Abstract:The rheo-dielectric response of carbon black filled elastomer melts is investigated by dielectric relaxation spectroscopy in the frequency range from 0.1 Hz up to 10 MHz during oszillatory shearing in a plate-plate rheometer. Various concentrations and types of carbon blacks dispersed in a non-crosslinked EPDM melt are considered. It is demonstrated that during heat treatment at low strain amplitude a pronounced flocculation of filler particles takes place leading to a successive increase of the shear modulus and conductivity. Followed up by a strain sweep, the filler network breaks up and both quantities decrease simultaneously with increasing strain amplitude. Two relaxation times, obtained from a Cole-Cole fit of the dielectric spectra, are identified, which both decrease strongly with increasing flocculation time. This behaviour is analyzed in the frame of fractal network models, describing the effect of structural disorder of the conducting carbon black network on the diffusive charge transport. Significant deviations from the predictions of percolation theory are observed, which are traced back to a superimposed cluster-cluster aggregation process (CCA). During flocculation, a universal scaling behaviour holds between the conductivity and the corresponding high frequency relaxation time, which fits all the measured data. The scaling exponent agrees fairly well with the prediction obtained from CCA. It is demonstrated that the underlying basic mechanism is a change of the correlation length of the filler network, i.e. the size of the fractal heterogeneities. This decreases during flocculation due to the formation of additional conductive paths, making the system more homogeneous. An addition less pronounced effect is found from nanoscopic gaps between adjacent filler particles, which decrease during flocculation. The same universal scaling behaviour, as obtained for flocculation, is found for temperature-dependent dielectric measurements of the cured crosslinked systems, which are heated from room temperature up to 200 °C. Thereby, the conductivity decreases significantly and the relaxation time increases, indicating that the filler network breaks up randomly due to the thermal expansion of the rubber matrix.

Decoupling elasticity and electrical conductivity of carbon black gels filled with insulating non-Brownian grains

Decoupling elasticity and electrical conductivity of carbon-black gels filled with insulating non-Brownian grains

Controlling the rheo-electric properties of graphite/carbon black suspensions by 'flow-switching'

Controlling the rheo-electric properties of graphite/carbon black suspensions by 'flow switching'

Reversible Nonlinear Conduction Behavior for High‐density Polyethylene/graphite Powder Composites Near the Percolation Threshold

Dual Origin of Viscoelasticity in Polymer-Carbon Black Hydrogels: A Rheometry and Electrical Spectroscopy Study

Interpenetration of fractal clusters drives elasticity in colloidal gels formed upon flow cessation

Impact of granular inclusions on the phase behavior of colloidal gels

Dielectric Properties of Exfoliated Graphite Reinforced Flouroelastomer Composites

Simultaneous rheo-electric measurements of strongly conductive complex fluids

Flow-Switched Bistability in a Colloidal Gel with Non-Brownian Grains

Energy processes and phase transition in granular assemblies

Electromagnetic Properties of Carbon Gels

Carbon black networking in elastomers monitored by simultaneous rheological and dielectric investigations

Mixtures of anisotropic and spherical colloids: Phase behavior, confinement, percolation phenomena and kinetics

Nonlinear Magneto-Electro-Mechanical Response of Physical Cross-Linked Magneto-Electric Polymer Gel

Effective conductivity in association with model structure and spatial inhomogeneity of polymer/carbon black composites

Anisotropic viscoelastic phase separation in polydisperse hard rods: non-sticky gelation

Nonequilibrium continuous phase transition in colloidal gelation with short-range attraction

Three length scales colloidal gels: the clusters of clusters versus the interpenetrating clusters approach

Contrasting the dynamics of elastic and non-elastic deformations across an experimental colloidal Martensitic transition