Abstract:The coalescence of drops is a fundamental process in the coarsening of emulsions. However, counter-intuitively, this coalescence process can produce a satellite, approximately half the size of the original drop, which is detrimental to the overall coarsening. This also occurs during the coalescence of bubbles, while the resulting satellite is much smaller, approximately 10 %. To understand this difference, we have conducted a set of coalescence experiments using xenon bubbles inside a pressure chamber, where we can continuously raise the pressure from 1 up to 85 atm and thereby vary the density ratio between the inner and outer fluid, from 0.005 up to unity. Using high-speed video imaging, we observe a continuous increase in satellite size as the inner density is varied from the bubble to emulsion-droplet conditions, with the most rapid changes occurring as the bubble density grows up to 15 % of that of the surrounding liquid. We propose a model that successfully relates the satellite size to the capillary wave mode responsible for its pinch-off and the overall deformations from the drainage. The wavelength of the primary wave changes during its travel to the apex, with the instantaneous speed adjusting to the local wavelength. By estimating the travel time of this wave mode on the bubble surface, we also show that the model is consistent with the experiments. This wavenumber is determined by both the global drainage as well as the interface shapes during the rapid coalescence in the neck connecting the two drops or bubbles. The rate of drainage is shown to scale with the density of the inner fluid. Empirically, we find that the pinch-off occurs when 60 % of the bubble fluid has drained from it. Numerical simulations using the volume-of-fluid method with dynamic adaptive grid refinement can reproduce these dynamics, as well as show the associated vortical structure and stirring of the coalescing fluid masses Enhanced stirring is observed for cases with second-stage pinch-offs. Numerous sub-satellites are observed when the length of the top protrusion of the drop exceeds the Rayleigh instability wavelength. We also find a parameter regime where the focusing of more than one capillary wave can pinch-off satellites. One realization shows a sequence of three pinch-offs, where the middle one pinches off a toroidal bubble.

Bubble formation during the collision of a sessile drop with a meniscus

On the Dynamics of Head-on Collision of Sessile Droplets on the Traveling Substrate

Large Bubble Entrapment During Drop Impacts on A Restricted Liquid Surface

The Instability of Monodisperse Bubbles Passing Through a Confined Geometry

Droplet Jumping: Effects of Droplet Size, Surface Structure, Pinning, and Liquid Properties.

Maximal air bubble entrainment at liquid drop impact

Short-Time Force Response during the Impact of a Droplet with Gas Bubbles

Dynamic Interaction Between a Millimeter-Sized Bubble and Surface Microbubbles in Water

Partial Coalescence from Bubbles to Drops

Jet Formation During the Gas Penetration Through a Thin Liquid Layer

Micro-bubble Morphologies Following Drop Impacts Onto a Pool Surface

Phenomena of a Drop Impact on a Restricted Liquid Surface

Initial surface deformations during impact on a liquid pool

Bubble nucleation and jetting inside a millimetric droplet

Droplet impact on immiscible liquid pool: Multi-scale dynamics of entrapped air cushion at short timescales

Coalescence of immersed droplets on a substrate

Experiment on Bubble Formation Through Dynamical Wetting Transition in a Square Capillary

Dynamics of high-speed micro-drop impact: numerical simulations and experiments at frame-to-frame times below 100 ns.

Air-in-liquid Compound Drop Impact Onto a Pool

Bouncing Drop on Liquid Film: Dynamics of Interfacial Gas Layer

Collision of liquid drops: bounce or merge?