Abstract:Passive solar water heaters are extensively studied and used around the world. Nevertheless, little is known about thermal stratification in their storage tank as most research on these devices reports averaged temperatures and energy conversion efficiency. Here we address the issue by analyzing the impact of the slope on thermal behavior ofthe device at low tilt angles, of particular interest for sub-tropical regions. In the present work the effect of the tilt angle on flow patterns, energy conversion efficiency and the stratification effect was studied with experimental setups and tridimensional numerical simulations as well. The study was performed using a commercial “water in glass evacuated tube solar water heater” (WGET-SWH) with nominal capacity of 40L and 8 evacuated tubes. Experiments were carried during four weeks varying the tilt angle of the collector. The data gathered during the clearest days were used to validate the tridimensional Computational Fluid Dynamics (CFD) model. The numerical model was used to study the effect of several tilt angles (10°, 27° and 45°) with the same energy input. It was found that the tilt angle has significant effect on daily solar energy gain, flow patterns inside the storage tank and stratification. Nevertheless, it was found little impact on the thermal efficiency due to the low magnitude of heat losses though the vacuum tubes. Also, 10° tilt angle allowed to achieve significant higher temperatures and thermal stratification, along with a thermal inactive area at the bottom of the tank. Conversely, the content of the storage tank for the 45° tilt angle is fully mixed at the end of the heating process. This occurred mainly due to the relative position of the tubes’ opening inside the tank and the mixing effect of the convective water flow. A non dimensional number to quantify the stratification effect is proposed and it was found an exponential dependence on the tilt angle. Some considerations regarding the use of WGET-SWHs on subtropical regions are made. No charge or discharge processes were considered in this work.

Effect of Tilt Angle Variation on the Performance of the Flat Collector Solar Thermal System (Passive Type)

Experimental Investigation of a Small-Scale Parabolic Trough Concentrated Solar Power ‎Systems

Effect of the collector tilt angle on thermal efficiency and stratification of passive water in glass evacuated tube solar water heater

A Hybrid Parabolic Trough Solar Collector System Integrated with Photovoltaics

Effects of the inclination angle on the performance of flat plate solar collector

An Optimized Model for Solar Thermal Collectors Based on Concept of Effective Heat Collection

Dynamic Simulation and Optimization of Flat Plate Solar Collector Parameters Using the MATLAB Program for Erbil-Iraq Climate Condition

Modeling and optimization of photovoltaic serpentine type thermal solar collector with thermal energy storage system for hot water and electricity generation for single residential building

Tilt Angle Optimization and Investigation of the Behavior of a Flat Plate Solar Collector Using MATLAB for Kurdistan Climate Conditions-Iraq

EXPERIMENTAL STUDY ON THERMAL PERFORMANCE OF EVACUATED TUBULAR SOLAR AIR COLLECTOR WITH INSERTED TUBES

Experimental Study of Hybrid Photovoltaic (PV/T) Thermal Solar Collector with Air Cooling for Domestic Use: A Thermal and Electrical Performances Evaluation

Experimental Study on A Heat-Pipe Photovoltaic/Thermal System

EXPERIMENTAL INVESTIGATION ON A NOVEL SOLAR PHOTOVOLTAIC/THERMAL SYSTEM WITH FLAT ALUMINOUS BOX AS COLLECTOR

Performance optimization for solar photovoltaic thermal system with spiral rectangular absorber using Taguchi method

Dynamic Performance Analysis of Photovoltaic–thermal Solar Collector with Dual Channels for Different Fluids

Experimental Analysis of a Novel Solar PV/T Collector

Performance Analysis and Multi-Objective Optimization of a Hybrid Photovoltaic/thermal Collector for Domestic Hot Water Application

A Parametric Study on the Performance Characteristics of an Evacuated Flat-Plate Photovoltaic/thermal (PV/T) Collector

Optimum tilt and azimuth angles of heat pipe solar collector, an experimental approach

A sensitivity study of a hybrid photovoltaic/thermal water-heating system with natural circulation

Simulation and Experiment on Thermal Performance of a Micro-Channel Heat Pipe under Different Evaporator Temperatures and Tilt Angles