Abstract:Background: Formulation of a medical preparedness plan for treating severely bleeding casualties during naval deployment is a significant challenge because of territory covered during most missions. The aim of this study was to evaluate the concept of "walking blood bank" as a supportable plan for supplying safe blood and blood products. Methods: In 2013, the Royal Norwegian Navy conducted antipiracy operations from a frigate, beginning in the Gulf of Aden and ending in the Indian Ocean. Crews were on 24-hour emergency alert in preparation for an enemy assault on the frigate. Under an approved command protocol, a "walking blood bank," using crew blood donations, was established for use on board and on missions conducted in rigid-hulled inflatable boats, during which freeze-dried plasma and leukoreduced, group O low anti-A/anti-B titer, cold-stored whole blood were stored in Golden Hour Boxes. Data demonstrating the ability to collect, store, and provide whole blood were collected to establish feasibility of implementing a whole blood-focused remote damage-control resuscitation program aboard a naval vessel. In addition, ROTEM data were collected to demonstrate feasibility of performing this analysis on a large naval vessel and to also measure hemostatic efficacy of cold-stored leukoreduced whole blood (CWB) stored during a period of 14 days. ROTEM data on CWB was compared with reconstituted whole blood. Results: Drills simulating massive transfusion activation were conducted, in which 2 U of warm fresh whole blood with platelet sparing leukoreduction were produced in 40 minutes, followed by collection of two additional units at 15-minute increments. The ROTEM machine performed well during ship-rolling, as shown by the overlapping calculated and measured mechanical piston movements measured by the ROTEM device. Error messages were recorded in 4 (1.5%) of 267 tests. CWB yielded reproducible ROTEM results demonstrating preserved fibrinogen function and platelet function for at least 3.5 weeks and 2 weeks, respectively. The frequency of ROTEM tests were as follows: EXTEM (n = 88), INTEM (n = 85), FIBTEM (n = 82), and APTEM (n = 12). CWB results were grouped. Compared with Days 0 to 2, EXTEM maximum clot firmness was significantly reduced, beginning on Days 10 to 14; however, results through that date remained within reference ranges and were comparable with the EXTEM maximum clot firmness for the reconstituted whole blood samples containing Day 5 room temperature-stored platelets. Conclusion: A "walking blood bank" can provide a balanced transfusion product to support damage-control resuscitation/remote damage-control resuscitation aboard a frigate in the absence of conventional blood bank products. ROTEM analysis is feasible to monitor damage-control resuscitation and blood product quality. ROTEM analysis was possible in challenging operational conditions. Level of evidence: Therapeutic study, level V.

Feasibility evaluation of a blood rotation system for efficient blood product utilization in remote island settings

Patient rescue and blood utilization in the Ogasawara blood rotation system

Quality Control of Red Blood Cell Solutions for Transfusion Transported via Drone Flight to a Remote Island

Transfusion in limited infrastructure locations – where to go decades after safe blood initiative by World Health Organization?

Reducing Unnecessary Transfusions of RBCs in Inpatients Admitted Across Niagara Health Community Hospitals

Evaluation of a rail logistics transmission system for the transportation of blood components within a medical centre

Temperature Management of Red Blood Cell Solution Transported by Car for Transfusion at Home

An intelligent system for blood donation process optimization - smart techniques for minimizing blood wastages

S.O.S. – Save Our Supplies: Understanding reasons to tackle the challenge of wasted returned blood products

Coagulation function of stored whole blood is preserved for 14 days in austere conditions: A ROTEM feasibility study during a Norwegian antipiracy mission and comparison to equal ratio reconstituted blood

Analysis of a 5-year, evidenced-based, rational blood utilisation project in a South African regional hospital

Impact of Implementing a Standard Operating Procedure to Reduce Blood Wastage in Blood Centers of Iran

Optimal policy of ordering blood units in the hospital according to compatibility and priority transfers between blood groups under uncertainty conditions: A case study

Improving RBC inventory by optimizing preoperative ordering and eliminating crossmatch and hold

Designing an optimal model of blood logistics management with the possibility of return in the three-level blood transfusion network

Evaluating the Crossmatch-to-Transfusion Ratio as a Tool for Analyzing and Optimizing Blood Bank Resource Utilization: A Retrospective Observational Study

Pathogen reduced red blood cells as an alternative to irradiated and washed components with potential for up to 42 days storage

Analyzing RBC Transfusion Practices Using Quality Indicators: A Retrospective Transfusion Audit

Don't Break the (Blood) Bank: Can Waste Be Minimized in a Whole Blood Program?

Prehospital Blood Transfusion: A Cross-Sectional Study of Prehospital and Retrieval Medicine Services across Australia & Aotearoa-New Zealand