Abstract:Abstract Phase transitions of CO2-Hydrocarbons in liquid rich shale (LRS) volatile oil reservoirs after the CO2 pre-pad energized fracturing is quite obvious, particularly due to the impact of temperature changes and nano-confinement. In this paper, the impact of phase transitions caused by heat transfer and nano-confinement effects on the CO2 effective diffusion coefficient (CO2-EDC) after CO2 pre-pad energized fracturing was investigated. A novel multi-component diffusion model incorporating both heat transfer and nano-confinement effects was proposed to accurately evaluate CO2-EDC in the Gulong LRS volatile oil reservoir located in the Songliao Basin, China, which provides valuable insights into fracturing design and CO2-EOR in shale oil reservoirs. Firstly, the nano-pore network model (PNM) was constructed based on focused ion beam scanning electron microscopy (FIB-SEM). Secondly, components of oil samples were analyzed by chromatographic experiments. Then, the temperature in each pore-throat was calculated using Fourier heat transfer equations. In addition, phase states (liquid or vapor) of CO2-hydrocarbons in each pore-throat were determined by the modified PR-EOS considering nano-confinement effects, and diffusion mechanisms (Knudsen, Transition, Maxwell-Stefan diffusion) were determined by the Knudsen number. Finally, the novel PNM with multi-scale diffusion equations was established to calculate the molar flow rate, which is used to obtain CO2-EDC by solving Fick's law. The phase behavior of CO2-hydrocarbons in the nano-confined pores was investigated, and the CO2-EDC was calculated under reservoir conditions (137.5 ℃, 37 MPa), and at varying injection temperatures. The results show that three distinct phase behaviors considering nano-confinement effects were observed under reservoir conditions: volatile oil in pore-throats larger than 33nm, condensate gas in pore-throats ranging from 5nm to 33nm, and wet gas or dry gas in pores/throats smaller than 5nm. However, it is only liquid in each pore-throat without considering the nano-confinement effects. As temperature increased, the phase behavior of CO2-hydrocarbons underwent a gradual transformation from a liquid state to a state of vapor-liquid coexistence, and finally to a vapor state. The phase transition is proved by the observation of a 2-month single gas production period prior to oil-gas production and a rapid decline in GOR (from 3559.7 m3/m3 to 318.5 m3/m3) followed by a period of stability in the Gulong LRS volatile oil reservoir. It is worth noting that the CO2-EDC increased significantly with the nano-confinement effects, rising by 896.96% from 0 ℃ to 300 ℃ compared to an increase of 10.31% without the nano-confinement effects. Specifically, the CO2-EDC increased slowly in the liquid-dominated stage (< 180 ℃) and rapidly rose in the vapor-dominated stage (> 180 ℃).

Diffusion and Dissolution Behaviors of CO 2 , CH 4 , and N 2 in Heavy Oil under High-Temperature and -Pressure Conditions: Insights into Heavy Oil Production via Multithermal Fluid Stimulation

Research and performance evaluation of CO2 solubilization synergist for heavy oil

New Insights into the Interfacial Phenomena during Miscible Displacement by Hydrocarbon Solvents and CO2 in Heavy Oil Reservoirs

Quantification of preferential and mutual mass transfer of gases-light oil systems at high pressures and elevated temperatures by dynamic volume analysis

Molecular Insights into CO2 Diffusion Behavior in Crude Oil

Determination of Concentration-Dependent Effective Diffusivity of Each Gas Component of a Binary Mixture in Porous Media Saturated with Heavy Oil under Reservoir Conditions

Molecular Dynamics Study on the Diffusion Mass Transfer Behaviour of CO2 and Crude Oil in Fluids Produced via CO2 Flooding

Structure–Solubility Relationship of CO Dispersion in Model Hydrocarbon Liquids and Heavy Oil Fractions

Miscibility of light oil and flue gas under thermal action

Theoretical Insight into the Effect of Steam Temperature on Heavy Oil/Steam Interface Behaviors Using Molecular Dynamics Simulation

Evolution of the Properties and Composition of Heavy Oil by Injecting Dry Boiler Flue Gas

Research on molecular mechanism and prediction model of viscosity reduction of heavy oil by different types of gas

Enhanced Solubility and Miscibility of CO2-Oil Mixture in the Presence of Propane under Reservoir Conditions to Improve Recovery Efficiency

Molecular dynamics simulation of CO2 dissolution-diffusion in multi-component crude oil

Miscibility Process Of Hydrocarbon Mixture Gas And Crude Oil: Insights From Molecular Dynamics

Solvent Exsolution and Liberation from Different Heavy Oil–Solvent Systems in Bulk Phases and Porous Media: A Comparison Study

Effects of Nano-Confinement and Heat Transfer on Phase Transition and Multi-Component Diffusion of CO2-Hydrocarbons During the Flowback and Early-Production Stages: A Field Example from a Liquid-Rich Shale Volatile Oil Reservoir

Improved fluid characterization and phase behavior approaches for gas flooding and application on Tahe light crude oil system

Research on the Phase Behavior of Multi-Component Thermal-Fluid-Heavy Oil Systems

CO2 Convective Dissolution in Oil-Saturated Unconsolidated Porous Media at Reservoir Conditions

Molecular Dynamics Simulation of Heavy Oil Dissolution in Supercritical Water and Multi-Component Thermal Fluid