Abstract:Wastewater treatment based on activated sludge processes faces a major challenge due to an increased number of people contributing to wastewater and changes in wastewater characteristics in regions with seasonal winter tourism. The combination of significant increases in carbon (COD) and nitrogen (N) loads by a factor of four to five within a short periode of time and low wastewater temperatures (<12 °C), represents a bottleneck in meeting essential effluent requirements. According to literature research, however, little attention has been paid to these special framework conditions for wastewater treatment. Based on this fact, a model-based simulation study of the wastewater treatment plant (WWTP) in Montafon (Austria) evaluates operational optimization approaches for the above-mentioned framework conditions and is intended to provide new insights for nitrification-optimized and energy-optimized wastewater treatment. The WWTP Montafon is designed for a COD load of 6250 kg d −1 , a daily dry weather water discharge of 12,700 m 3 d −1 and is a typical plant in a winter tourism region. The 5 studied smart operation approaches shown are a combination of two different aeration control strategies based on a time-controlled (i) or ammonia-based feedback aeration control (ABAC) (ii) for intermittent nitrification-denitrification and sludge removal control strategies based on a constant sludge concentration to 3 g L −1 (iii), a constant sludge retention time (SRT) to 20 days (iv) and a constant sludge retention time to 20 days combined with a higher level sludge concentration control to max. 3 g L −1 (v). The simulation results show that a combination of a time-controlled aeration strategy and controlling the sludge concentration to a constant 3 g L −1 is not recommended in order to comply with the emission limits. Under the mentioned influent conditions, ABAC control alone does not inevitably lead to a nitrification-optimized process and reduction in energy consumption. Sufficient nitrifying bacteria in the activated sludge are the key to a nitrification optimized process and reduction of energy consumption for aeration. Hence, a combination of an intermittent aeration control based on ammonium measurement and a constant sludge retention time to 20 days is preferable for nitrification capacity and is the most energy-efficient control strategy to obtain required COD and N effluent quality. An average energy consumption of 57–63 Wh PE 120 −1 d −1 for the aeration is to be expected for combinations of (i,iv), (ii, iii) (ii,iv) and (ii,v) which is low in relation to the influent challenges and to plants with higher wastewater temperatures (>12 °C) between 27 Wh PE 120 −1 d −1 and 121 Wh PE 120 −1 d −1 according to literature. The approach with a time-controlled intermittent aeration and a SRT to constant 20 days was implemented at the WWTP Montafon and confirms the results of the associated simulation. According to this simulation study, a 35 % increase in nitrification capacity in existing WWTPs designed as activated sludge processes can be achieved through optimized operating conditions without additional high investments.

Annual cycle of nitrogen removal by a pilot-scale subsurface horizontal flow in a constructed wetland under moderate climate

Nitrogen removal from summer to winter in a field pilot-scale multistage constructed wetland-pond system

Cold Temperature Increases Nitrate Accumulation in Pilot-Scale Surface Flow Constructed Wetlands with High Rates of Nitrogen Removal

Synergistic Long-Term Temperate Climate Nitrogen Removal Performance in Open Raceway Pond and Horizontal Subsurface Flow Constructed Wetland Operated Under Different Regimes

Side-by-side comparison of 15 pilot-scale conventional and intensified subsurface flow wetlands for treatment of domestic wastewater

Nitrogen removal performance and bacterial community analysis of a multistage step-feeding tidal flow constructed wetland

Pilot-scale evaluation of anammox-based mainstream nitrogen removal from municipal wastewater

Effect of HRT and seasons on the performance of pilot-scale horizontal subsurface flow constructed wetland to treat rural wastewater

Evapotranspiration dynamics in aerated and non-aerated subsurface flow treatment wetlands

Seasonal dynamics of anaerobic oxidation of ammonium and denitrification in a dimictic lake during the stratified spring–summer period

Long-term performance of vertical-flow and horizontal-flow constructed wetlands as affected by season, N load, and operating stage for treating nitrogen from domestic sewage

Nitrogen dynamics model for a pilot field-scale novel dewatered alum sludge cake-based constructed wetland system

Nitrogen and phosphorus removal by wetland mesocosms subjected to different hydroperiods

[Effect of Intermittent Aeration on Nitrogen Removal Efficiency in Vertical Subsurface Flow Constructed Wetland]

Nitrogen Removal from Agricultural Runoff by Full-Scale Constructed Wetland in China

Linking seasonal N2O emissions and nitrification failures to microbial dynamics in a SBR wastewater treatment plant

Greenhouse Gas Emissions From a Horizontal Subsurface Flow Constructed Wetland for Wastewater Treatment in Small Villages

Denitrifying bacterial communities in surface-flow constructed wetlands during different seasons: characteristics and relationships with environment factors

Performance of pilot-scale vertical-flow constructed wetlands in responding to variation in influent C/N ratios of simulated urban sewage

Model-based dynamic simulation study to boost the WWTP performance in winter tourism regions

Rhizosphere Microorganisms in Subsurface Flow Garden Constructed Wetland and their Influence on Nitrogen Removal Efficiency