Abstract:The incorporation of ethanol into hydrocarbon fuels for use is attracting increasing interest and it is necessary to investigate its inherent flame instability for better application in combustion units. The instability of hydrogen-methane-ethanol spherically expanding flame has been investigated at an initial temperature of 400 K, initial pressures of (2–4 bar), ethanol fraction of (20%, 50%, 80%), and equivalence ratios ( Ф ) of (0.7–1.4) using the constant volume combustion chamber (CVCC). High-speed schlieren technology was used to record flame propagation images. The effects of hydrodynamic and thermal-diffusion effect on the inherent instability of the flame were investigated. As the ethanol ratio increased, the hydrodynamic effect was enhanced. The thermal-diffusion effect was discovered to stabilize the flame surface under all conditions, as judged jointly by the effective Lewis number and the critical Lewis number. The critical conditions (critical radius and Peclet number) at the onset of unstability were evaluated, and it was found that the flames were more prone to flame instability at higher pressures. The critical Peclet number increased with the increase in the equivalence ratio when the ethanol ratio was 20%, and showed the opposite trend when the ethanol ratio was 50% and 80%. In addition, as the ethanol ratio increases, the stability of the lean mixtures flame increases, while the rich mixtures flame suffers from early onset of instability. The theoretical and experimental results were consistent, with some differences at Ф = 1.4. An empirical correlation formula for the critical Peclet number ( Pec ) and Markstein number ( M b ) was further proposed ( Pec = 18.03 M b +214.78). Finally, the Karlovitz number was used to study the instability behavior of the flame. The critical Karlovitz number ( Ka c ) decreased with increasing M b and the tendency of the flame to suffer from instability diminished, and the following correlation was obtained Kac=0.05635×e−0.13852Mb . Furthermore, the flame was more unstable in rich mixtures, this was consistent with the conclusion of instability derived from the critical radius.

Effect of initial pressure on the critical characteristics and overpressure of hydrogen-air premixed gas combustion and explosion

Experimental and Numerical Study on the Effect of Hydrogen Addition on Laminar Burning Velocity of Ethanol-Air Mixtures

Investigation of cellular characteristics of hydrogen-ethanol flame at elevated temperatures and pressures

Laminar burning Velocities, Markstein numbers and cellular instability of spherically propagation Ethane/Hydrogen/Air premixed flames at elevated pressures

Effect of hydrogen addition on explosion characteristics of premixed methane/air mixture under different equivalence ratio distributions

Investigation on Hydrogen/ethanol Intrinsic Flame Instability

The effects of different equivalence ratios and initial pressures on the explosion of methane/air premixed gas in closed space

Propagation characteristics and inherent instability of hydrogen-air premixed flame with inert gas dilution

Investigation of cellularization characteristics of hydrogen-methane-ethanol expanding spherical flame at elevated pressures

Characteristics of Explosion Hazards in Methane–Air Mixtures Diluted by Hydrogen

Laminar Combustion Characteristics of Premixed Shale Gas and Air Flames

Effects of hydrogen addition on the explosion venting characteristics of hydrogen-propane-air mixtures

Study on Combustion Characteristics of Natural Gas-Hydrogen-Air Mixtures

Effects of Hydrogen Fraction on Explosion Characteristics of Hydrogen/Methane/ Air in a Vented Chamber

Effect of concentration, obstacles, and ignition location on the explosion overpressure of hydrogen-air in a closed-vessel

Study on the explosion characteristics and flame propagation of hydrogen-methane-air mixtures in a closed vessel

Flame acceleration, detonation limit and heat loss for hydrogen-oxygen mixture at cryogenic temperature of 77 K

Experimental and numerical study of the effect of elevated pressure on laminar burning velocity of lean H2/CO/O2/diluents flames

On the Equivalent Effect of Initial Temperature and Pressure Coupling on the Flame Speed of Methane Premixed Combustion under Dilution

The effect of open-end ignition at different positions on the explosion behaviors of H 2 /CO/Air in variable cross-section pipe

Effect of Turbulence and Diffusional–Thermal Instability on Hydrogen‐Rich Syngas Turbulent Premixed Flame