Abstract:The development of continuous flow reactors (CFRs) employing aerobic granular sludge (AGS) for the retrofit of existing wastewater treatment plants (WWTPs) using a continuous-flow activated sludge (CFAS) system has garnered increasing interest. This follows the worldwide adoption of AGS technology in sequencing batch reactors (SBRs). The better settleability of AGS compared to AS allows for process intensification of existing wastewater treatment plants without the difficult conversion of often relatively shallow CFRs to deeper AGS-SBRs. To retrofit existing CFAS systems with AGS, achieving both increased hydraulic capacity and enhanced biological nutrient removal necessitates the formation of granular sludge based on the same selective pressures applied in AGS-SBRs. Previous efforts have focussed mainly on the selective wasting of flocculent sludge and retaining granular sludge to drive aerobic granulation. In this study a pilot-scale CFR was developed to best mimic the implementation of the granulation mechanisms of full-scale AGS-SBRs. The pilot-scale reactor was fed with pre-settled municipal wastewater. We established metrics to assess the degree to which the proposed mechanisms were implemented in the pilot-scale CFR and compared them to data from full-scale AGS-SBRs, specifically with respect to the anaerobic distribution of granule forming substrates (GFS). The selective pressures for granular sludge formation were implemented through inclusion of anaerobic upflow selectors with a water depth of 2.5 meters, which yielded a sludge with properties similar to AGS from full-scale SBRs. In comparison to the CFAS system at Harnaschpolder WWTP treating the same pre-settled wastewater, a more than twofold increase in volumetric removal capacity for both phosphorus and nitrogen was achieved. The use of a completely mixed anaerobic selector, as opposed to an anaerobic upflow selector, caused a shift in EBPR activity from the largest towards the smallest size class, while nitrification was majorly unaffected. Anaerobic selective feeding via bottom-feeding is, therefore, favorable for the long-term stability of AGS, especially for less acidified wastewater. The research underlines the potential of AGS for enhancing the hydraulic and biological treatment capacity of existing CFAS systems.

Coupling of Fe-C and aerobic granular sludge to treat refractory wastewater from a membrane manufacturer in a pilot-scale system

A Case for Aerobic Sludge Granulation: from Pilot to Full Scale

Rapid aerobic sludge granulation in an integrated oxidation ditch with two-zone clarifiers.

Formation of Aerobic Granular in Pilot-scale SBR for Real Wastewater Treatment

Filterability and Extracellular Polymeric Substances of Aerobic Granules for AGMBR Process

Integrated Aerobic Granular Sludge and Membrane Process for Enabling Municipal Wastewater Treatment and Reuse Water Production

Rapid granulation of aerobic sludge in a continuous-flow reactor with a two-zone sedimentation tank by the addition of dewatered sludge

Improving aerobic sludge granulation in sequential batch reactor by natural drying: Effluent sludge recovery and feeding back into reactor

Aerobic Sludge Granulation in a Full-Scale Sequencing Batch Reactor

Treatment Of Synthetic Wastewater By Combining Submerged Mbr Technology And Aerobic Granular Technology

Full-scale upgrade activated sludge to continuous-flow aerobic granular sludge: Implementing microaerobic-aerobic configuration with internal separators

Cultivating aerobic granular sludge in a developed continuous-flow reactor with two-zone sedimentation tank treating real and low-strength wastewater

Aerobic Granular Sludge Cultivated from Fe-loaded Activated Carbon As Carrier Working Low-Strength Wastewater Conditions by Bioreactor.

Feasibility Study of Applying Anaerobic Step-Feeding Mode for the Treatment of High-Strength Wastewater in Granular Sequencing Batch Reactors (GSBRs)

Utilizing anaerobic substrate distribution for growth of aerobic granular sludge in continuous-flow reactors

Enhanced aerobic granulation for treating low-strength wastewater in an anaerobic-aerobic-anoxic sequencing batch reactor by selecting slow-growing organisms and adding carriers

Aerobic Granular Sludge Operation and Nutrients Removal Mechanism in a Novel Configuration Reactor Combined Sequencing Batch Reactor and Continuous-Flow Reactor.

Continuous flow aerobic granular sludge: recent developments and applications

Study on rapid formation of aerobic granular sludge promoted by addition of Fe2+

Rapid static feeding combined with Fe2+ addition for improving the formation and stability of aerobic granular sludge in low-strength wastewater

Fast Granulation by Combining External Sludge Conditioning with FeCl3 Addition and Reintroducing into an SBR