Abstract:Monoethanolamine (MEA) based CO2 capture in coal-fired power plants would consume a huge amount of the steam bleed from the steam turbines for the solvent regeneration. The unmatched steam bleed parameters for the solvent regeneration, as well as the huge amount of the process waste heat within the CO2 capture process, inevitably bringing about a significant efficiency penalty. In this study, a novel de-carbonization supercritical coal-fired power plant, which encompasses a supplementary steam turbine (SST), process heat recovery and a modified boiler heating exchangers configuration was proposed. In the proposed system, the steam bleeds for the reboiler and part of the regenerative heaters are coming from the SST, which is located in the upstream of the reheater (steam side), instead of the high and intermediate-pressure turbines (IPT), making the parameters of the steam bleed more matched with the solvent regeneration and feed water heating. In addition, part of the process heat within the CO2 capture/compression unit was efficiently recovered and beneficially used to heat the ambient air before its entering the air pre-heater. The saved flue gas can then be used to heat the feed/condensed water in the low-temperature economizer (LTE), saving part of the steam bleed from the turbines. The configuration of the superheaters/reheaters, as well as the air preheaters were also modified. The mass and energy balance as well as the system thermodynamic performance were determined by the developed models and process simulation. The economic performance of the proposed system was assessed by the cost of electricity (COE) and the cost of CO2 avoided (COA). Finally, the off-design performance of the proposed system was determined. Results showed that the energy efficiency penalty of the proposed system could decrease by 3.86%-points as compared to the reference system. The COE and COA of the proposed system without considering the CO2 transportation and storage cost were $86.11/MWh and $36.92/ton CO2, respectively, both less than those of the reference plant. The off-design operation analysis indicated that the proposed plant also featured a thermodynamics superiority in a wide range of power load variation.

Design and optimization of waste heat recovery system for supercritical carbon dioxide coal-fired power plant to enhance the dust collection efficiency

Study on Heat Recovery System of Coal-Fired Power Plant Integrated With SCO2 Power Cycle

Thermodynamic Analysis of Coal-Fired Thermal Power Units Coupled S-CO2 Energy Storage System

Thermo-Economic Optimization on the Waste Heat Recovery System of SCO2 Coal-Fired Power Plants

Optimization and Comparison on Supercritical CO2 Power Cycles Integrated Within Coal-Fired Power Plants Considering the Hot and Cold End Characteristics

Thermo-economic analyses on a new conceptual system of waste heat recovery integrated with an S-CO2 cycle for coal-fired power plants

Thermodynamic and Economic Comparison of Supercritical Carbon Dioxide Coal‐fired Power System with Different Improvements

Performance analysis of an efficient waste heat utilization system in an ultra-supercritical coal-fired power plant

Innovative System Configuration Analysis and Design Principle Study for Different Capacity Supercritical Carbon Dioxide Coal-Fired Power Plant

Performance Analysis and Optimization of Flue Gas Waste Heat Recovery System of a 600MW Coal-Fired Power Plant

Thermodynamic Optimization on Supercritical Carbon Dioxide Brayton Cycles to Achieve Combined Heat and Power Generation

An integrated de-carbonization supercritical coal-fired power plant incorporating a supplementary steam turbine, process heat recovery and a modified boiler structure

Preliminary Design Assessment of Supercritical CO2 Cycle for Commercial Scale Coal-Fired Power Plants

Improved Design of Supercritical CO2 Brayton Cycle for Coal-Fired Power Plant

Energy and Exergy Analyses of an Improved Recompression Supercritical CO2 Cycle for Coal-Fired Power Plant

System Design and Thermo-Economic Analysis of a New Coal Power Generation System Based on Supercritical Water Gasification with Full CO2 Capture

Heat Integration and Optimization of Supercritical CO2 Recompression Cycle Coupled with Oxy-Coal Combustion

Energy-Saving Optimization Study on 700°C Double Reheat Advanced Ultra-Supercritical Coal-Fired Power Generation System

Multi-objective optimization of supercritical CO 2 Brayton cycles for coal-fired power generation with two waste heat recovery schemes

System Design and Thermodynamic Analysis on a Coal Supercritical Water Gasification Power Generation System Integrated with Supercritical Carbon Dioxide Cycle

Optimal Structure Design of Supercritical CO2 Power Cycle for Gas Turbine Waste Heat Recovery: A Superstructure Method