Abstract:The effect of fortifying reconstituted skim milk with increasing levels of the beta-lactoglobulin (beta-LG) genetic variants A, B, and an A-B mixture on rennet-induced gelation was studied by small deformation-sensitive rheology. Free-zone capillary electrophoresis and high-sensitivity oscillatory rheology were used to elucidate the role of potential heterotypic associative interactions between whey proteins and casein in a mixed colloidal system, subjected to moderate heating (65 degrees C for 30 min) prior to renneting, on the gelling properties of the system. Increasing levels of added whey protein, in the concentration range of 0.225 to 1.35% of added protein, led to a concomitant progressive increase in the equilibrium shear storage modulus, G' (recorded after approximately 10,800 s), in the order beta-LG B > beta-LG A and beta-LG A-B, as the general expected consequence of the setup of denser casein gel networks. The preferential effect of beta-LG B over beta-LG A on the mechanical strength of the gels may be due to the formation of cross-links and aggregates involving whey proteins and rennet hydrolysis products or an increase in the size of the casein micelle caused by the grafting of beta-LG B to its surface, or both. The results of free-zone capillary electrophoresis were consistent with the notion that beta-LG B (and not beta-LG A) binds to the casein micelle under an optimal stoichiometry of 1:0.045 (mg/mg), even in the absence of heat treatment. The liquid-like character of the gel networks formed, tan delta, was a parameter sensitive to the level of addition of beta-LG A in particular. At low concentrations (up to 0.45%) of beta-LG A, tan delta increased by almost twice as much, which was interpreted as a result of the increase in the loss modulus, G'', of the sol fraction because of the presence of unbound beta-LG A. At greater incremental concentrations of beta-LG (>0.45%), the formation of smaller whey protein aggregates confined to the sol fraction may have led to a progressive decrease in tan delta. The critical gel time, t(gel), was also affected by the concentration of added whey protein and described 3 zones of behavior, irrespective of the type of whey protein variant. The critical gel time was slightly shorter for beta-LG B than for beta-LG A at 0.45% of added whey protein, but this difference became larger at 0.67%. Even when only beta-LG B was found to associate with casein prior to renneting, both beta-LG A and beta-LG B, either alone or mixed, had a profound influence on the mechanical strength and coagulation kinetics of the rennet-induced casein gels. This knowledge is expected to be useful to exert better control and optimize processing conditions during the manufacturing of cheese and cheese analogs.

Strength of Rennet Curd Made from Milk and Chemically Modified Soy Proteins

Rheological, Physicochemical, Microbiological, and Aroma Characteristics of Sour Creams Supplemented with Milk Protein Concentrate

Differences in Several Important Proteins Contents Between Raw Milk and Reconstituted Milk

Characterizing acidified and renneted gels with different soy milk and skim milk proportions

QUALITY OF PROTEIN IN MILK REPLACERS FOR YOUNG CALVES. IV. RENNET (CHYMOSIN, RENNIN) COAGULATION OF RECONSTITUTED SKIM MILK POWDER CONTAINING ADDED PROTEINS, FAT, CALCIUM, PHOSPHATE AND CITRATE

Effect of Enzyme Modified Soymilk on Rennet Induced Gelation of Skim Milk

Effect of konjac glucomannan and soy soluble polysaccharides on the rheological, microstructural and syneretic properties of rennet gels

Study of the Effect of Soy Proteins on the Acid-Induced Gelation of Casein Micelles

Effect of Alkaline Treatment on the Dispersibility of Soy Protein Isolates and Properties of Milk Clots formed from Nonfat Milk and Treated Soy Protein Mixtures

Effect of β-Lactoglobulin A and B Whey Protein Variants on the Rennet-Induced Gelation of Skim Milk Gels in a Model Reconstituted Skim Milk System

Amino Acid Composition of Whey and Cottage Cheese Under Various Rennet Enzymes

Cold-Renneted Milk Powders for Cheese Production: Impact of Casein/Whey Protein Ratio and Heat on the Gelling Behavior of Reconstituted Rennet Gels and on the Survival Rate of Integrated Lactic Acid Bacteria

Effects of endogenous small molecular compounds on the rheological properties, texture and microstructure of soymilk coagulum: Removal of phytate using ultrafiltration

GELATION OF MIXTURES OF SOYMILK AND RECONSTITUTED SKIM MILK SUBJECTED TO COMBINED ACID AND RENNET

Rheological and structural properties of differently acidified and renneted milk gels

Influence of protein concentration and coagulation temperature on rennet-induced gelation characteristics and curd microstructure

Aggregation and gelation of soymilk protein after alkaline heat treatment: Effect of coagulants and their addition sequences

Dextran modulates physical properties of rennet‐induced milk gels

Physicochemical and Rheological Evaluation of Rice-Whole Soybean Curds Prepared by Microbial Transglutaminase