Abstract:Background: The total contact cast (TCC) is an effective intervention to reduce plantar pressure in patients with diabetes and a plantar forefoot ulcer. The walls of the TCC have been indirectly shown to bear approximately 30 % of the plantar load. A new direct method to measure inside the TCC walls with capacitance sensors has shown that the anterodistal and posterolateral-distal regions of the lower leg bear the highest load. The objective of this study was to directly measure these two regions in patients with Diabetes and a plantar forefoot ulcer to further understand the mechanism of pressure reduction in the TCC. Methods: A TCC was applied to 17 patients with Diabetes and a plantar forefoot ulcer. TCC wall load (contact area, peak pressure and max force) at the anterodistal and posterolateral-distal regions of the lower leg were evaluated with two capacitance sensor strips measuring 90 cm(2) (pliance®, novel GmbH, Germany). Plantar load (contact area, peak pressure and max force) was measured with a capacitance sensor insole (pedar®, novel GmbH, Germany) placed inside the TCC. Both pedar® and pliance® collected data simultaneously at a sampling rate of 50Hz synchronised to heel strike. The magnitude of TCC wall load as a proportion of plantar load was calculated. The TCC walls were then removed to determine the differences in plantar loading between the TCC and the cut down shoe-cast for the whole foot, rearfoot, midfoot and forefoot (region of interest). Results: TCC wall load was substantial. The anterodistal lower leg recorded 48 % and the posterolateral-distal lower leg recorded 34 % of plantar contact area. The anterodistal lower leg recorded 28 % and the posterolateral-distal lower leg recorded 12 % of plantar peak pressure. The anterodistal lower leg recorded 12 % and the posterolateral-distal lower leg recorded 4 % of plantar max force. There were significant differences in plantar load between the TCC and the cut down shoe-cast for the whole foot, rearfoot, midfoot and forefoot (region of ulcer). Contact area significantly increased by 5 % beneath the whole foot, 8 % at the midfoot and 6 % at the forefoot in the shoe-cast (p < 0.05). Peak pressure significantly increased by 8 % beneath the midfoot and 13 % at the forefoot in the shoe-cast (p < 0.05). Max force significantly increased 6 % beneath the midfoot in the (shoe-cast p < 0.05). Conclusion: In patients with diabetes and a plantar forefoot ulcer, the walls of the TCC bear considerable load. Reduced plantar contact area in the TCC compared to the shoe-cast suggests that the foot is suspended by the considerable load bearing capacity of the walls of the TCC which contributes mechanically to the pressure reduction and redistribution properties of the TCC.

Plantar pressures in fiberglass total contact casts vs. a new diabetic walking boot

A comparison study of plantar foot pressure in a standardized shoe, total contact cast, and prefabricated pneumatic walking brace

The efficacy of a removable vacuum-cushioned cast replacement system in reducing plantar forefoot pressures in diabetic patients

The mechanism of plantar unloading in total contact casts: implications for design and clinical use

Therapeutic footwear can reduce plantar pressures in patients with diabetes and transmetatarsal amputation

Total contact cast wall load in patients with a plantar forefoot ulcer and diabetes

COMPARATIVE ANALYSIS OF THREE TYPES OF THERAPEUTIC OFFLOADING DIABETIC SHOES WITH CUSTOM MADE INSOLE ON PLANTAR PRESSURE DISTRIBUTION IN SEVERE DIABETIC CHARCOT FOOT

Clinical foot measurements as a proxy for plantar pressure testing in people with diabetes

Plantar pressures are higher in cases with diabetic foot ulcers compared to controls despite a longer stance phase duration

Reduction of Abnormal Foot Pressures in Diabetic Neuropathy Using a New Polymer Insole Material

Effect of different orthotic materials on plantar pressures: a systematic review

A preliminary study of decreasing the insole dynamic pressure by diabetic shoes

Comparison of in-shoe plantar pressure between Korean combat boots and running shoes

Comparison of Removable and Irremovable Walking Boot to Total Contact Casting in Offloading the Neuropathic Diabetic Foot Ulceration

The effect of calcaneus and metatarsal head offloading insoles on healthy subjects' gait kinematics, kinetics, asymmetry, and the implications for plantar pressure management: A pilot study

Optimised cushioning in diabetic footwear can significantly enhance their capacity to reduce plantar pressure

A method for automated masking and plantar pressure analysis using segmented computed tomography scans

Effects of a range of 6 prefabricated orthotic insole designs on plantar pressure in a healthy population: A randomized, open-label crossover investigation

The effect of terrain on foot pressures during walking

Effectiveness of Total Contact Orthosis for Plantar Pressure Redistribution in Neuropathic Diabetic Patients During Different Walking Activities

A Method for Diabetic Wound Specific Insole Design, Manufacturing and Biomechanical Validation for Better Recovery