Abstract:In order to clarify the effect of particle coagulation on the heat transfer properties, the governing equations of nanofluid together with the equation for nanoparticles in the SiO2/water nanofluid flowing through a turbulent tube are solved numerically in the range of Reynolds number 3000 <= Re <= 16,000 and particle volume fraction 0.005 <= phi <= 0.04. Some results are validated by comparing with the experimental results. The effect of particle convection, diffusion, and coagulation on the pressure drop increment P, particle distribution, and heat transfer of nanofluid are analyzed. The main innovation is that it gives the effect of particle coagulation on the pressure drop, particle distribution, and heat transfer. The results showed that increment P increases with the increase in Re and phi. When inlet velocity is small, the increase in increment P caused by adding particles is relatively large, and increment P increases most obviously compared with the case of pure water when the inlet velocity is 0.589 m/s and phi is 0.004. Particle number concentration M-0 decreases along the flow direction, and M-0 near the wall is decreased to the original 2% and decreased by about 90% in the central area. M-0 increases with increasing Re but with decreasing phi, and basically presents a uniform distribution in the core area of the tube. The geometric mean diameter of particle GMD increases with increasing phi, but with decreasing Re. GMD is the minimum in the inlet area, and gradually increases along the flow direction. The geometric standard deviation of particle diameter GSD increases sharply at the inlet and decreases in the inlet area, remains almost unchanged in the whole tube, and finally decreases rapidly again at the outlet. The effects of Re and phi on the variation in GSD along the flow direction are insignificant. The values of convective heat transfer coefficient h and Nusselt number Nu are larger for nanofluids than that for pure water. h and Nu increase with the increase in Re and phi. Interestingly, the variation in phi from 0.005 to 0.04 has little effect on h and Nu.

Forced convection mass transfer from a rotating rigid spherical particle in laminar flows

Direct numerical simulation of turbulent channel flow with spanwise rotation

External mass transfer from/to a single sphere in a nonlinear uniaxial extensional creeping flow

Convective Heat Transfer Coefficient for a Rod-Like Particle in a Uniform Flow

Interface-resolved Numerical Simulations of Particle-Laden Turbulent Channel Flows with Spanwise Rotation

Fluid Flow and Convective Heat Transfer in a Rotating Helical Square Duct

Numerical Investigation on Flow and Heat Transfer of the Rotating Spherical Particle in a Supercritical Water Crossflow Environment

Fluid Flow and Mixed Convection Heat Transfer in a Rotating Curved Pipe

Direct Numerical Simulation Of Turbulent Heat Transfer In An Axially Rotating Pipe Flow - Reynolds Shear Stress And Scalar Flux Budgets

Numerical Study on the Distribution of Rodlike Particles in Laminar Flows of Power Law Fluids Past a Cylinder.

Interface-resolved Direct Numerical Simulations of the Interactions Between Neutrally Buoyant Spheroidal Particles and Turbulent Channel Flows

Lift Force on Rotating Sphere at Low Reynolds Numbers and High Rotational Speeds

Flow structure and combined free and forced convective heat transfer in rotating curved pipe

Direct Numerical Simulation of Moderate-Reynolds-Number Flow Past Arrays of Rotating Spheres

Numerical study of uniform flow over sphere at intermediate Reynolds numbers

Particle Distribution and Heat Transfer of SiO<sub>2</sub>/Water Nanofluid in the Turbulent Tube Flow

Drag Force and Heat Transfer Coefficient for Stefan Flow-Affected Non-Spherical Particles in Supercritical Water

Mixed Convection about a Horizontal Cylinder and Sphere in a Fluid-Saturated Porous Medium

Wake and Thermal Characteristics for Cross-Buoyancy Mixed Convection Around and Through a Porous Cylinder

Mixed convection flows from a revolving cylindrical cavity

Direct Numerical Simulation of Low-Reynolds-number Flow Past Arrays of Rotating Spheres