Abstract:BackgroundLignocellulosic biomass, such as corn stover, is a potential raw material for ethanol production. One step in the process of producing ethanol from lignocellulose is enzymatic hydrolysis, which produces fermentable sugars from carbohydrates present in the corn stover in the form of cellulose and hemicellulose. A pretreatment step is crucial to achieve efficient conversion of lignocellulosic biomass to soluble sugars, and later ethanol. This study has investigated steam pretreatment of corn stover, with and without sulphuric acid as catalyst, and examined the effect of residence time (5–10 min) and temperature (190–210°C) on glucose and xylose recovery. The pretreatment conditions with and without dilute acid that gave the highest glucose yield were then used in subsequent experiments. Materials pretreated at the optimal conditions were subjected to simultaneous saccharification and fermentation (SSF) to produce ethanol, and remaining organic compounds were used to produce biogas by anaerobic digestion (AD).ResultsThe highest glucose yield achieved was 86%, obtained after pretreatment at 210°C for 10 minutes in the absence of catalyst, followed by enzymatic hydrolysis. The highest yield using sulphuric acid, 78%, was achieved using pretreatment at 200°C for 10 minutes. These two pretreatment conditions were investigated using two different process configurations. The highest ethanol and methane yields were obtained from the material pretreated in the presence of sulphuric acid. The slurry in this case was split into a solid fraction and a liquid fraction, where the solid fraction was used to produce ethanol and the liquid fraction to produce biogas. The total energy recovery in this case was 86% of the enthalpy of combustion energy in corn stover.ConclusionsThe highest yield, comprising ethanol, methane and solids, was achieved using pretreatment in the presence of sulphuric acid followed by a process configuration in which the slurry from the pretreatment was divided into a solid fraction and a liquid fraction. The solid fraction was subjected to SSF, while the liquid fraction, together with the filtered residual from SSF, was used in AD. Using sulphuric acid in AD did not inhibit the reaction, which may be due to the low concentration of sulphuric acid used. In contrast, a pretreatment step without sulphuric acid resulted not only in higher concentrations of inhibitors, which affected the ethanol yield, but also in lower methane production.

Optimization of thermally activated persulfate pretreatment of corn straw and its effect on anaerobic digestion performance and stability

Fungal Pretreatment of Rice Straw with Pleurotus Ostreatus and Trichoderma Reesei to Enhance Methane Production under Solid-State Anaerobic Digestion

Combinations of Fungal and Milling Pretreatments for Enhancing Rice Straw Biogas Production During Solid-State Anaerobic Digestion.

Effect of hydrothermal and Ca(OH)2 pretreatments on anaerobic digestion of sugarcane bagasse for biogas production.

Pretreatment of Sophora flavescens residues to produce fermentable sugars for lactic acid production: Optimization and mechanism analysis

Comparison of Hydrogen Peroxide and Ammonia Pretreatment of Corn Stover: Solid Recovery, Composition Changes, and Enzymatic Hydrolysis

Efficient decomposition of lignocellulose and improved composting performances driven by thermally activated persulfate based on metagenomics analysis

Experimental investigation of the straw pre-treatment to enhance its high solid anaerobic digestion]

Biological pretreatment of corn straw for enhancing degradation efficiency and biogas production

Ethanol and biogas production after steam pretreatment of corn stover with or without the addition of sulphuric acid

Effects of different pretreatment methods on biogas production and microbial community in anaerobic digestion of wheat straw

Comprehensive insights into the impact of pretreatment on anaerobic digestion of waste active sludge from perspectives of organic matter composition, thermodynamics, and multi-omics

Optimization of mixed microbes pretreatment on corn straw for enhancing methane production

Optimization of Sodium Hydroxide Pretreatment Conditions to Improve Biogas Production from Asparagus Stover

Effect of time and temperature of pretreatment and anaerobic co-digestion of rice straw and swine wastewater by domesticated paddy soil microbes

Effect of lysozyme combined with hydrothermal pretreatment on excess sludge and anaerobic digestion

Effects of Potassium Ferrate and Low-Temperature Thermal Hydrolysis Co-Pretreatment on the Hydrolysis and Anaerobic Digestion Process of Waste Activated Sludge

Sulfite altered permanganate pretreatment effects on the volatile fatty acid production during sludge anaerobic fermentation

Effect of Activated Persulfate on Gas Production from Food Waste Anaerobic Digestion

Integrated alkaline-solid/liquid separation-thermal multiple-step pretreatment of lignocellulosic biomass for biogas production enhancement

Effect of biological pretreatments in enhancing corn straw biogas production