Abstract:Two pasteurization steps are often used in the preparation of whey protein concentrate (WPC) before evaporation into a dry product. The Pasteurized Milk Ordinance (PMO) in the United States requires that raw bovine milk be pasteurized using a process that meets minimum heat treatment requirements to achieve reductions in pertinent microorganisms. In addition, WPC produced from USDA-approved plants must comply with CFR Subpart B §58.809, which dictates that all fluid whey used in the manufacture of dry whey products shall be pasteurized before being condensed. These heat treatments are effective at inactivating the most thermally resistant bacterium, such as Coxiella burnetii; however, they can also alter milk proteins-inducing denaturation, aggregation and reduced bioactivity. Though the impact of thermal treatments on whey proteins has been examined, the specific influence of 2 high-temperature-short-time (HTST) pasteurization steps on the retention of proteins in WPC remains unknown. This study aimed to investigate the effect of commercial-scale HTST pasteurization of both raw milk and the resulting sweet whey on the products' overall protein profile. Three distinct batches of raw milk (RM) and corresponding pasteurized milk (PM), the resulting whey (RW) and pasteurized whey (PW) produced at commercial scale were analyzed. Assessments of denaturation were conducted through solubility testing at pH 4.6 and hydrophobicity evaluation via anilinonaphthalene-1-sulfonic acid assay (ANS). Additionally, enzyme-linked immunosorbent assay (ELISA), PAGE (PAGE) and liquid chromatography tandem mass spectroscopy (LC-MS/MS) were employed to compare the retention of key bioactive proteins before and after each HTST pasteurization step. The percentage of soluble whey protein decreased from RM to PM and from RW to PW, but no significant differences were observed via hydrophobicity assay. ELISA revealed a significant reduction in key bioactive proteins, such as lactoferrin, immunoglobulin A and immunoglobulin M, but not immunoglobulin G, after HTST pasteurization of RM and RW. PAGE and LC-MS/MS revealed a significant decrease in the retention of lactoferrin and key milk fat globular membrane proteins, such as xanthine dehydrogenase oxidase/xanthine oxidase, lactadherin and fatty acid binding protein. Additionally, xanthine oxidase activity was significantly reduced after HTST pasteurization of milk and whey. This research helps to identify the limitations of the current processing techniques used in the dairy industry and could lead to innovation in improving the retention of bioactive proteins.

Antioxidant activities of buttermilk proteins, whey proteins, and their enzymatic hydrolysates

Rheological, Physicochemical, Microbiological, and Aroma Characteristics of Sour Creams Supplemented with Milk Protein Concentrate

Proteomic Comparisons of Caprine Milk Whole Cream Buttermilk Whey and Cheese Whey Cream Buttermilk

Novel Antioxidant Peptides from Fermented Whey Protein by Lactobacillus rhamnosus B2-1: Separation and Identification by in Vitro and in Silico Approaches

Evaluation of Antimicrobial and Antioxidant Activities of Casein-Derived Bioactive Peptides Using Trypsin Enzyme

Antioxidant Activity of Sweet Whey Derived from Bovine, Ovine and Caprine Milk Obtained from Various Small-Scale Cheese Plants in Greece before and after In Vitro Simulated Gastrointestinal Digestion

Peptidomic profiling of fermented goat milk: considering the fermentation-time dependent proteolysis by Lactobacillus and characterization of novel peptides with Antioxidative activity

Antioxidant Activity of Peptides from Fermented Milk with Mix Culture of Lactic Acid Bacteria and Yeast

Characterization and application of a crude bacterial protease to produce antioxidant hydrolysates from whey protein

Effects of high temperature short time (HTST) pasteurization on milk and whey during commercial whey protein concentrate production

Purification and Characterization of Novel Antihypertensive and Antioxidative Peptides From Whey Protein Fermentate: In Vitro, In Silico, and Molecular Interactions Studies

The affinity of milk fat globule membrane fragments and buttermilk proteins to hydroxyapatite

Lipidomic Comparisons of Whole Cream Buttermilk Whey and Cheese Whey Cream Buttermilk of Caprine Milk

Physicochemical properties, antioxidant and antidiabetic activities of different hydrolysates of goat milk protein

Protein Hydrolysates Derived from Animals and Plants-A Review of Production Methods and Antioxidant Activity

Impact of Enzymatic Hydrolysis and Heat Inactivation on the Physicochemical Properties of Milk Protein Hydrolysates

Antioxidant Activity of Milk and Dairy Products

Probiotic Whey-Based Beverages from Cow, Sheep and Goat Milk: Antioxidant Activity, Culture Viability, Amino Acid Contents

Effect of buttermilk consumption on blood pressure in moderately hypercholesterolemic men and women

Enzymatic Hydrolysis Optimization of Yak Whey Protein Concentrates and Bioactivity Evaluation of the Ultrafiltered Peptide Fractions

Antibacterial Activity From Goat’s Milk Whey Hydrolized by Protease Enzyme of Bacillus Lincheniformis