Abstract:α-Arbutin is the fourth generation whitening factor in the field of cosmetics, which can block the synthesis of melanin in epidermal cells and has the advantages of good stability and less toxic side effects. Moreover, α-arbutin has potential application value in food, medicine, and other fields. However, the extraction yield from plant tissues is relatively low, which restricts its application value. Currently, enzymatic catalysis is universally deemed the safest and most efficient method for α-arbutin synthesis. Amylosucrase (ASase), one of the most frequently employed glycosyltransferases, has been extensively reported for α-arbutin synthesis. To discover new resources of amylosucrase (ASase), this study synthesized α-arbutin using low-cost sucrose as a glycosyl donor. Probe sequences were used to identify homologous sequences from different microbial strains in protein databases as candidate ASases. Recombinant plasmids were constructed, and the enzymes were successfully expressed in Escherichia coli, followed by the enzymatic synthesis of α-arbutin. One ASase from Calidithermus terrae, named CtAs, was selected for its effective α-arbutin synthesis. The expression conditions for CtAs were optimized, its enzymatic properties were analyzed, and the conditions for the enzymatic synthesis of α-arbutin were further refined to improve its molar yield. The optimal induction conditions for CtA expression were achieved by adding IPTG at a final concentration of 0.5 mmol/L to LB medium when OD600 reached 1.0, followed by an incubation at 20 °C and 200 r/min for 18 h. The optimal temperature and pH for CtAs were found to be 42 °C and 9.5, respectively, with good stability across the pH range of 5.0–12.0. CtAs was activated by Na+, K+, Mg2+, EDTA, methanol, and ethanol, but inhibited by Ca2+, Zn2+, Ba2+, and Ni2+. The kinetic parameters were Vmax = 6.94 μmol/min/mL, Km = 89.39 mmol/L, Kcat= 5183.97 min−1, and Kcat/Km = 57.99 L/(mmol·min). At 42 °C and pH 9.5, the hydrolysis/polymerization/isomerization reaction ratios were 23.27:32.96:43.77 with low sucrose concentrations and 38.50:37.12:24.38 with high sucrose concentrations. The optimal conditions for the enzymatic synthesis were determined to be at 25 °C and pH 5.0 using sucrose at a final concentration of 42 mmol/L and hydroquinone at 6 mmol/L (donor-to-acceptor ratio of 7:1), with the addition of 200 μL (0.2 mg/mL) of purified enzyme and 0.10 mmol/L ascorbic acid, under dark conditions for 6 h. The final molar yield of α-arbutin was 62.78%, with a molar conversion rate of hydroquinone of 74.60%, nearly doubling the yield compared to pre-optimization.

Production of 2-O-α-d-glucopyranosyl-l-ascorbic acid using sucrose phosphorylase by semi-rational design

Identification of Process-Related Impurities and Corresponding Control Strategy in Biocatalytic Production of 2-<i>O</i>--D-Glucopyranosyl-L-ascorbic Acid Using Sucrose Phosphorylase

Enhancing regioselectivity of sucrose phosphorylase by loop engineering for glycosylation of L-ascorbic acid

Optimization of Whole-cell Synthesis of AA-2G by Sucrose Phosphorylase

Promoter engineering for efficient production of sucrose phosphorylase in Bacillus subtilis and its application in enzymatic synthesis of 2-O-α-D-glucopyranosyl-L-ascorbic acid

Increased yield of 2‐<i>O</i>‐α‐<scp>d</scp>‐glucopyranosyl‐<scp>l</scp>‐ascorbic acid synthesis by α‐glucosidase using rational design that regulating the ground state of enzyme and substrate complex

Rational design of α-glucosidase for the synthesis of 2-O-α-D-glucopyranosyl-L-ascorbic acid

Sucrose phosphorylase from Lactobacillus reuteri: Characterization and application of enzyme for production of 2-O-α-d-glucopyranosyl glycerol

Efficient 2-O--D-glucopyranosyl-sn-glycerol production by single whole-cell biotransformation through combined engineering and expression regulation with novel sucrose phosphorylase from <i>Leuconostoc mesenteroides</i> ATCC 8293

Increased yield of 2-O-α-D-glucopyranosyl-l-ascorbic acid synthesis by α-glucosidase using rational design that regulating the ground state of enzyme and substrate complex.

2-O-α-D-glucosyl glycerol production by whole-cell biocatalyst of lactobacilli encapsulating sucrose phosphorylase with improved glycerol affinity and conversion rate

Robust enhancing stability and fructose tolerance of sucrose phosphorylase by immobilization on Ni-NTA functionalized agarose microspheres for the biosynthesis of 2-α-glucosylglycerol

Characterization of a novel sucrose phosphorylase from Paenibacillus elgii and its use in biosynthesis of α-arbutin

Comparison of Three Α-Glucosidases from Different Sources in the Synthesis of L-ascorbic Acid 2-Glucoside

Purification of Sucrose Phosphorylase and Enzymatic Synthesis of α-arbutin

Mining and Characterization of Amylosucrase from Calidithermus terrae for Synthesis of α-Arbutin Using Sucrose

Spatially sequential co-immobilization of phosphorylases in tiny environments and its application in the synthesis of glucosyl glycerol

2-O-D-glucopyranosyl-L-ascorbic acid: Properties, production, and potential application as a substitute for L-ascorbic acid

Comparative Analysis of L-sorbose Dehydrogenase by Docking Strategy for 2-Keto-l-gulonic Acid Production in Ketogulonicigenium Vulgare and Bacillus Endophyticus Consortium.

Identification and Characterization of a Novel High-Activity Amylosucrase from Salinispirillum Sp. LH10-3-1

Optimization of Enzymatic Synthesis of L-ascorbyl Palmitate by Solvent Engineering and Statistical Experimental Designs