Abstract:Heavier-than-air flight at any scale is energetically expensive. This is greatly exacerbated at small scales and has so far presented an insurmountable obstacle for untethered flight in insect-sized (mass less than 500 milligrams and wingspan less than 5 centimetres) robots. These vehicles<a href="#ref-CR1">1</a>,<a href="#ref-CR2">2</a>,<a href="#ref-CR3">3</a>,<a href="/articles/s41586-019-1322-0#ref-CR4">4</a> thus need to fly tethered to an offboard power supply and signal generator owing to the challenges associated with integrating onboard electronics within a limited payload capacity. Here we address these challenges to demonstrate sustained untethered flight of an insect-sized flapping-wing microscale aerial vehicle. The 90-milligram vehicle uses four wings driven by two alumina-reinforced piezoelectric actuators to increase aerodynamic efficiency (by up to 29 per cent relative to similar two-wing vehicles<a href="/articles/s41586-019-1322-0#ref-CR5">5</a>) and achieve a peak lift-to-weight ratio of 4.1 to 1, demonstrating greater thrust per muscle mass than typical biological counterparts<a href="/articles/s41586-019-1322-0#ref-CR6">6</a>. The integrated system of the vehicle together with the electronics required for untethered flight (a photovoltaic array and a signal generator) weighs 259 milligrams, with an additional payload capacity allowing for additional onboard devices. Consuming only 110–120 milliwatts of power, the system matches the thrust efficiency of similarly sized insects such as bees<a href="/articles/s41586-019-1322-0#ref-CR7">7</a>. This insect-scale aerial vehicle is the lightest thus far to achieve sustained untethered flight (as opposed to impulsive jumping<a href="/articles/s41586-019-1322-0#ref-CR8">8</a> or liftoff<a href="/articles/s41586-019-1322-0#ref-CR9">9</a>).

Towards the Long-Endurance Flight of an Insect-Inspired, Tailless, Two-Winged, Flapping-Wing Flying Robot

A Sub-100 mg Electromagnetically Driven Insect-inspired Flapping-wing Micro Robot Capable of Liftoff and Control Torques Modulation

Untethered flight of an insect-sized flapping-wing microscale aerial vehicle

An All Servo-Driven Bird-Like Flapping-Wing Aerial Robot Capable of Autonomous Flight

Design and Flight Performance of a Bio-Inspired Hover-Capable Flapping-Wing Micro Air Vehicle with Tail Wing

A bioinspired revolving-wing drone with passive attitude stability and efficient hovering flight

A self-sustaining wireless sensing and flight control device for beetles

Research on insect-like long endurance hovering double-wing FMAV prototype

A Bio-Inspired Flapping-Wing Robot with Cambered Wings and Its Application in Autonomous Airdrop

Braking and Body Angles Control of an Insect-Computer Hybrid Robot by Electrical Stimulation of Beetle Flight Muscle in Free Flight

Crawl and Fly: A Bio-Inspired Robot Utilizing Unified Actuation for Hybrid Aerial-Terrestrial Locomotion

A Review Of Fabrication Options And Power Electronics For Flapping-Wing Robotic Insects

Design and Optimization of a Pigeon-Inspired Flapping-Wing Robot

An Aerial-Wall Robotic Insect That Can Land, Climb, and Take Off from Vertical Surfaces

Liftoff of an Electromagnetically Driven Insect-Inspired Flapping-Wing Robot

Repeatable Energy-Efficient Perching for Flapping-Wing Robots Using Soft Grippers

Design and Analysis of an Untethered Micro Flapping Robot Which Can Glide on the Water

A review: Learning from the flight of beetles

Flight of the RoboBee

Feedback Control-Based Navigation of a Flying Insect-Machine Hybrid Robot.

A Multi-Chip System Optimized for Insect-Scale Flapping-Wing Robots