the effect of aqueous 2-propanol (IPA), which can dissolve the copolymer readily. The addition of IPA, SDS, and CTAB at low concentrations increases the swelling of the hydrogel film, decreases the elastic modulus, and increases the rheological phase angle (more fluidlike). A transition from swelling to (partial) dissolution occurs at higher concentrations with a threshold of approximately 7 wt % IPA, 0.1.cmc for SDS, and 0.5.cmc for CTAB to promote partial dissolution. With IPA, initial swelling is always observed immediately after the solvent is added, whereas the initial swelling can be significantly delayed with long incubation times to dissolution, on the order of hours, at low concentrations of surfactant. These results illustrate that simple ionic surfactants can dissolve these hydrophobically cross-linked hydrogels, but identification of the maximum concentration of surfactant that will not dissolve the hydrogels may be challenged by the long incubation times that increase as the concentration decreases. The long times to dissolve these thin films (initial thickness <200 nm for copolymer) suggest that stability of bulk physically cross-linked hydrogels in complex aqueous environments may be challenging to accurately assess if surfactant diffusion is the limiting factor.

Hysteresis in the surfactant-induced volume transition of hydrogels

Interface-induced hysteretic volume phase transition of microgels: simulation and experiment

Hystereses in flow-induced compression of a poroelastic hydrogel

Delayed Swelling and Dissolution of Hydrophobically Associated Hydrogel Coatings by Dilute Aqueous Surfactants

Hyper-Auxeticity and the Volume Phase Transition of Polymer Gels

Formation and Phase Transition of Hydrogel in a Zwitterionic/anionic Surfactant System

The swelling and shrinking of spherical thermo-responsive hydrogels

Swelling and shrinking kinetics of a lamellar gel phase

Modeling Investigation of Hydrogel Volume Transition

Mechanics Underpinning Phase Separation of Hydrogels

A comparative analysis of transient finite-strain coupled diffusion-deformation theories for hydrogels

Swelling dynamics of surface-attached hydrogel thin films in vapor flows

Quantifying the Equilibrium Swelling Responses and Swelling-Induced Snap-Through of Heterogeneous Spherical Hydrogels

Volume Phase Transition of Swollen Gels: Discontinuous or Continuous?

Wetting hysteresis induced by nanodefects

Hyperelastic swelling of stiff hydrogels

A theory of hydrogel mechanics that couples swelling and external flow

Hysteresis‐Free Nanoparticle‐Reinforced Hydrogels

Theory of Sorption Hysteresis in Nanoporous Solids: I. Snap-Through Instabilities

On the blistering of thermo-sensitive hydrogel: the volume phase transition and mechanical instability.