Abstract:Experiments are conducted in a water tunnel to investigate the near-field interaction of an inclined jet with a crossflow over a flat plate. The tunnel contains a jet emerging from a round pipe inclined at a 30° angle to the streamwise direction of the crossflow. The flow structures induced by the inclined jet are examined with laser-induced fluorescence (LIF) visualization and time-resolved particle image velocimetry (TR-PIV). The behaviors of the near-field flow are compared at four different jet-to-cross-flow velocity ratios (VRs): 0.25, 0.5, 0.75, and 1.0. It is found that the inclined configuration significantly weakens the interaction between the jet and the crossflow, especially at lower VRs. As such, at VR ≤0.5 (typically at VR = 0.25), the inclined jet-in-crossflow (JICF) behaves differently from a highly unsteady normal JICF at low VRs. The flow patterns are relatively simple and only weakly unsteady. A counter-rotating vortex pair (CRVP) is well observed. As VR increases up to 1.0, the inclined JICF fully detaches from the flat plate and shows the classical topology of the normal JICF at high VRs. Both CRVP and shear layer vortices are well captured in this highly unsteady flow regime. The different flow structures together with the interaction between the inclined jet and the crossflow near the jet exit are found to have a strong impact on the distribution of jet-shear layer, jet trajectory, and the jet influence on the crossflow, especially on the near-wall region. Proper orthogonal decomposition is performed on the TR-PIV results to extract the dominant fluctuating modes and reconstruct phase-averaged flow fields. It is found that the highly unsteady flow regime at VR = 1.0 is very unstable, varying between two flow patterns with different fluctuating frequencies at downstream of the jet column. The jet flow near to the exit is also found to be remarkably unsteady due to the interaction between the emerging jet and the crossflow.

Evolution of liquid film in a crossflow tunnel: Liquid film thickness measurement and effect of droplet impingement on film breakup

Simultaneous Measurements of Velocity and Concentration Fields in an Inclined Jet in Crossflow

Spray Trajectory and 3D Droplets Distribution of Liquid Jet in Crossflow with Digital Inline Holography

The Liquid Film Behaviors Created by an Inclined Jet Impinging on a Vertical Wall

A novel laser interferometric method for thin film thickness measurement in gas-liquid intermittent flow

A Comparative Study on the Breakup of Newtonian and Viscoelastic Liquid Films

Interaction of liquid films formed by two continuous jets impinging obliquely on a vertical wall

Experimental Study on Gas-Liquid Flow Characteristics of Submerged Air Jets

Thin liquid film flow and heat transfer under spray impingement

The breakup and instability structures of liquid jets in subsonic crossflows

Measurement of Falling Film Thickness Around a Horizontal Tube Using Laser-Induced Fluorescence Technique

Study on the film thickness and surface wave velocity of the thin liquid film formed by a round jet obliquely impinging on a horizontal plate

Film Breakup of Tilted Impinging Spray under Various Pressure Conditions

Liquid film dispersion on horizontal circular tubes under spray impingement

Impact of Liquid Crossflow on the Discharge Coefficient of a Gas Jet Hole on a Flat Plate

Numerical Study On Liquid Droplet Formation In T-Junction Microchannel

Experimental Study on Interfacial Film Dynamics of Oscillating Multiphase Micro Flows

Measurements of Liquid Film Thickness of Gas-Liquid Two Phase Flow Inside a Micropipe

EXPERIMENTAL STUDY ON SPRAY MICROSCOPIC CHARACTERISTICS IN CROSS FLOW: DROPLET MORPHOLOGY, STATISTICS AND BREAKUP

Measurement and theoretical analysis of transient liquid film during micro-channel flow boiling

Near-field Interaction of an Inclined Jet with a Crossflow: LIF Visualization and TR-PIV Measurement