Capacitors Voltage Ripple Complementary Control on Three-Level Boost Fed Single-Phase VSI With Enhanced Power Decoupling Capability

Yan Zhang,Yanfei Huang,Peng Fang,Xiaoyang Gao,Yue Yang,Jinjun Liu

DOI: https://doi.org/10.1109/tpel.2021.3072869

IF: 5.967

2021-12-01

IEEE Transactions on Power Electronics

Abstract:Power decoupling is always a strong desire for single-phase voltage source inverter (VSI) due to the inherent double-line (2ω) frequency ripple caused by the instantaneous power unbalance between dc- and ac-side. The existing solutions either apply a large capacitor or employ a small power converter to compensate it, which inevitably increases the system cost and control complexity. To overcome these drawbacks, this article performs the transient modeling analysis and it reveals that 2ω frequency power component in the converter achieves minimum value when the inductor current ripple is minimized. A novel capacitors' voltage ripple complementary control algorithm based on three-level boost fed single-phase VSI is proposed. By mitigating the 2ω power component from the inductor and redistributing the stored energy between two intermediate series-connected capacitors, the oscillating power is absorbed with notably eliminated input current ripple and significantly reduced dc-link voltage ripple. Thus, the good power quality of both dc- and ac-side is guaranteed. Furthermore, the total capacitance requirement is minimized under the given dc-link ripple tolerance without any more electric stress increment and lifetime reduction. Simulation and experiment results verify the theoretical analysis and proposed control method. It is promising in applications, where both input current ripple is strictly limited and ac output voltage quality is highly required with small dc-link capacitance.

engineering, electrical & electronic

What problem does this paper attempt to address?

### Problems Addressed by the Paper

The paper primarily addresses the issue of double-frequency (2ω) oscillations caused by instantaneous power imbalance between the DC side and the AC side in single-phase voltage source inverters (VSI). Specifically:

1. **Background Problem**:
- Single-phase VSIs generate double-frequency oscillations due to instantaneous power imbalance between the DC side and the AC side.
- Existing solutions either require the use of large capacitors or small power converters for compensation, which increases system cost and control complexity.

2. **Research Objectives**:
- Propose a new capacitor voltage fluctuation complementary control algorithm based on a three-level Boost-fed single-phase VSI.
- By reducing inductor current fluctuations and redistributing energy between two series-connected intermediate capacitors, absorb oscillating power, thereby significantly reducing DC side voltage fluctuations and eliminating input current fluctuations.
- Minimize the total capacitor requirement while ensuring good power quality on both the DC side and the AC side.

3. **Core Contributions**:
- Through transient modeling analysis of the three-level Boost-fed single-phase VSI, it was found that when the inductor current fluctuation is minimized, the 2ω frequency power component is also minimized.
- The proposed control method can minimize the total capacitor requirement within the allowable range of given DC side voltage fluctuations without increasing electrical stress and lifespan loss.

In summary, the paper aims to effectively suppress the double-frequency oscillation problem in single-phase VSIs by improving the control algorithm, thereby enhancing the overall performance and reliability of the system.