Abstract:Conventional wet-process phosphoric acid (WPA) extraction route encounters unsatisfactory extraction efficiency, phosphorus yield, and raffinate utilization. Herein, a new extraction route for H3PO4 separation from wet-process superphosphoric acid (WSPA) is proposed to improve these dilemmas. We focus on the equilibrium of H3PO4 extraction by tributyl phosphate (TBP) from WSPA and the extraction mechanism of TBP under high H3PO4 loading conditions. Several critical factors affecting the extraction equilibrium were investigated to optimize the extraction process, including the initial phase ratio (R0), the volume fraction of TBP in extradant (φTBP), temperature (T), and the crosscurrent extraction stages. The results show that the single-stage extraction rate of H3PO4 reaches 70% at R0=6, φTBP=80% and T=80oC with separation factors βP/Fe, βP/Al, βP/Mg, and βP/Ca of 12.48, 21.66, 47.57, and 8.89, respectively. In addition, Fourier transform infrared spectroscopy and Raman spectroscopy enlighten the extraction mechanism at high loading conditions. The characteristic peak positions of P=O, P=O⋯H2O, and P=O⋯H3PO4 in the infrared spectra are determined to be centered at 1,283, 1,267, and 1,233 cm−1, respectively. The semi-quantitative analysis implies that the self-polymerization behavior of the extraction complex TBP·H3PO4 and the mutual attraction of reverse micelles (RMs) through their polar cores is the trigger for the formation of a third phase. Furthermore, the red shift of P-(OH)3 asymmetrical stretching vibration in the Raman spectrum indicates the formation of hydrogen bonds among H3PO4 molecules in the organic phase, which corroborates the formation of RMs. Conclusions can be obtained that H3PO4 enters the organic phase under high loading capacity by reversed micellar extraction. The feasibility of this extraction process is further tested by scrubbing, stripping, and cycling performance experiments. The results are promising for the design of a new efficient route for separating H3PO4 from WPA.

Mathematical model and reaction mechanism of molybdenum and tungsten extraction with TRPO from peroxide solution

Removal of molybdenum by TBP-TRPO extraction in sodium isopolytungstate solution

Substituent Effects of Phenanthroline-Derived Phosphine-Oxide Extractants on Extraction and Separation Performance Towards U(VI)/Th(IV)

Removal Mechanism of Mineral Impurities in Molybdenum Concentrate Treatment Process

Distributions of Hydrochloric Acid between Water and Organic Solutions of Tri- n -octylphosphine Oxide: Thermodynamic Modeling

An innovative strategy for deeply separating macro amounts of molybdenum from tungstate solutions via vulcanization step-by-step and microbubble floating-extraction: Theoretical and experimental investigation

Extraction of Ruthenium From Nitric Acid Medium by Trialkylphosphine Oxide

Theoretical study on the extraction behaviors of MoO22+ with organophosphorous extractants

Reactive extraction equilibria behavior of monocarboxylic acids by trialkyl phosphine oxide

Extraction Equilibria of Glycolic and Glyoxylic Acids with Trialkylphosphine Oxide and Trioctylamine As Extractant

Solvent Extraction of Molybdenum (VI) from Hydrochloric Acid Leach Solutions Using P507. Part I: Extraction and Mechanism

Selective Oxidation of Methanol to Dimethoxymethane over Iron and Vanadate Modified Phosphotungstate

A non-aqueous phase extraction system using tributyl phosphate for H3PO4 separation from wet-process superphosphoric acid: Extraction equilibrium and mechanism

Solvent extraction of titanium from the simulated ilmenite sulfuric acid leachate by trialkylphosphine oxide

Iron and Molybdenum Modified Phosphotungstates Towards Selective Oxidation of Styrene to Benzaldehyde

Hybrid ANN-PSO modeling and risk assessment approach of molybdenum separation from tungsten in sulfate solutions by liquid–liquid extraction process with D2EHPA

Solvent Extraction of Molybdenum (VI) from Hydrochloric Acid Leach Solutions using P507. Part II: Stripping and Mechanism

Evolution of the Chemical Form of Zirconium in Aqueous Solution During Denitration and Its Influence on Extraction by TRPO

Extraction of Glyoxylic Acid, Glycolic Acid, Acrylic Acid, and Benzoic Acid with Trialkylphosphine Oxide

EXTRACTION EQUILIBRIUM CHARACTERISTICS OF DICARBOXYLIC ACIDS WITH TRIALKYLPHOSPHINE OXIDE AS EXTRACTANT AND 1-OCTANOL AS DILUENT

Eco-friendly extraction of arsenic and tungsten from hazardous tungsten residue waste by pressure oxidation leaching in alkaline solutions: Mechanism and kinetic model.