Abstract:The evaporation of aviation kerosene droplets in the aeroengine combustion chamber is one of the basic processes during liquid fuel combustion, which directly affects fuel atomization, air-fuel mixture formation and the combustion quality. However, the data are rarely reported due to the difficulty of conducting experiments in high temperature and pressure conditions. In this study, a series of experiments were carried out to investigate the evaporation characteristics of RP-3 aviation kerosene droplet. The environmental pressure and temperature of droplet evaporation ranged from 1 and 20 bar and 400 and 600 °C respectively. An individual RP-3 kerosene droplet with initial diameter between 0.9 and 1.1 mm was suspended at a thermocouple bead with 50 μm diameter to measure droplet temperature. Droplet diameter during the whole evaporation process was recorded simultaneously by a high-speed camera. Experimental results indicated that at lower evaporation rate, RP-3 kerosene droplet evaporation experienced two processes: transient heating and equilibrium evaporation periods. While under high evaporation rates, the droplet only underwent equilibrium evaporation period without droplet expansion. At all the studied temperatures, droplet temperature kept increasing during the entire evaporation process without reaching a stable temperature. In most cases, the transient evaporation rate ( K ) of RP-3 kerosene droplet first increased rapidly until reaching the peak, and then followed by a monotonous decrease. However, at 20 bar above 500 °C conditions, the temporal K curve exhibited a double-peak feature. Above the critical temperature of the fuel, increasing ambient pressure and temperature both can promote the heating and evaporation. However, the promotion of increasing ambient temperature to droplet evaporation was weakened at high ambient pressure. The quantitative correlations of droplet lifetime and evaporation rate constant with pressure were proposed under different ambient temperatures.

Ignition, puffing and sooting characteristics of kerosene droplet combustion under sub-atmospheric pressure

Effect of Pressure on Burning and Soot Characteristics of RP-3 Kerosene Droplets under Sub-Atmospheric Pressure

Evaporation, Autoignition and Micro-Explosion Characteristics of RP-3 Kerosene Droplets under Sub-Atmospheric Pressure and Elevated Temperature

Interactive Effects in Two-Droplets Combustion of RP-3 Kerosene under Sub-Atmospheric Pressure

Experimental Investigations on Ignition Characteristics and Engine Performance of Kerosene under Compression Ignition Condition

Experimental investigation on evaporation characteristics of RP-3 aviation kerosene droplet above the critical temperature under various pressure conditions

Shock Tube Study on Auto-Ignition Characteristics of Kerosene/air Mixtures

Ignition of a Single Lubricating Oil Droplet in Combustible Ambient Gaseous Mixture under High-Temperature and High-Pressure Conditions

Influence of Low Fuel Temperature and Insufficient Air on Flame Structure of Rp-3 Kerosene Swirling Spray Combustion

Experimental study on puffing, auto-ignition and combustion characteristics of an n-pentanol-diesel droplet

Study on Ignition Delay of Kerosene Aerosol in Shock Tube

Ignition delay characteristics of RP-3 under ultra-low pressure (0.01–0.1 MPa)

Evaporation and Combustion Characteristics of Hydrocarbon Fuel Droplet in Sub- and Super-Critical Environments

Laminar Burning Speed of Aviation Kerosene at Low Pressures

Experimental Study of Ignition Behaviors of Pyrolysis Gas of Kerosene‐based Endothermic Hydrocarbon Fuel

Experimental investigation on ignition, combustion and micro-explosion of RP-3, biodiesel and ethanol blended droplets

An Experimental Study on the Phenomena Inside the Burning Aviation Kerosene Droplet

Experiment study on oil droplet induced pre-ignition in RCM

An experimental and modeling study of oxidation of real RP-3 aviation kerosene

Comparative Study of Combustion and Emissions of Kerosene (Rp-3), Kerosene-Pentanol Blends and Diesel in A Compression Ignition Engine

An experimental study on the instability of RP-3 aviation kerosene/air premixed flame