Abstract:We study the phase behavior of a symmetric binary polymer blend which is confined into a thin film. The film surfaces interact with the monomers via short range potentials. We calculate the phase behavior within the self-consistent field theory of Gaussian chains. Over a wide range of parameters we find strong first order wetting transitions for the semi-infinite system, and the interplay between the wetting/prewetting behavior and the phase diagram in confined geometry is investigated. Antisymmetric boundaries, where one surface attracts the A component with the same strength than the opposite surface attracts the B component, are applied. The phase transition does not occur close to the bulk critical temperature but in the vicinity of the wetting transition. For very thin films or weak surface fields one finds a single critical point at $\phi_c=1/2$. For thicker films or stronger surface fields the phase diagram exhibits two critical points and two concomitant coexistence regions. Only below a triple point there is a single two phase coexistence region. When we increase the film thickness the two coexistence regions become the prewetting lines of the semi-infinite system, while the triple temperature converges towards the wetting transition temperature from above. The behavior close to the tricritical point, which separates phase diagrams with one and two critical points, is studied in the framework of a Ginzburg-Landau ansatz. Two-dimensional profiles of the interface between the laterally coexisting phases are calculated, and the interfacial and line tensions analyzed. The effect of fluctuations and corrections to the self-consistent field theory are discussed.

What problem does this paper attempt to address?

This paper mainly explores the phase behavior of symmetric binary polymer mixtures in thin films. In particular, when the film surface has antisymmetry (that is, one surface attracts component A, while the other surface attracts component B with the same intensity), it focuses on the interaction between the wetting behavior and the phase diagram. Specifically, the research focuses on: 1. **Wetting transition**: In a semi - infinite system, the researchers found a first - order strong wetting transition. This transition occurs far from the bulk critical temperature, but close to the wetting transition temperature. 2. **Features of the phase diagram**: - For very thin films or weak surface fields, the system has a single critical point at $ \varphi_c = 1/2 $. - For thicker films or stronger surface fields, two critical points and two coexistence regions appear in the phase diagram. Only below the triple point does a single two - phase coexistence region exist. - As the film thickness increases, the two coexistence regions gradually become the pre - wetting lines of the semi - infinite system, and the triple - phase temperature converges to the wetting transition temperature from above. 3. **Interface localization - delocalization transition**: The behavior near the tricritical point, which separates the phase diagrams with one and two critical points, was studied. This transition was analyzed using the Ginzburg - Landau model. 4. **Interfacial tension and line tension**: The two - dimensional interface profile between laterally coexisting phases was calculated, and the interfacial tension and line tension were analyzed. 5. **Fluctuation effects**: The influence of fluctuations on the self - consistent field theory was discussed. Through these studies, the paper aims to gain a deep understanding of the complex phase behavior of polymer mixtures under confined geometric conditions, especially the mechanisms in terms of wetting and interface localization - delocalization transitions.

A symmetric polymer blend confined into a film with antisymmetric surfaces: interplay between wetting behavior and phase diagram

Phase diagram of polymer blends in confined geometry

Interface localisation-delocalisation transition in a symmetric polymer blend: a finite-size scaling Monte Carlo study

Surface-induced Phase Transitions in Dense Nanoparticle Arrays of Lamella-Forming Diblock Copolymers

Symmetric Diblock Copolymers in Thin Films (I): Phase stability in Self-Consistent Field Calculations and Monte Carlo Simulations

Surface-directed phase separation via a two-step quench process in binary polymer mixture films with asymmetry compositions.

Phase Dynamics and Wetting Layer Formation Mechanisms of Pattern-Directed Phase Separation in Binary Polymer Mixture Films with Asymmetry Compositions

Wetting Behavior of a Three-Phase System in Contact with a Surface

The Nature of Phase Transitions of Symmetric Diblock Copolymer Melts under Confinement

Surface-induced phase transition of asymmetric diblock copolymer in selective solvents.

Microphase separation in thin block copolymer films: a weak segregation mean-field approach

Depletion-induced Surface Alignment of Asymmetric Diblock Copolymer in Selective Solvents.

Polymer Compatibility in Two Dimensions. Modeling of Phase Behavior of Mixed Polymethacrylate Langmuir Films.

Bicontinuous microemulsion in binary blends of complementary diblock copolymers

Self-Assembly Of Abc Star Triblock Copolymer Thin Films Confined With A Preferential Surface: A Self-Consistent Mean Field Theory

Surface segregation of conformationally asymmetric polymer blends

Effect of long range forces on the interfacial profiles in thin binary polymer films

Interfacial Phenomena of Solvent-diluted Block Copolymers

Three-dimensional Numerical Simulations of Lamellar Structure Via Two-Step Surface-Directed Phase Separation in Polymer Blend Films.

Phase Behavior in Thin Films of Confined Colloid-Polymer Mixtures

Reentrant ordering transition of asymmetric copolymer solution film confined between polymer-grafted surfaces.